Only show results available in Massachusetts? Ok

Filter Bags Applications

  • Premium

    Industrial monitoring solutions for the dust collectors areas

    Most industrial processes have dust collectors of some form or other, the most popular being filter bag houses. Very few of these are covered by regulation other than to have a broken bag detector to prevent nuisance dusts escaping and creating a local nuisance. The CODEL StakGard is a low cost Tribo-electric monitor that directly measures mass particulate concentration by sensing the frictional charge created when particles collide with a conductor. The advanced electronics of the StakGard detect this signal and...

    By Codel International Ltd based in Bakewell, UNITED KINGDOM.

  • Premium

    Emission control solutions for clinker cooler and pre-heater dedusting sector

    The control of clinker fines emissions after the heatexchanger, placed downstream of the clinkercooler,is usually a problem for cementplant managers. The process is characterized by high material abrasiveness, high loads and variable flow ratein normal and maximum conditions.

    By Advanced Cyclone Systems, S. A. based in Porto, PORTUGAL.

  • Premium

    Fire detection solutions for the power stations sector

    One of the main hazards in a power station is a fire in a coal rich environment; the latter can often become an explosion with consequential damage to human life and capital equipment.

    By Codel International Ltd based in Bakewell, UNITED KINGDOM.

  • Premium

    Emission control solutions for calcination processes sector

    In calcination processes, solid intermediates and products are regularly handled in the fine powder form (ex: kaolin or metakaulin). There is a need to separate these very fine powders from the exhaust streams of calciners, fluid bed dryers or incinerators, often at critical temperature conditions. For PM emission control at very high temperature ( >600 ºC), traditional bag filters following temperature exchangers or scrubbers are used as end stage dedusters.

    By Advanced Cyclone Systems, S. A. based in Porto, PORTUGAL.

  • Premium

    Emission control solutions for pyrolisis, incineration and gasification sector

    For PM emission control in very high temperature exhaust streams ( >600ºC ), such as gasification, pyrolysis and incineration, traditional bag filters following temperature exchangers, ceramic filters, or scrubbers are used as end stage dedusters. For most arrangements, a primary high temperature separator, namely a cyclone, is important to reduce as much ash and char as possible. A good efficiency is important to reduce concentration of solids to the final stage dedusters, avoiding plugging of scrubbers...

    By Advanced Cyclone Systems, S. A. based in Porto, PORTUGAL.

  • Premium

    Emission control solutions for air caption & dedusting sector

    Several industries face problems from dust released during product transportation or processing. This is the case of the Textile, Wood Processing, Mining, Ink Manufacturing and other industries. Frequently, in order to maintain an appropriate level of particles suspended in the air (usually measured in Parts per Million by Volume), dust is extracted with air in strategically positioned caption points and typically recovered in cyclones or in bag filters.

    By Advanced Cyclone Systems, S. A. based in Porto, PORTUGAL.

  • Premium

    Emission control solutions for high temperature separation & energy recovery sector

    Given the difficulties in achieving results by increasing revenues, companies are turning more and more to cutting costs. Reducing energy consumption has become the target for many companies. In sectors as the cement, particleboard manufacturing, inceneration,among others, energy is demanded mostly in the form of heat. Most companies are retrofitting their boilers and thermal oil heaters to run with biomass, instead of oil or coal, to reduce costs and become more eco-friendly. Still too, much of the generated...

    By Advanced Cyclone Systems, S. A. based in Porto, PORTUGAL.

  • Premium

    Product recovery solutions for pharmaceutical ingredients industry

    Efficient recovery of active pharmaceutical ingredients (APIs), chemical substances or food powders after drying applications such as sprayand fluid bed dryingis frequently a problem. The same problem occurs in many milling and micronization applications. The preferred way to recover these sensitive and expensive products is with cyclone collectors due to their direct powder capture. Unlike bag filters or wet scrubbers, cyclones minimize filter or product contamination and product cross contamination and can...

    By Advanced Cyclone Systems, S. A. based in Porto, PORTUGAL.

  • Premium

    Product recovery solutions for chemicals industry

    Efficient recovery of active pharmaceutical ingredients (APIs), chemical substances or food powders after drying applications such as spray and fluid bed drying is frequently a problem. The same problem occurs in many milling and micronization applications. The preferred way to recover these sensitive products is with cyclone collectors due to their direct powder capture. Unlike bag filters or wet scrubbers, cyclones minimize filter or product contamination and product cross contamination and can easily handle a...

    By Advanced Cyclone Systems, S. A. based in Porto, PORTUGAL.

  • Premium

    Product recovery solutions for food ingredients industry

    Efficient recovery of active pharmaceutical ingredients(APIs), chemical substances or food powdersafter drying applications such as spray and fluid bed dryingis frequently a problem. The same problem occurs in many milling and micronization applications. The preferred way to recover these sensitive products is with cyclone collectors due to their direct powder capture. Unlike bag filters or wet scrubbers, cyclones minimize filter or product contamination and product cross contamination and can easily handle a...

    By Advanced Cyclone Systems, S. A. based in Porto, PORTUGAL.

  • Premium

    Emission control & air dedusting for Fertilizers

    The recovery of fertilizers typically after drying tunnels or drum dryers is associated with a high load of particulates and very humid gas streams. The recovery of these products is commonly performed by dryer cyclones as they allow for a direct powder capture and avoid filter clogging due to condensation. Arrangements with cyclones and/or with bag filters are usual in the industry.

    By Advanced Cyclone Systems, S. A. based in Porto, PORTUGAL.

  • Premium

    Product recovery solutions for milling and drying processes industry

    Efficient recovery of active pharmaceutical ingredients (APIs), chemical substances and food powders after drying applications such as spray and fluid bed drying is frequently a problem. The same problem occurs in many millingand micronization applications.

    By Advanced Cyclone Systems, S. A. based in Porto, PORTUGAL.

  • Premium

    Emission control solutions for fuel oil combustion sector

    For PM emission control in high temperature exhaust streams, such as those from fuel oil boilers, common dedusters like Bag filters, have very high maintenance costs. The diesel and fuel oil fly ash can be quite sticky and clog to filter elements, which can be minimized with costly protection reagents or frequent filter elements changes. Flue gas cooling is needed in front of the filter when temperatures are higher than 200 ºC.

    By Advanced Cyclone Systems, S. A. based in Porto, PORTUGAL.

  • Premium

    Emission control solutions for steel and ferroalloys sector

    Steel and ferroalloysmanufacturing processes involve high temperature exhaust streams, often at more than 900ºC. Typically, the gas flows from the furnace (usually electric arch type) and goes into a gas conditioning tower to cool down below 200ºC so that it can be treated by a Bag Filter. It`s also common to have ESP´s as end dedusters that can be preceded by a multicyclone serving as pre-separators.

    By Advanced Cyclone Systems, S. A. based in Porto, PORTUGAL.

  • Premium

    Emission control solutions for biomass and coal combustion sector

    For particulate matter (PM) emission control in high temperature exhaust streams, such as those from biomass or coal boilers and heaters, common dedusters such as cyclones and multicyclones are not able to comply with current emission limits. This is mainly due to their low efficiency, particularly for small particles (less than 10µm). In order to meet emission limits this usually requires an additional investment in a final stage deduster. Bag filters (BF) are very efficient dedusters. They can also be...

    By Advanced Cyclone Systems, S. A. based in Porto, PORTUGAL.

  • Premium

    Water Treatment Solutions for Turbidity Removal

    Turbidity is a measure of the loss of light transmittance through a liquid due to suspended particles. The more particles in the water, the murkier it looks or the higher the turbidity. This is a measure of the quality of the water. It is measured in units called Nephelometric Turbidity Units (NTU). Turbidity can be caused by run off after a heavy rain as erosion washes soil into a river or lake. It is often increased in the spring and fall when the water temperature at different levels in a lake change causing a...

    By Adedge Water Technologies, LLC based in Buford, GEORGIA (US) (USA).

  • Premium

    Hydrocarbons and carbon monoxide

    Example: Aluminium recycling. Similar tasks: Recycling of copper, lead, cink.

  • filter bag

    filter bag for dust collector

    By Redball Technica based in Marikina City, PHILIPPINES.

  • Bag Filter Plants

    Triboelectric dust probes installed in the clean gas duct after bag filters, cartridge filters or centrifugal separators (cyclones) are used to detect faulty, damaged or leaking filters. This early detection of failures minimises product loss, improves environmental conditions and problematic dust emissions. Benefits include low initial outlay, no consumables and low maintenance requirements. There are more than 10,000 Dr. Foedisch filter monitor devices installed worldwide in the food processing, cement,...

    By CEM Solutions (UK) Ltd. based in Darley Dale, UNITED KINGDOM.

  • Nomex filter bags for asphalt mixing site dust filtration

    Nomex filter bag for higher temperature dust filtration ,widely applied in Asphalt mixing plant ,Kiln smoke in cement plant ,steel plant blast furnace smoke and so on. NOMEX filters offer one of the best total economies in a filtrationsystem because of higher air to cloth ratios, higher temperaturecapability, and a long wear life.

    By Zhejiang Grace Envirotech based in Xiaoshan, CHINA.

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you