ammonia scrubber Articles

  • Determination of Ammonia and Nitrogen

    Customer: CAE Grand Ouest, France CAE is a laboratory of the Veolia Group located in Western France. The laboratory is specializing in environmental analysis, especially in water and soil analysis. Application: Determination of Ammonia and TKN in waste water and soil Total Kjeldahl Nitrogen (TKN) and Ammonia are common parameters for the evaluation of ...


    By BÜCHI Labortechnik AG

  • Ammonia Scrubbing Semiconductor Manufacturing 101

    Semiconductor chip manufacturing utilizes a variety of inorganic acids and ammonia solutions. Mixing of acid gases and ammonia in a ventilation system can result in a as phase reaction producing very fine particulate that is ifficult and expensive to remove. For this reason a large emiconductor foundry on the west coast decided topre-treat the exhaust from the ammonia sources prior o mixing with ...

  • Compact scrubber for biosolids odors saves $500,000

    A new scrubber at a Camden, NJ bio solids processing facility uses advanced technology to cut the cost of odor control. The system was designed, built and installed by Bay Products with process design assistance from Lantec Products. A single tower is used to remove malodorous gases from air in two stages having separate sumps for the recirculated scrubbing solutions. The lower stage absorbs ...


    By Lantec Products, Inc.

  • Coke Plant Scrubber Water Case Study

    Challenge For the production of coke, volatile constituents of the coal —including water, coal-gas, and coal-tar— are driven off by baking in an airless furnace at temperatures as high as 2.000 °C. The flue gas goes through an ammonia-based scrubbing process. The resulting scrubber water contain small coal-tar and other organic particles (1-250 micron) that cause scaling in ...


    By akvola Technologies

  • Pharmaceutical: Scrubber Eliminates Ethylene Oxide Case Study

    A contract sterilization service uses a single-stage scrubber to convert this hazardous gas to inert ethylene glycol. ETO Sterilization Inc. provides contract sterilization services for hundreds of northern New Jersey customers, concentrating on spices and herbs, cosmetic ingredients and medical supplies. Two of the largest ethylene oxide sterilization vessels in the world are in operation ...


    By CR Clean Air Group, LLC

  • Pulp & Paper: Ammonia Emergency Plan calls on Packed Tower Case Study

    A few years ago Union Camp turned a corner. Management decided that advance planning would take the place of reacting after the fact to an emergency or regulatory agency demands. At Union Camp’s Dover, OH. facility, byproducts of the paper industry are converted into usable specialty chemicals for cosmetics, adhesives and other industries. Crystallization is a process used intensively ...


    By CR Clean Air Group, LLC

  • Ammonia Emergency Plan Calls on Packed Tower to Scrub Released Chemicals,

    A few years ago Union Camp turned a corner.  Management decided that advance planning would take the place of reacting after the fact to an emergency or regulatory agency demands.  At Union Camp’s Dover, OH. facility, byproducts of the paper industry are converted into usable specialty chemicals for cosmetics, adhesives and other industries. Crystallization is a process used intensively ...


  • Medical Industry: Scrubber Eliminates Ethylene Oxide Case Study

    A contract sterilization service uses a single-stage scrubber to convert this hazardous gas to inert ethylene glycol: ETO Sterilization Inc. provides contract sterilization services for hundreds of northern New Jersey customers, concentrating on spices and herbs, cosmetic ingredients and medical supplies. Two of the largest ethylene oxide sterilization vessels in the world are in operation ...


    By CR Clean Air Group, LLC

  • Case History - Ammonia Emergency Plan Calls on Packed Tower to Scrub Released Chemicals

    Croll-Reynolds designed the Union Camp packed tower scrubber for ammonia removal efficiency at 99+% for the minimum single valve release and well over 90% for the entire range of operation. A few years ago Union Camp turned a corner. Management decided that advance planning would take the place of reacting after the fact to an emergency or regulatory agency demands. At Union Camp's Dover, OH, ...


  • Chemical Industry: Ammonia Emergency Plan Calls on Packed Tower to Scrub Released Chemicals Case Study

    A few years ago Union Camp turned a corner. Management decided that advance planning would take the place of reacting after the fact to an emergency or regulatory agency demands. At Union Camp’s Dover, OH. facility, byproducts of the paper industry are converted into usable specialty chemicals for cosmetics, adhesives and other industries. Crystallization is a process used intensively with ...


    By CR Clean Air Group, LLC

  • Fertilizer Industry: New Fertilizer Plant Eliminates Toxic Fumes with Special Scrubbers Case Study

    Effective control of toxic emissions from fertilizer plants, has been demonstrated in the South American countries of Colombia and Venezuela. A jointly operated process plant in Monomeros Colombo Venezolanos, produces caprolactam for the textile industry and various chemical fertilizers for agricultural use. Agricultural plant capabilities were recently increased with the addition of process ...


    By CR Clean Air Group, LLC

  • Monroe scrubber solves pollution and odor problems from a glass resin reactor at a synthetic fiber manufacturing plant

    Monroe scrubber solves pollution and odor problems from a glass resin reactor at a synthetic fiber manufacturing plant Challenge The plant was emitting about 6.0 lbs/hr of toxic fumes from their resin reactor at a temperature of 200oF. The emitted gases to be cleaned were from hazardous, gaseous pollutants such as phenol and formaldehyde, as well as dust particulate. The ...

  • Innovative Q-PAC® packed two stage odor control scrubber saves $500,000

    Two stages in one 12 ft (3.7 m) tower treat 68,500 cfm (116,400 m3/hr) using high-capacity packing A new scrubber at a Camden, NJ biosolids processing facility uses advanced technology to cut the cost of odor control. The system was designed, built and installed by Bay Products with process design assistance from Lantec Products. A single tower is used to remove malodorous gases ...


    By Lantec Products, Inc.

  • New fertilizer industry gas cleaning technology achieves lower required emission levels

    All fertilizer plants produce dust and gases, such as ammonia (NH3) and acid fumes, which must be removed at very high efficiencies before venting to atmosphere. Familiar examples are granulation and prilling of nitrogenous products such as Urea which is the most widely used fertilizer in the world(1). Phosphatic fertilizer production produces dust and Fluorine compounds. Typical air treatment ...


    By Kimre, Inc.

  • Comprehensive Odor Emissions Study Hall Street Wastewater Treatment Plant Concord, New Hampshire

    ABSTRACTThe operation of the Hall Street wastewater treatment plant (WWTP) in Concord, NH has caused the emission of objectionable odors from various liquid and solids treatment processes resulting in periodic odor complaints from its neighbors. The City of Concord retained Fay, Spofford & Thorndike (FST) to conduct a comprehensive odor emissions study at the Hall Street WWTP and to recommend ...

  • Scrubers with a level head

    The available methods for removing pollutants from a gas stream are numerous, to say the least. A popular method, scrubbers allow users to separate gases and solids by allowing the gas to come into contact with a liquid stream. In the end, the pollutants are washed away in the effluent, and the gas exits the system to be used in later processes or to be released into the atmosphere. For many ...


    By Kimre, Inc.

  • Particulate removal - Case Study

    Application QAFCO (the Qatar Fertiliser Company) operates the world's largest ammonia and urea production site at Mesaieed City, Qatar. The QAFCO 5 expansion project is a $3.2 billion investment to expand capacity to help meet the increased demand from agriculture. It is scheduled to come on stream in 2011. Each of the QAFCO plants uses highly explosive high-pressure natural gas from ...

  • The State of the Art in Gas Cleaning for the Fertilizer Industry

    INTRODUCTION The fertilizer industry has earned recognition for having contributed directly to increase world grain yields in the past century. Based on the conservative estimate of the world population growth, total fertilizer use in the future is expected to grow more than 200 million tons from the current level of 165 million tons. In U.S.A. and other countries the industries ...


    By Kimre, Inc.

  • Reducing Odor and VOC Emissions

    The Montgomery County Regional Composting Facility (MCRCF) in Silver Spring, Maryland is designed to process 400 wet tons/day of lime amended biosolids from the Blue Plains Wastewater Treatment Plant (WWTP) in Washington, D.C. Recently, political pressures forced operations to cease at the MCRCF. Although the aerated static pile composting plant’s fate has not been completely decided, its owner, ...


    By BioCycle Magazine

  • Odor Control Advances at Composting Facility

    The Rockland County (New York) Cocomposting Facility began operations in February, 1999, processing biosolids from the five publicly owned treatment works (POTWs) in the county. The Rockland County Solid Waste Management Authority (RCSWMA) owns the facility, but contracted with Waste Management of New York to design, build and operate (DBO) the 110 wet tons/day agitated bin composting facility ...


    By BioCycle Magazine

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you