biogas plant heat recovery Articles

  • Assessing Feasibility of Direct Drive Technology for Energy Recovery from Digester Biogas

    ABSTRACTThe Regional Municipality of Waterloo completed a study, with support from Environment Canada, to evaluate the feasibility of using direct drive technology to recover energy from digester biogas. The study identified that a 150 HP engine, operating at 54 % load, could be supported by the estimated gas production of 1560 m3/d with 63 % methane by volume. ...

  • Idex Environnement’s Biogas plant at Amiens - Case Study

    The Anaerobic Digestion (AD) plant in Amiens is operated by Idex Environment. The biogas is derived from the municipal solid waste (MSW) originating from the local area. Clarke Energy has delivered a full turnkey installation for this site, creating renewable energy. The engines supplied for this project are two JGMC ...


    By Clarke Energy

  • Power Positive Resource Recovery

    Using laws of thermodynamic analysis to evaluate the energy and power characteristics of wastewater and beneficial uses of biogas offers greater insight into best business practices and what is achievable. Growing numbers of waste-water treatment plants (WWTP) are striving to produce more power onsite. In recent years, there’s even been a race among WWTP operators to see who can ...


    By BioCycle Magazine

  • Electric Utilities Hook up To Biogas

    Pennsylvania Power & Light, Alliant Energy, Wisconsin Electric and Portland General Electric are some utilities that are plugging into anaerobic digestion projects. AT the October, 2001 BioCycle conference on “Renewable Energy from Organics Recycling,” the director of the Iowa Energy Center, Floyd Barwig, pointed out that the possibility of separating the United States from Middle ...


  • What`s New? Biogas Power

    Technologies that connect the biogas line to the power line include cooling and clean up components, microturbines and reciprocating gas engines and control systems. TOP BILLING on the biogas to electricity stage typically goes to the microturbines and reciprocating gas engines. But in the theater of renewable energy from organics recycling, the show can’t go on without the supporting cast of gas ...


    By BioCycle Magazine

  • National brewery benefits from biogas

    Anheuser-Busch has installed anaerobic digestion systems at 10 of its 12 large breweries in the U.S., with an 11th system in design. Primary drivers are cost-avoidance for wastewater treatment fees and fossil fuel purchases. ANHEUSER-BUSCH, owner of 12 large breweries in the U.S., has committed to reduce its greenhouse gas emissions 5 percent from 2005 levels by 2010. The company is well ...


    By BioCycle Magazine

  • High-strength wastes boost biogas production

    Water and wastewater treatment plants (WWTP) are significant consumers of energy. The U.S. Environmental Protection Agency estimates the industry uses the equivalent of 56 billion kilowatt hours (kWh) of electricity, representing three percent of the nation’s energy consumption, and is responsible for creating 45 million tons of greenhouse gas emissions each year. Energy intensive processes, such ...


    By BioCycle Magazine

  • Microturbines, Gas Engines Link Biogas to the Grid

    OPPORTUNITIES to produce electricity from methane are being improved continuously as manufacturers introduce new and upgraded equipment to address market needs and varying characteristics of raw biogas. In the renewable energy from organics recycling arena, the two primary types of electricity generation equipment are microturbines and reciprocating gas engines. This article provides a brief ...


    By BioCycle Magazine

  • Economical and Effective biogas process to Purify alternative fuels for Power generation

    Abstract Energy recovery from biogas is becoming more common, but the processes are hampered with the presence of hydrogen sulfide (H2S). Biogas is a mixture of methane and carbon dioxide (CO2) and is often contaminated with toxic quantities of H2S. Sources of biogas are: municipal landfills that produce landfill gas (LFG); wastewater treatment plants; industrial plants; and large scale ...


    By Eco-Tec Inc.

  • Green Light for Recycling – Biogas has an exciting future - Case Study

    The tipping lorry of the container vehicle moves up. In minutes, its load of food residue is emptied and starts its course to energy recovery. "Energy for tomorrow" is the slogan of the Danpower Group for a reason. Danpower sees the biogas sector as a key growth factor for the future. Twenty five biogas plants are currently in operation, one of which is in Bad Köstritz/Thüringen. ...


    By HSM GmbH + Co. KG

  • Maximizing Energy Recovery through Digester Gas Management System Enhancement

    ABSTRACTAdvanced anaerobic digestion practices and maximum energy recovery call for a digester gas system that reliably allows for complete biogas collection and utilization. This paper will describe the planning, design, and construction of a new digester gas management system at the East Bay Municipal Utility District’s (District) Main Wastewater Treatment Plant. The need for an upgraded ...

  • Captive power plant efficiency for Africa

    Power distribution networks across Africa are notoriously unreliable. Frequent power interruptions can be enormously costly for many of the continent’s factories. Not only do power outages disrupt production batches, they can also damage or reduce the life of important plant components such as kilns. This too has a knock-on effect on wider the country’s gross domestic product – ...


    By Clarke Energy

  • Combined heat & power is a clean, efficient and economic energy solution

    The 21st century has highlighted a need for clean, efficient and economic energy, which has put Combined Heat & Power (CHP) into the limelight. By providing on-site power generation, waste heat recovery and system integration, CHP offers a realistic, near-term solution for exceptional energy efficiency and emission reduction. CHP systems can generate electricity locally while they recover ...


    By Shenton Group

  • Gatineau Sewage Treatment Plant, Gatineau, Quebec, Canada

    Project No. 1 Industrial Boiler Application A FLU-ACE waste heat recovery system installed to process all flue gases from three boilers. The system recovers up to 3.5 mmBTU/h of waste heat which is re-used for heating the digester sludge. The main fuel for the boilers is recycled methane based sewage gas generated from the plant’s anaerobic digesters. 'The installation ...

  • Feasibility of anaerobic membrane bioreactors (AnMBR) for onsite sanitation and resource recovery (nutrients, energy and water) in urban slums

    Slums are challenging locations for sanitation technologies. High population densities, a lack of water and electricity infrastructure, and space constraints combine to ensure that many traditional waste treatment technologies fail when implemented in this context. This paper proposes the use of anaerobic membrane bioreactors (AnMBRs) for slum sanitation. AnMBRs allow for localized water ...


    By IWA Publishing

  • Columbus, Georgia`s High-Efficiency, Low Cost, Digester-Gas-Fired Power Plant

    ABSTRACTGrowing concern over the cost of power and long-term availability of limited fossil fuel resources for the production of electricity have caused electrical utilities and governments to promote “green” or renewable power. Solar, wind, geothermal, biomass, biogas, and low-impact hydroelectricity are current acceptable green-power sources. Digester gas is a renewable, green energy resource ...

  • Bristol (Avonmouth), wessex water case study

    Plant inputs : 30,660 Tonnes dry solids/annum Primary sludge 70% Secondary sludge 30% Advanced Digestion plant : Monsal EH - High rate hydrolysis Heating technology - water - from CHP 6 x 2,728m3  Mesophilic digesters (16,368m3  total) Biogas and Bioenergy engineering : Over 33,000m3 /day or 425m3  biogas generated/tonne DS treated 3 x ...


    By Monsal Limited

  • Great billing anglian water case study

    Plant inputs : 40.000 Tonnes dry solids/annum Wastewater sludge 12.000 TDS Indigenous, 28,000 TDS cake imports Primary sludge 60% Secondary sludge 40% Advanced Digestion Plant : Monsal EEH • High rate hydrolysis  Cake back mixing • 7-8% DS teed plant Heating technology • water and steam 4 x 3,030m3 + 1 x 4,925m3 Mesophilic digesters (17,045m3 ...


  • Digester gas - Stornoway Scotland - case study

    Scottish Island to be the first to utilise Anaerobic Digestion in waste treatment Comhairle nan Eilean Siar Stornoway, Isle of Lewis, Scotland “We were convinced by ENER-G’s ability to install a system that met with our requirements for a facility that is an innovative combination of waste treatments and includes the UK’s first dry Anaerobic Digestion facility” ...


    By ENER-G

  • Kings lynn anglian water case study

    Plant inputs : 20.000 Tonnes dry solids/annum Wastewater sludge Primary sludge 40% Secondary sludge 60% Advanced Digestion plant : Monsal EEH high rate hydrolysis Hybrid heating technology • water and steam 2 x 5,650m3 Mesophilic digesters Biogas and Bioenergy engineering : Over 390m3 biogas/tonne DS treated 2 MWe CHP installed Heat recovery, steam ...


Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you