ceramic filter membrane Articles

  • Ceramic membranes for water treatment

    Ceramic membranes, different in pore size and membrane material, were applied to remove particulate and dissolved matter from different spent filter backwash water types as well as from dam water. The study was conducted in pilot scale under conditions typical for waterworks at a dam water treatment plant. A comparison of different ceramic membranes implied that total membrane resistance was more ...


    By IWA Publishing

  • Ceramic Membranes in Sludge Thickening Applications

    The Aerobic Digestion group has recently been conducting pilot testing of silicon carbide ceramic membranes manufactured by the Danish company Cembrane A/S.  This promising technology shows a great ability to filter water even in the challenging high solids environment of sludge thickening.  The results of the pilot testing have led the aerobic digestion group to utilize ...

  • Ceramic membranes with higher abrasion resistance

    High flux rates, combined with a very high chemical and thermal resistance and the resulting operational reliability - these are the reasons why users worldwide opt for ceramic membranes. Up to now, the only parameter where ceramic membranes performed well but not excellent was abrasion resistance. Therefore, filtering of abrasive matter required pre-treatment stages such as prefiltration, ...


    By atech innovations gmbh

  • Evaluation of an emerging water treatment technology: ceramic membranes

    Historically, low-pressure membranes (microfiltration (MF) and ultrafiltration (UF)) used in potable water treatment are made of polymers (polysulfone (PS), polypropylene (PP), polyethersulfone (PES), polyvinylidene fluoride (PVDF) etc). Recently, membranes made of ceramic materials (aluminium oxide) have been developed by MetaWater (Japan), Kubota (Japan) and others and is being marketed in the ...


    By IWA Publishing

  • Filtration by Means of Ceramic Membranes - Practical Examples from the Chemical and Food Industries

    Traditionally, ceramic membranes have been used in waste water engineering. Meanwhile, they are applied in all areas where media need to be filtered, such as in recycling processes in the chemical industry, for cell separation in biotechnology or for fruit-juice filtration in the food industry. 1 Introduction Ceramic membranes based on aluminum oxide are an operationally reliable ...


    By atech innovations gmbh

  • Assessment of a membrane drinking water filter in an emergency setting

    The performance and acceptability of the NeroxTM membrane drinking water filter were evaluated among an internally displaced population in Pakistan. The membrane filter and a control ceramic candle filter were distributed to over 3,000 households. Following a 6-month period, 230 households were visited and filter performance and use were assessed. Only 6% of the visited households still ...


    By IWA Publishing

  • Chemical and microstructural analyses for heavy metals removal from water media by ceramic membrane filtration

    This study aims to investigate the ability of low cost ceramic membrane filtration in removing three common heavy metals namely; Pb2+, Cu2+, and Cd2+ from water media. The work includes manufacturing ceramic membranes with dimensions of 15 by 15 cm and 2 cm thickness. The membranes were made from low cost materials of local clay mixed with different sawdust percentages of ...


    By IWA Publishing

  • Working on a Love/Hate Relationship with the Surface Chemistry of Membrane Filters

    Water, oils, and solvents sometimes need to be filtered. But when you see filters labeled as hydrophilic, hydrophobic, and now oleophobic; what does all this mean?  Sterlitech currently offers membrane disc and sheet filters in 10 different polymer types and 4 inorganic filters. 2 of the polymer types are subdivided into 4 subgroups based on surface ...


    By Sterlitech Corporation

  • What Are the Best Companies for Microfiltration and Ultrafiltration Membrane Systems?

    Whether you are looking for a microfiltration or ultrafiltration (MF/UF) membrane system that will help your facility manufacture safe food and/or beverages, boiler feed water for industrial process, or treat contaminated waste to acceptable effluent standards, it can be overwhelming to search for the MF/UF membrane system that is ideal for your specific application. MF/UF membrane systems solve ...


    By SAMCO Technologies, Inc.

  • Solid / gas separation with fabric filters

    A myriad of filter media are utilized today for separation of particulate matter in industrial gas filtration applications. These media range from single use (deposable) to semi-permanent media and include fiber, fabric, ceramic, membrane, metal mesh, and sintered metal media. Semi-permanent media are usually cleanable, either on or off-line, and are primarily intended for long-term (up to ...

  • BioLargo`s AOS Filter Wins `Technology Star Award` - New Technology Magazine -The First Word on Oil Patch Innovation

    Advanced disinfectant technology developer sets sights on oil and gas applications A small publicly-listed Santa Ana, Calif.–based company that is developing water purification and advanced disinfectant technologies, all using some form of iodine, sees one of its Edmonton-developed technologies as a way to clean up and even eliminate oilsands mining tailings ...


    By Biolargo, Inc.

  • Basic Principles of Microfiltration

    Microfiltration can be defined as the separation of particles of one size from particles of another size in the range of approximately 0.01 µm through 20 µm. The fluid may be either a liquid or a gas. Microfiltration media are available in a wide variety of materials and methods of manufacture. They can be rated either 'absolute' or 'nominal' depending upon the percentage of capture of particles ...

  • VSEP recycles used motor oil at 90°C providing a filtrate suitable for use as marine grade diesel fuel or lube oil feedstock

    A unique membrane filtration system was installed in July 2001 at a major waste oil re-refining operation in Portland, Oregan. The system manufactured by New Logic Research, Inc. of Emeryville, California near San Francisco, is being used to process used crankcase waste oil and produce filtrate that can be sold as a higher value bunker oil. The V��SEP, (Vibratory Shear Enhanced ...


    By New Logic Research, Inc.

  • Clarification of rough beer in brewery industry case study

    Standard filtration uses diatomaceous earth (Kieselguhr) into filter-press and consists in the retention of solid particles (yeast cells, macrocolloids, suspended matter) and solutes responsible for haze. After use the disposal of Kieselguhr (after filtration) are a major difficulty due to their polluting effect. From the health perspective, the used diatomaceous earth is classified as ...


    By RVF-Filtration

  • City Water International explains The Basics of Water Filtration

    The Basics of Water Filtration Most of us know that filtered water is healthier than tap water because of its purity, but how does water filtration work? The basic principle is that filtered water has passed through a filter which removes contaminants through one of several methods, depending on the type of filter. Most water purification systems work in one of three ways ­ by running water ...


    By City Water International

  • Comparing environmental impacts of tertiary wastewater treatment technologies for advanced phosphorus removal and disinfection with life cycle assessment

    Different technologies for tertiary wastewater treatment are compared in their environmental impacts with life cycle assessment (LCA). Targeting very low phosphorus concentration (50–120 μg/L) and seasonal disinfection of wastewater treatment plant (WWTP) secondary effluent, this LCA compares high-rate sedimentation, microsieve, dual media filtration (all with UV disinfection), and ...


    By IWA Publishing

  • Microfiltration vs Ultrafiltration Processes: What is the Difference?

    Microfiltration (MF) and ultrafiltration (UF) are both processes by which a contaminated liquid is passed through a semipermeable membrane that removes solids too large to fit through the membrane’s pore size, yielding a purified liquid stream. To what degree the stream is purified depends on the contaminants present and the pore size of the membrane. MF and UF are generally ...


    By SAMCO Technologies, Inc.

  • Seawater Aquarium Case Study

    Challenge The AquaDom aquarium is the biggest freestanding cylindrical aquarium in the world. It is home to 1500 fish and corals of 97 different species. All its 1000 m³ of water are recycled every hour in order to maintain the appropriate water conditions for sustaining life. Due to the recirculation of the water and the ineffectiveness of their phosphate removal filter, the level ...


    By akvola Technologies

  • Nano this and Nano that?

    Several terms, each with the prefix “nano-”, are now in use in the fields of filtration and its related separation processes, and it is important to be able to differentiate among their nuances of meaning. Firstly, there is nanometer itself, from which the others derive, and which is precise, measuring one thousandth of a micrometer or one millionth of a millimeter. It is thus a very ...

  • Ideal treatment of laundry wastewater with ultrafiltration installations

    Treatment of very dirty work clothing also produces heavily polluted, oily/greasy wastewater. It is the aim of laundry wastewater treatment to reduce fresh water consumption and to minimise the volume of residuals. At the same time, adherence to the limit values according to appendix 55 of the General provisions on hydrocarbon, heavy metal and AOX contamination in wastewater must be guaranteed. ...


    By EnviroChemie GmbH

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you