bioreactor installation Articles

  • MBR bioreactor installation courtaulds, china

    Introduction Following a successful on-site trial using a mobile Bioreactor, Microbac has installed a full-scale Microbac Bioreactor unit in a Courtaulds textile plant in China to reduce the Chemical Oxygen Demand (COD) and Biochemical Oxygen Demand (BOD) of the wastewater. Information obtained from the site trial enabled accurate sizing of the full-scale Bioreactor unit to be ...


    By Microbac Ltd

  • MBR bioreactor installation - rhone poulenc agriculture, united kingdom

    Details Prior to installation of the Microbac Bioreactor at the Rhone Poulenc Agriculture site at Ongar, laboratory studies and a site trial were undertaken to demonstrate the effectiveness of the submerged, fixed film Bioreactor system for the removal of acetone and ammonia in the Rhone Poulenc waste stream. The main benefit of undertaking projects in a phased manner is that it ...


    By Microbac Ltd

  • Bioreactor installation - ministry of defence site, scotland, united kingdom

    Introduction A Bioreactor has been installed by Microbac at an MOD transit training camp in Scotland for army personnel. Occupation of the site varies widely, with as little as twelve persons, for short periods of time, and up to two thousand personnel at maximum occupancy Treatment For this reason, the client requested a system which required little day ...


    By Microbac Ltd

  • Membrane Bioreactor Pilot

    The problem A company which produces a product that requires a constant supply of relatively clean water is planning to expand by adding new process units online.  The plant currently uses well water as a supply to its production.  The water production from the well is limited.  They need to install a system to produce reuse water to reduce the amount of water required ...


    By Dynatec Systems Inc.

  • Membrane Bioreactor for National Park

    The problem: Assateague Island is a barrier island that stretches from the Eastern shore of Maryland down Atlantic coast to Virginia. The island is a National Park, administered by the National Park Service, under the National Seashore division. Assateague Island is a vital resting and feeding area for birds and also is home to more than 300 wild ponies. The park receives about 1 ...


    By Dynatec Systems Inc.

  • The cost of a small membrane bioreactor

    The individual cost contributions to the mechanical components of a small membrane bioreactor (MBR) (100–2,500 m3/d flow capacity) are itemised and collated to generate overall capital and operating costs (CAPEX and OPEX) as a function of size. The outcomes are compared to those from previously published detailed cost studies provided for both very small containerised plants (<40 ...


    By IWA Publishing

  • Membrane Bioreactor for Retirement Community

    The facility: Glen Meadows is a retirement community located next to Gunpowder Falls State Park in north-central Maryland’s open country.  The community has Independent Living, Assisted Living, and Skilled Nursing and Rehabilitation facilities. The problem: The facility has grown significantly over the years. At first, a septic system ...


    By Dynatec Systems Inc.

  • BORD NA MÓNA PURAM® membrane bioreactor system installed at Laurel Cove Golf & Country Club in College Grove, TN

    Bord na Móna Environmental Products U.S. Inc. today announced the installation of a PuraM® Membrane Bioreactor wastewater treatment system at the Laurel Cove Golf & Country Club, a new 1000 acre country club and residential community under development in College Grove, Tennessee.According to Shane Keaney, President of Bord na Móna Environmental Products U.S. Inc., the company was awarded the ...

  • Case study - BioReactor Camping Simuni, Croatia

    Project: Beach Plant System Type: BioReactor Country: Croatia Client: Simuni  Camping Village Capacity: 500 m³/day Year of Installation: 2015. Description: This BioReactor is installed on ...


    By BioKube A/S

  • Case study - BioReactor plant Nairobi, Kenya

    Project: Sucassa Apartment complex System Type: 4 x BioReactor 150 – 2 chamber Country: Kenya Client: Suraya Property Group Ltd Capacity: 900 m³/day Year of Installation: 2015. Description: ...


    By BioKube A/S

  • Case study - BioReactor, residential area, Panama

    Project: New residential area System Type: BioReactor 200 Country: Panama Client: Rhino tech Capacity: 600 m³/day Year of Installation: 2015. Description: This new residential area is under construction and the plant are going to clean all the ...


    By BioKube A/S

  • Membrane Bioreactors – Enviroquip MBR Systems (Retrofit)

    The Leoni Township’s wastewater treatment plant (WWTP) serves thirteen communities across three counties including the Michigan Speedway complex. A moratorium on growth was put in place until capacity and treatment issues with an aging aerated lagoon system could be addressed. In June of this year, construction of a new membrane bioreactor (MBR) ...

  • Influence of shear on nitrification rates in a membrane bioreactor

    Grundfos BioBooster (GBB) installed and operated a membrane bioreactor (MBR) test plant in 2012. During the period it became evident that the nitrification rate was lower than expected and a study was carried out to investigate the possible reasons for the observed low-nitrification rate. Tests were conducted at a pilot plant and the effect of shear from the BioBooster membrane system and the ...


    By IWA Publishing

  • Case study - BioKube BioReactor plant Ujazd, Polen

    Project: Ujazd, village System Type: 6 x BioReactor 150 – 2 chamber Country: Polen Client: Municipality of Ujazd Capacity: 600 m³/day Year of Installation: 2014. Description: This 6x ...


    By BioKube A/S

  • Project: BioReactor at Oil Field - Yemen - Case Study

    Project Description Project: BioReactor at Oil Field Type: BioReactor 150, 3-chamber Country: Yemen Client: Horizon Capacity: 150 m³/day Year of Installation: 2008 ...


    By BioKube A/S

  • Redundancy and Reliability – The 5th Generation of Membrane Bioreactor Design

    Membrane bioreactor (MBR) facility designs have progressed through four generations of development (Crawford et al, 2001). The four generations are generally described as evolving from long Solids Retention Time (SRT) package plants, to the inclusion of nutrient removal (total nitrogen and/or phosphorus), to equipment and facility design optimization by reducing both the SRT and the Mixed Liquor ...

  • Enhanced membrane bioreactor process without chemical cleaning

    In membrane bioreactors (MBR) for wastewater treatment, the separation of activated sludge and treated water takes place by membrane filtration. Due to the small footprint and superior effluent quality, the number of membrane bioreactors used in wastewater treatment is rapidly increasing. A major challenge in this process is the fouling of the membranes which results in permeability decrease and ...


    By IWA Publishing

  • A Submerged Attached Growth Bioreactor for Decentralized Wastewater Treatment

    ABSTRACTThe Amphidrome® process is a submerged attached growth bioreactor (SAGB) that has been used in Massachusetts, Connecticut, Rhode Island and New Jersey for decentralized wastewater treatment systems ranging in size from 440 gpd to 150,000 gpd. The two primary advantages of a SAGB are the small volume requirement and the elimination of downstream clarification. Five years of data from four ...

  • Membrex Membrane Bioreactor - Croisières AML, QC, Canada

    Customer: Croisières AML Croisières AML is the most important cruise-expedition company in Canada. With a fleet of 18 boats located in 8 different ports in the province, near 650 employees welcome 500,000 passengers every year. In order to obtain from Transport Canada all the certifications and permits that are needed, each of their ships must meet very specific ...


    By Premier Tech Aqua

  • Specific energy consumption of membrane bioreactor (MBR) for sewage treatment

    This paper provides an overview of current electric energy consumption of full-scale municipal MBR installations based on literature review and case studies. Energy requirements of several MBRs were linked to operational parameters and reactor performance. Total and specific energy consumption data were analysed on a long-term basis with special attention given to treated flow, design capacity, ...


    By IWA Publishing

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you