biogas flaring Articles

  • Case study - ABUTEC’s medium temperature flare burns canning plant biogas

    A Northumberland, Pa.-based canning plant recently contacted ABUTEC, through ADI System Inc., for help combusting the biogases created during the canning process. During this process, foods that are being prepared for canning create biogases that are used in power generation for the local facility. Excess gases that are not used by the gensets are typically vented into atmosphere, which can ...


    By ABUTEC LLC

  • Development of Low noise landfill gas flare

    Summary: Increasing requirements of the environmental standards and planning permission conditions create more challenges to the equipment providers. Environment Agency guidance demands low emission levels and local planners put low noise levels in their conditions for landfill sites. Achieving both at the same time with conventional equipment was found problematic. Biogas Technology has ...


    By Biogas Technology Limited

  • Greenstars portable monitoring for CHP and flares case study

    Greenstar's award-winning KTK landfill site in Kilcullen, Co. Kildare, is unusual in Ireland in that it has three gas engines feeding electricity to the grid and two flares. In Ireland, while flaring is common, engines are not. The flares are run in tandem with engines so that if an engine is ramped down for repair or service, the flare ramps up automatically. All are supplied by 122 landfill gas ...


    By Geotech

  • High Temperature Combustion of Biogas

    High Temperature Combustion of Biogas Efficient combustion of biogas Controlled and concealed combustion Combustion temperature > 900°C Residence time more than 0.3 s Insulated combustion chamber High safety standard The HOFGAS® - IFL4c high temperature flare provides safe and environmentally-friendly combustion of biogas. The exhaust gas ...


    By Hofstetter BV

  • Solution concepts for the production of biogas

    With its products that go to form part of biogas plants, it is not only a significant pioneering role that Hofstetter Umwelttechnik AG in Switzerland deserves. The company in Berne also adopts a leading position on the worldwide market for utilizing biogas. Hofstetter products – the socalled flares and compressor stations – are designed both for fermentation plants for biomass and for plants for ...


    By Hofstetter BV

  • Biogas Market Snapshot 2014

    1. Biogas Market Scope - Introduction and Definition Biogas is a widely available renewable energy source that can produce uninterrupted baseload power. Biogas can be produced from a wide variety of available organic materials and wastes, including sewage sludge, animal manure, municipal/industrial organic waste, stillage from ethanol production, crop residues, and specially grown energy ...


    By XPRT Media

  • Easy payback from biogas monitoring

    There is a strong business case for biogas monitoring and CHP protection. A fixed biogas analyser may cost some £6-10,000 and monitor gas every few minutes day and night. By comparison it can save its own cost many times over by protecting CHP engines from expensive unplanned downtime, biogas engine ...


    By Geotech

  • National brewery benefits from biogas

    Anheuser-Busch has installed anaerobic digestion systems at 10 of its 12 large breweries in the U.S., with an 11th system in design. Primary drivers are cost-avoidance for wastewater treatment fees and fossil fuel purchases. ANHEUSER-BUSCH, owner of 12 large breweries in the U.S., has committed to reduce its greenhouse gas emissions 5 percent from 2005 levels by 2010. The company is well ...


    By BioCycle Magazine

  • What`s New? Biogas Power

    Technologies that connect the biogas line to the power line include cooling and clean up components, microturbines and reciprocating gas engines and control systems. TOP BILLING on the biogas to electricity stage typically goes to the microturbines and reciprocating gas engines. But in the theater of renewable energy from organics recycling, the show can’t go on without the supporting cast of gas ...


    By BioCycle Magazine

  • Case study - Environmentally friendly vapor combustors, flares and incinerators

    Today’s industry requires innovative, cost competitive solutions to meet the ever growing and changing needs in the market. ABUTEC has developed a full line of “Environmentally Friendly” Vapor Combustors, Flares and Incinerators to meet these demands. The HTF (High Temperature Flare) and MTF (Medium Temperature Ground Flare) offer a flexible and scalable solution to clients in a ...


    By ABUTEC LLC

  • Biological desulphurization of Landfill biogas - Case Study

    Summary Biorem's biogas desulphurization product is providing very high removal efficiencies at a landfill site in Quebec. Despite the highly variable concentrations and low winter temperatures, the system has achieved an average removal efficiency of 97%, and has maintained outlet hydrogen sulphide concentration below target consistently. As a result, the customer has realized a significant ...


    By Biorem Technologies Inc.

  • Thoeni, Allens Farm Biogas Installation - Case Study

    Allens Farm anaerobic digestion (AD) facility is located within the beautiful countryside of Colchester, which is said to be the oldest recorded town in Great Britain. The farm is run by three partners – David Hunter, Charlie Lochore and Will Lochore, who felt ...


    By Clarke Energy

  • High-strength wastes boost biogas production

    Water and wastewater treatment plants (WWTP) are significant consumers of energy. The U.S. Environmental Protection Agency estimates the industry uses the equivalent of 56 billion kilowatt hours (kWh) of electricity, representing three percent of the nation’s energy consumption, and is responsible for creating 45 million tons of greenhouse gas emissions each year. Energy intensive processes, such ...


    By BioCycle Magazine

  • Biogas production and potential from U.S. Wastewater Treatment

    How many wastewater treatment plants (WWTPs) have anaerobic digestion? How many are utilizing the biogas? What percentage of these facilities are feeding additional substrates into their digesters? How is the biogas being used — is it flared, used to drive process machinery, heat the digester, or injected into a natural gas pipeline? These are some of the questions asked of the ...


    By BioCycle Magazine

  • Microturbines, Gas Engines Link Biogas to the Grid

    OPPORTUNITIES to produce electricity from methane are being improved continuously as manufacturers introduce new and upgraded equipment to address market needs and varying characteristics of raw biogas. In the renewable energy from organics recycling arena, the two primary types of electricity generation equipment are microturbines and reciprocating gas engines. This article provides a brief ...


    By BioCycle Magazine

  • Small scale biogas upgrading: Green gas with the DMT Carborex® MS system

    Abstract  More and more effort is being put in the utilization of bio-solids. Bio-solids can be an important source for useful products like fertilizers and biogas. DMT has been developing biogas treatment plants for over 20 years following the market developments closely.  Biogas was first seen as a nuisance at e.g. landfills, creating odor problems and methane emissions. A flare has ...

  • Recovering energy from biogas emission: the case of Mariana Mantovana landfill (Italy)

    This paper deals with the analytic rating of the economic investment in an energy recovery plant for municipal waste, in relation to the estimate of its capability to exploit biogas production transformation, and sale of electricity production, and the Green Certificates. The approach entails the assessment of potential scenarios of biogas flare coming from its production forecasts, according to ...


    By Inderscience Publishers

  • Assessing Feasibility of Direct Drive Technology for Energy Recovery from Digester Biogas

    ABSTRACTThe Regional Municipality of Waterloo completed a study, with support from Environment Canada, to evaluate the feasibility of using direct drive technology to recover energy from digester biogas. The study identified that a 150 HP engine, operating at 54 % load, could be supported by the estimated gas production of 1560 m3/d with 63 % methane by volume. ...

  • GA3000 fixed biogas analysis system at Harper Adams case study

    About the customer Harper Adams Energy in Shropshire, England, is responsible for running the anaerobic digestion plant at Harper Adams University College. The challenges the customer faced Plant manager, James Wood, wanted to monitor biogas composition automatically 24 hours a day, seven days a week.  He wanted his own independent analysis of the gas ...


    By Geotech

  • Case study - GA3000 PLUS fixed biogas analysis system at Harper Adams

    Plant manager, James Wood, wanted to monitor biogas composition automatically 24 hours a day, seven days a week.  He wanted his own independent analysis of the gas mix and to record it in detail, especially the percentage of methane, hydrogen sulphide and carbon dioxide. How the company uses the GA3000 PLUS product James said: “We want our own gas analysis record ...


    By Geotech

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you