boiler regulation Articles

  • Reduced Emissions for Landfill Gas Installations

    The use of landfill gas as a source of renewable energy is increasing. For environmental and safety reasons, the owners of the waste storage sites have to strictly monitor and control the construction, operations, and emissions generated. Sulzer offers solutions to control these emissions within the limits given by the government. Landfill gas is similar to natural gas, but it is created by ...


    By Sulzer

  • Tuning Your Boiler for EPA Boiler MACT Compliance

    The EPA’s Boiler MACT regulations are heating up. Boiler MACT is an EPA rule to limit hazardous air pollutants (HAP) from commercial and industrial boilers and process heaters. Originally proposed in 2011 as a mandate driven by the Clean Air Act,  the rules are Area Source Boiler MACT 40 CFR 63, subpart JJJJJJ for smaller boilers (stores, hotels, apartments, ...


    By Sierra Instruments, Inc.

  • Boiler feedwater deaerators

    The thermophysical deaerator is by far the most applied technology when oxygen and carbon dioxide in Boiler Feed Water must be reduced to negligible concentrations Bono ARTES has inherited the experience in the design of Deaerators that started up within the BONO Group in 1959. The Boiler Feed Water, if in equilibrium with the atmosphere, may contain significant levels of corrosive gases, mainly ...


    By Artes Ingegneria SpA

  • Checklist for Boiler Maintenance

    Boilers play a crucial role at industrial facilities and it is imperative that they be safely and properly maintained. Routine boiler maintenance can help prevent unplanned shutdowns and outages, increase the efficiency of the boiler and cut operating costs, and ensure that the facility is in full compliance with all laws and regulations governing boiler safety. What follows is a boiler ...


    By STI Group, Inc.

  • EPA finalizes boiler NESHAP

    EPA published the final National Emission Standards for Hazardous Air Pollutants (NESHAP) for industrial, commercial, and institutional boilers and process heaters at both major and area sources of hazardous air pollutants (HAP) emissions. EPA developed separate rules for units at major sources of HAP emissions (greater than 10 tons per year [tpy] of any single HAP and/or greater than 25 tpy of ...


    By Trinity Consultants

  • Reducing the Economic Friction of Regulation

    Last month, we looked at two distinctly different bioenergy business models that are merging. Energy profit centers and waste cost-recovery facilities are learning the benefits of each other's business model. The resulting projects generate maximum revenue with lower production costs. The same kind of business model duality occurs in biomass energy regulation. There are more than two kinds of ...


    By BioCycle Magazine

  • Boiler mact - what the new emissions limits on industrial boilers mean for you

    Generically known as “Boiler MACT”, the new possible industrial boiler limits directly address emissions of Hazardous Air Pollutants (HAPs) from industrial boilers and indirectly address the way that industrial sources operate their boilers. This white paper explains how Boiler MACT affects you and how to maintain operating flexibility while addressing compliance issues. The most ...

  • Advantages of cfb boiler from zg

    The circulating fluidized bed boiler of Zhengzhou Boiler Co., Ltd,is improved and optimized on the basis of drawing on the fluidized bed industrial boiler&nbs ...


  • EPA issues final rules for boilers

    The U.S. Environmental Protection Agency (EPA) reports that more than 200,000 boilers, process heaters and incinerators will be impacted by a set of Clean Air Act regulations issued on February 21, 2011. Since EPA first proposed the ...


    By Bergeson & Campbell, P.C.

  • Filter technology to meet evolving regulations

    Maguin has developed the Cercat filter for high temperature air pollution control. In this article, David Gambier and Hélène Real outline the technology, as well as installations planned for 2009. Maguin has been present in the waste thermal treatment field since the 1970s. The company’s knowledge has been built through the turnkey supply of thermal treatment units for different kinds of products ...

  • Bionomic Boiler MACT Emission Control Technologies

    Introduction Bionomic Industries' extensive line of field-proven, cost effective wet and dry scrubber and electrostatic technology choices can easily and economically help you achieve compliance with EPA Boiler MACT regulations for hydrochloric acid, particulate or mercury control. Bionomics' wide range of equipment enables selection of the best control technology to remove a specific or ...


    By Bionomic Industries Inc.

  • Boilers, Solid Waste, and the CAA....Oh My!

    Boilers, Solid Waste, and the CAA....Oh My!   ...


    By All4 Inc.

  • The Wait Is Over; The New Boiler MACT Is Here

    The Wait Is Over; The New Boiler MACT Is Here    April 29, 2010 was a busy day for U.S. EPA and marked the culmination of months and years of background effort and planning related to air toxic emissions from boilers.  U.S. EPA has released pre-publication versions of four (4) proposed rules on their website that, when finalized, will impact thousands of ...


    By All4 Inc.

  • Fire prevention measures in gas fired boiler’s operation

    Gas fired boiler is a kind of industrial boiler using natural or coal gas as fuel,its fuel is risky,especially,fire leakage in the operation is easy to ...


  • New boiler MACT and affiliated rules proposed

    EPA proposed three related rules (with final rules expected by December 16, 2010), intended to reduce the emission of hazardous air pollutants (HAPs) from industrial, commercial, and institutional boilers and process heaters as well as commercial and industrial solid waste incinerators. Simultaneously, it also proposed a definition of solid waste that could potentially affect some units currently ...


    By Trinity Consultants

  • Proposed boiler MACT sets aggressive emission limits

    On June 4, 2010, U.S. EPA proposed National Emission Standards for Hazardous Air Pollutants (NESHAP) for industrial, commercial, and institutional boilers and process heaters at both major and area sources of hazardous air pollutants (HAP) emissions.  EPA proposed separate rules for units at major sources of HAP emissions (greater than 10 tons per year [tpy] of any single HAP and/or greater ...


    By Trinity Consultants

  • Navigating NSPS subpart Db for boilers: a case study

    Over the past year, Trinity assisted a chemical company with the permitting and installation of a new 220 MMBtu/hr package boiler. The new natural gas-fired boiler replaces coal-fired units that were installed in the 1940s. Navigating through the numerous, and at times conflicting, regulatory requirements applicable to such a unit has been challenging. With careful planning and implementation, ...


    By Trinity Consultants

  • What is a Condensing Boiler and How Does it Work?

    It can be all too easy to get confused about the different types of boilers and which is right for you. Today, it’s all about the condensing boiler, and building regulations specify that any new boiler installed in the UK should be a condensing type. But what are these boilers all about, and how are they different to regular boilers? What is a condensing boiler? ...


    By Green Business Watch

  • New Regulations for Biomass and Other Alternatative Fuels

    EPA completed new rules that changed the way they look at "nontraditional" fuels. Using these alternative fuels to generate energy makes a facility subject to emission limits and rules regulation boilers. In December U.S. Environmental Protection Agency (EPA) completed new rules that changed the way they look at'nontraditional" fuels. Materials that can meet the newly revised standards are ...

  • Modernising gas fired power plant boiler damper drives and damper bearings

    Sector: Power Generation Category: Fluid Power Actuators, Services Products: PM/DM, Retrofit The challenge of modernising the instrumentation on an old utility boiler can be overwhelming, especially when the boiler was originally commissioned in 1964. Power utility base load preference has historically been the domain of the larger coal fired boilers. That has been the desired management ...


    By Rotork

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you