boiler water Articles

  • Real Time TOC Analysis in Steam and Condensate

    Executive Summary Steam in petro/chemical plants could be contaminated with hydrocarbons (TOC = Total Organic Carbons) from various sources. In any case this is a sign for defects in the process, whether it they occur in the heat exchanger, the blow down vessel, the condensate recovery or other parts of the system. Conventional solutions to monitor such contaminations use TOC- ...


    By JCT Analysentechnik GmbH

  • Organics in boiler water condensate

    With the wide use of high efficiency boilers and current high-pressure boilers in industry today limiting condensate analysis to the more traditional parameters can result in very expensive repairs. Condensate return should be the highest quality least expensive water that most systems can generate. Boiler operators do not want to lose this or have it contaminated. Condensate return analysis has ...


    By LAR Process Analysers AG

  • The solutions of industrial hot water boiler water evaporation

    When the water evaporation of industrial hot water boiler occurs,we should actively looks for the reasons and the corresponding solutions to extend its thermal efficiency. In the last article,the reasons of industrial hot water boiler water vaporization have been analyzed,after consulting the engineers of Zhengzhou Boiler Co., Ltd,this text will introduce the ...

  • Tuning Your Boiler for EPA Boiler MACT Compliance

    The EPA’s Boiler MACT regulations are heating up. Boiler MACT is an EPA rule to limit hazardous air pollutants (HAP) from commercial and industrial boilers and process heaters. Originally proposed in 2011 as a mandate driven by the Clean Air Act,  the rules are Area Source Boiler MACT 40 CFR 63, subpart JJJJJJ for smaller boilers (stores, hotels, apartments, ...


    By Sierra Instruments, Inc.

  • Boiler feedwater deaerators

    The thermophysical deaerator is by far the most applied technology when oxygen and carbon dioxide in Boiler Feed Water must be reduced to negligible concentrations Bono ARTES has inherited the experience in the design of Deaerators that started up within the BONO Group in 1959. The Boiler Feed Water, if in equilibrium with the atmosphere, may contain significant levels of corrosive gases, mainly ...


    By Artes Ingegneria SpA

  • Saving waste in the boiler house

    Burner technology has improved greatly in recent years. Older Burners had a series of cams and levers that were calibrated to provide specific amounts of air for a particular rate of firing. Being mechanical items, these wore and sometimes required calibration. They, therefore, had to be regularly serviced and calibrated. Generally, new burners use frequency controlled motors and cams to open air ...


    By EBE Engineering Ltd.

  • Boiler Dissolved Oxygen Control

    DISSOLVED OXYGEN CHEMISTRY Dissolved Oxygen (DO) is a measure of the amount of oxygen, usually thought of as a gas, that is dissolved in a liquid such as water. Oxygen is essential to life and is also the most common element found taking part in corrosion reactions. DO can be thought of as the fuel needed for the corrosion process to proceed. It is the corrosion reactions that necessitate ...


    By IC Controls Ltd.

  • Checklist for Boiler Maintenance

    Boilers play a crucial role at industrial facilities and it is imperative that they be safely and properly maintained. Routine boiler maintenance can help prevent unplanned shutdowns and outages, increase the efficiency of the boiler and cut operating costs, and ensure that the facility is in full compliance with all laws and regulations governing boiler safety. What follows is a boiler ...


    By STI Group, Inc.

  • Tips of installing the coal fired hot water boiler

    After buying an coal fired hot water boiler as being the heat power, the other thing the enterprise should think about is to install it. As all of those other boilers, the installation work likewise need the customer’s attention. Because the installation quality is directly connected ...


  • EPA finalizes boiler NESHAP

    EPA published the final National Emission Standards for Hazardous Air Pollutants (NESHAP) for industrial, commercial, and institutional boilers and process heaters at both major and area sources of hazardous air pollutants (HAP) emissions. EPA developed separate rules for units at major sources of HAP emissions (greater than 10 tons per year [tpy] of any single HAP and/or greater than 25 tpy of ...


    By Trinity Consultants

  • Outsourced Water Treatment Plant for Boiler Make-Up Water

    Abstract: An outsourced Water Treatment Plant featuring down flow micro media filters, reverse osmosis units and short bed demineralizers designed to produce 66 l/s of makeup water for eight (8) functioning reactor-turbine units has been running for almost 4 years. Individual equipment and overall plant performance is assessed and plant optimization ...


    By Eco-Tec Inc.

  • Attention to the use of steam boilers in the industry

    In the industry, if people need to use high-temperature steam , then the steam boiler will be used; water can be heated to a quite high temperature, and generates high-temperature steam . Steam boilers and other hot water boiler are not the same , if people want to use the steam boiler, the boiler must be certified , or else once operated wrongly , then the consequences are very terrible.  ...

  • Frequency Converter energy savings on Boilers

    Boilers and heaters account for a significant share of a plant's purchased fuel cost. Combustion air fans are necessary to provide enough combustion air to the boiler or heater's burner system. Louvers, inlet guide vanes or frequency converters control the amount of air allowed into a boiler. Configuring a combustion air fan to allow the proper amount of air into the burner can improve boiler ...


  • Dewatering of Boiler Ash - Case Study

    Ten Gate develops and produces materials that function to increase performance, reduce costs, and deliver measurable results by working with our customers to provide advanced solutions. THE PROJECT The Wheelabrator Technology Group provides design/build and operation of trash-to-energy facilities. The Wheelabrator facility located in Lisbon, CT utilizes a storage tank for ...

  • How to protect the superheater of industrial boiler

    Superheater is the heating surface that heats the saturated steam into the superheated steam in corresponding pressure.To improve the thermal efficiency of circle of the ...


  • Application of 1-hydroxyethylidene-1, 1-diphosphonic acid in boiler water for industrial boilers

    The primary method used for boiler water treatment is the addition of chemicals to industrial boilers to prevent corrosion and scaling. The static scale inhibition method was used to evaluate the scale inhibition performance of 1-hydroxyethylidene-1, 1-diphosphonic acid (HEDP). Autoclave static experiments were used to study the corrosion inhibition properties of the main material for industrial ...


    By IWA Publishing

  • How To Prolong The Life Of Your Boiler

    Regularly boiler maintenance will prolong the life of your boiler and improve efficiency, saving you money. Over the years sludge can build up within the system making it work harder, causing it to be inefficient and expensive to keep. A planned maintenance will flush the system, removing the sludge and other deposits, your gas engineer will also treat the boiler. Flushing a new system will also ...


    By Waltham Technologies, Inc.

  • Monitoring flammable gas in boiler houses

    The most common fuels in use for space and water heating are Oil, Natural Gas and Liquid Petroleum Gas (LPG). By far the most popular, clean and cost effective solutions are utilising Natural Gas or LPG. The traditional safety measure derived from the time of oil fired boiler houses is the use of a fusible link placed above the each boiler. The fusible link is intended to melt if it becomes ...

  • Chemically Inclined: The Case for Clean Boilers

    Boiler cleaning is something most companies don’t want to think about — if boilers are working within operational limits it’s often easier to keep up with smaller preventative maintenance (PM) tasks but put off a total chemical clean ...

  • Power plant converts gray water into boiler feedwater using hero technology

    The Facility The Bajio Power Project is a 600 MW combined cycle project owned by the Energía Azteca, a Mexican project company jointly owned by InterGen and American Electric Power. The build, own and operate facility is in commercial operation near the municipality of San Luis de la Paz in the state of Guanajuato, approximately 160 miles from Mexico City. In 1999, ...

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you