VOC control Articles

  • Optimizing VOC Combustion - Case Study

    Volatile Organic Compounds (VOCs) are pre-cursors to Ozone pollution and subject to EPA regulations. Thermal and catalytic oxidizers are routinely used to destroy VOC emissions from a variety of industrial sources. ...

  • Case study : VOC analysis in ambient air by FID dectection - Complete system airmOzone

    Ozone concentration has been multiplied by 5 in the last century in the middle latitudes of the northern hemisphere from 10 PPB in 1874 to approximately 50 PPB today. This is an increase of 1.6% per year; the trend is probably higher (2.4% a year) over the last decades. (Chapter 1 of the International Geosphere-Biosphere Program - World Climate Research Program) In order to stop this global ...


    By Chromatotec Group

  • Case study - Coating/hot foil stamping

    Location: New Jersey Equipment: Catalytic Recuperative Oxidizer 12,000 scfm capacity (1994 vintage) Installed: Fall 2003 Problem: Start-up company needed emission control with low capital and operating costs. Problem Details: The founders of this start-up had extensive experience with foil coating, as ...


    By Kono Kogs, Inc.

  • Case study - Specialty spiral core winding

    Location: Ohio Equipment: Adwest Technologies Regenerative thermal oxidizer (RTO) Manufactured in 1999; Refurbished 2016 5,000 scfm capacity Problem: A manufacturer of spiral cores for multiple products needed to economically control emissions. Their growth had resulted in increased emission tonnage and were nearing the ...


    By Kono Kogs, Inc.

  • Thermally activated persulfate oxidation of NAPL chlorinated organic compounds: effect of soil composition on oxidant demand in different soil-persulfate systems

    This study investigates the interaction of persulfate with soil components and chlorinated volatile organic compounds (CVOCs), using thermally activated persulfate oxidation in three soil types: high sand content; high clay content; and paddy field soil. The effect of soil composition on the available oxidant demand and CVOC removal rate was evaluated. Results suggest that the treatment ...


    By IWA Publishing

  • Odorous volatile organic compound (VOC) emissions from ageing anaerobically stabilised biosolids

    Opportunities for the beneficial re-use of biosolids are limited by nuisance odour emissions. Volatile organic compounds (VOCs) from anaerobically stabilised biosolids were measured to identify compounds that could contribute to the overall odour character of nuisance emissions. Flux hood sampling and chemical analysis were used to identify VOCs emitted from biosolids as they were stored in ...


    By IWA Publishing

  • Treating drinking water with 99% removal - Case Study

    QED E-Z Tray® Air Stripper Treating Drinking Water with 99% Removal in Cedarburg, Wisconsin In October 2011, the Cedarburg, Wisconsin Light and Water Utility installed a QED E-Z Tray® (U.S. Patent Number 5,518,668) Air Stripper in a discreet addition to their existing production pump building. The E-Z Tray 72.6 handles a flow rate of ...


    By QED Environmental Systems

  • Removing VOCs from Municipal Water Supply - Case Study

    QED E-Z Tray® Air Strippers Removing Volatile Compounds in Cheyenne’s Drinking Water The U.S. Army Corps of Engineers (USACE) – Omaha District has funded the design and construction of a new groundwater treatment plant in Cheyenne, Wyoming to treat groundwater from the city’s Borie well field.  This important groundwater supply was apparently ...


    By QED Environmental Systems

  • Regenerative Thermal Oxidizer, TRITON Series, Flexographic Printer Project - Case Study

    A flexographic printer recently installed a TRITON Regenerative Thermal Oxidizer from Catalytic Products International, Inc. The TRITON system was contracted on a turnkey basis, in which CPI engineered and installed; the fugitive enclosure system to meet method 204, the ductwork system from all presses, foundation work, electrical integration, and rigged the oxidizer. The project was installed on ...

  • Thermal oxidizers for natural gas savings - Case Study

    It’s in the news every day; the natural gas production industry is experiencing record growth. The gas reserves in the United States are thought to hold enough natural gas for hundreds of years and the gas and oil industry has improved extraction techniques that make gas production more affordable and less impactful on the landscape. Good news for the country and our environment. The ...

  • Enhanced Vapor Intrusion Mitigation via Horizontal Remediation Wells

    Vapor Intrusion (VI) is a potential concern at any building - existing or planned, located near soil or groundwater contaminated with volatile organic compounds (VOCs). Conventional installation technologies (vertical wells) can fall short, especially when large structures such as factories, hangars, and offices buildings are involved because they typically involve expensive and lengthy ...

  • Fast analysis of semi-volatile organic compounds using PTV-GC–TOF MS

    The evaluation of semi-volatile organic compounds (SVOCs) in environmental matrices poses many challenges for the analyst, not least the vast number that may be encountered in any given analysis. In addition, analyte reactivity and the potential for multiple analytes to co-elute makes achieving the required method detection limits (LODs or MDLs) quickly and cost-effectively a formidable task ...


    By SepSolve Analytical

  • Antimicrobial Action of BiOn filtration media

    Bi-On is an air filtration media used in fruit and vegetable sold storage to eliminate harmful volatile compounds, especially ethylene, and sanitize the air. The filtration media is composed of potassium permanganate, its active ingredient, and natural clays. Potassium permanganate is a chemical compound which is widely known for its oxidizing and disinfectant properties. It is used in the ...


    By Bioconservacion SA

  • Synthetic Media Biofilter Eliminates Hydrogen Sulphide and Other Reduced Sulphur Compound Odours

    Abstract Innovative synthetic biofilter media has revolutionized biofilter technology for removal of hydrogen sulphide (H:S) odours from several wastewater treatment facilities across North America. The major drawback of biofilter technology in the past was use of organic wood-based media, which had several problems including high-pressure drop, frequent media replacement, lack of ...


    By Biorem Technologies Inc.

  • What is a Volatile Organic Compound (VOC)?

    What is a Volatile Organic Compound (VOC)? Our products are known for monitoring many different gases, but if you look closely at the description of some of them, you will see that it mentions the acronym VOC. For those that don’t know what VOC means, it stands for volatile organic compound, and there are thousands of different ones produced and used in our daily lives. ...


    By Analox Sensor Technology

  • New NSPS OOOOa Regulations Affecting Methane and VOC Emissions from the O&G Sector Finalized as of June 3, 2016

     The EPA has issued three final rules that will curb emissions of methane, smog-forming volatile organic compounds (VOCs) and toxic air pollutants such as benzene from new, reconstructed and modified oil and gas sources, while providing greater certainty about Clean Air Act permitting requirements for the industry. The EPA’s amended and new regulations affecting methane (CH4) and VOC ...


    By AEREON

  • New NSPS OOOOa Regulations Affecting Methane and VOC Emissions from the O&G Sector Finalized as of June 3, 2016

    The EPA has issued three final rules that will curb emissions of methane, smog-forming volatile organic compounds (VOCs) and toxic air pollutants such as benzene from new, reconstructed and modified oil and gas sources, while providing greater certainty about Clean Air Act permitting requirements for the industry. The EPA’s amended and new regulations affecting methane (CH4) and VOC ...


    By AEREON

  • NASA campaign KORUS-AQ: IONICON PTR-TOF to monitor VOCs above Korea

    Team of the University of Innsbruck and an IONICON PTR-TOFMS aboard NASA research aircraft An international team coordinated by NASA has recently investigated air pollution over the Korean peninsula. Two of IONICON’s PTR-TOFMS instruments were used to monitor volatile organic compounds (VOCs) in real-time aboard NASA’s DC-8 Flying Laboratory. The data gathered by scientists ...


    By Ionicon Analytik Ges.m.b.H.

  • Case study - CRI advances customer service and reduces cost with VOC/HAPS reporting tool

    Color Resolutions International (CRI) is a leading producer of water-based flexographic inks used on paper and film packaging for graphic image and performance conscious printers. CRI’s central manufacturing plant is located in Cincinnati, Ohio and the company operates 19 blending sites in the U.S. to provide prompt local service. The Situation Certain ...


    By UL The WERCS

  • Case study -Operating cost reduction strategies

    Overview More and more, companies operating air pollution control equipment today realize that the initial capital cost of an oxidizer system can be rapidly eclipsed by continued operating expenses if careful attention is not periodically given to the system. ACTION Below are ten tips to ensure your oxidizer is operating at peak performance. The ...

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you