ceramic membrane filter Articles

  • Ceramic membranes for water treatment

    Ceramic membranes, different in pore size and membrane material, were applied to remove particulate and dissolved matter from different spent filter backwash water types as well as from dam water. The study was conducted in pilot scale under conditions typical for waterworks at a dam water treatment plant. A comparison of different ceramic membranes implied that total membrane resistance was more ...


    By IWA Publishing

  • Ceramic membranes with higher abrasion resistance

    High flux rates, combined with a very high chemical and thermal resistance and the resulting operational reliability - these are the reasons why users worldwide opt for ceramic membranes. Up to now, the only parameter where ceramic membranes performed well but not excellent was abrasion resistance. Therefore, filtering of abrasive matter required pre-treatment stages such as prefiltration, ...


    By atech innovations gmbh

  • Evaluation of an emerging water treatment technology: ceramic membranes

    Historically, low-pressure membranes (microfiltration (MF) and ultrafiltration (UF)) used in potable water treatment are made of polymers (polysulfone (PS), polypropylene (PP), polyethersulfone (PES), polyvinylidene fluoride (PVDF) etc). Recently, membranes made of ceramic materials (aluminium oxide) have been developed by MetaWater (Japan), Kubota (Japan) and others and is being marketed in the ...


    By IWA Publishing

  • Filtration by Means of Ceramic Membranes - Practical Examples from the Chemical and Food Industries

    Traditionally, ceramic membranes have been used in waste water engineering. Meanwhile, they are applied in all areas where media need to be filtered, such as in recycling processes in the chemical industry, for cell separation in biotechnology or for fruit-juice filtration in the food industry. 1 Introduction Ceramic membranes based on aluminum oxide are an operationally reliable ...


    By atech innovations gmbh

  • Assessment of a membrane drinking water filter in an emergency setting

    The performance and acceptability of the NeroxTM membrane drinking water filter were evaluated among an internally displaced population in Pakistan. The membrane filter and a control ceramic candle filter were distributed to over 3,000 households. Following a 6-month period, 230 households were visited and filter performance and use were assessed. Only 6% of the visited households still ...


    By IWA Publishing

  • Solid / gas separation with fabric filters

    A myriad of filter media are utilized today for separation of particulate matter in industrial gas filtration applications. These media range from single use (deposable) to semi-permanent media and include fiber, fabric, ceramic, membrane, metal mesh, and sintered metal media. Semi-permanent media are usually cleanable, either on or off-line, and are primarily intended for long-term (up to ...

  • BioLargo`s AOS Filter Wins `Technology Star Award` - New Technology Magazine -The First Word on Oil Patch Innovation

    Advanced disinfectant technology developer sets sights on oil and gas applications A small publicly-listed Santa Ana, Calif.–based company that is developing water purification and advanced disinfectant technologies, all using some form of iodine, sees one of its Edmonton-developed technologies as a way to clean up and even eliminate oilsands mining tailings ...


    By Biolargo, Inc.

  • Basic Principles of Microfiltration

    Microfiltration can be defined as the separation of particles of one size from particles of another size in the range of approximately 0.01 µm through 20 µm. The fluid may be either a liquid or a gas. Microfiltration media are available in a wide variety of materials and methods of manufacture. They can be rated either 'absolute' or 'nominal' depending upon the percentage of capture of particles ...

  • VSEP recycles used motor oil at 90°C providing a filtrate suitable for use as marine grade diesel fuel or lube oil feedstock

    A unique membrane filtration system was installed in July 2001 at a major waste oil re-refining operation in Portland, Oregan. The system manufactured by New Logic Research, Inc. of Emeryville, California near San Francisco, is being used to process used crankcase waste oil and produce filtrate that can be sold as a higher value bunker oil. The V��SEP, (Vibratory Shear Enhanced ...


    By New Logic Research, Inc.

  • City Water International explains The Basics of Water Filtration

    The Basics of Water Filtration Most of us know that filtered water is healthier than tap water because of its purity, but how does water filtration work? The basic principle is that filtered water has passed through a filter which removes contaminants through one of several methods, depending on the type of filter. Most water purification systems work in one of three ways ­ by running water ...


    By City Water International

  • Clarification of rough beer in brewery industry case study

    Standard filtration uses diatomaceous earth (Kieselguhr) into filter-press and consists in the retention of solid particles (yeast cells, macrocolloids, suspended matter) and solutes responsible for haze. After use the disposal of Kieselguhr (after filtration) are a major difficulty due to their polluting effect. From the health perspective, the used diatomaceous earth is classified as ...


    By RVF-Filtration

  • Comparing environmental impacts of tertiary wastewater treatment technologies for advanced phosphorus removal and disinfection with life cycle assessment

    Different technologies for tertiary wastewater treatment are compared in their environmental impacts with life cycle assessment (LCA). Targeting very low phosphorus concentration (50–120 μg/L) and seasonal disinfection of wastewater treatment plant (WWTP) secondary effluent, this LCA compares high-rate sedimentation, microsieve, dual media filtration (all with UV disinfection), and ...


    By IWA Publishing

  • Seawater Aquarium Case Study

    Challenge The AquaDom aquarium is the biggest freestanding cylindrical aquarium in the world. It is home to 1500 fish and corals of 97 different species. All its 1000 m³ of water are recycled every hour in order to maintain the appropriate water conditions for sustaining life. Due to the recirculation of the water and the ineffectiveness of their phosphate removal filter, the level ...


    By akvola Technologies

  • Nano this and Nano that?

    Several terms, each with the prefix “nano-”, are now in use in the fields of filtration and its related separation processes, and it is important to be able to differentiate among their nuances of meaning. Firstly, there is nanometer itself, from which the others derive, and which is precise, measuring one thousandth of a micrometer or one millionth of a millimeter. It is thus a very ...

  • Ideal treatment of laundry wastewater with ultrafiltration installations

    Treatment of very dirty work clothing also produces heavily polluted, oily/greasy wastewater. It is the aim of laundry wastewater treatment to reduce fresh water consumption and to minimise the volume of residuals. At the same time, adherence to the limit values according to appendix 55 of the General provisions on hydrocarbon, heavy metal and AOX contamination in wastewater must be guaranteed. ...


    By EnviroChemie GmbH

  • From Pilot Studies to Full Scale Plant

    Natural gas is widely used as a primary energy source and is one of the most efficient fuel source. For this reason, more and more gas is utilized exceeding existent production facilities. Oil and gas companies therefore expand there measures and step behind borders finding and exploit new resources. One area of major interest is the Barents Sea, a remote area far from industry and civilisation. ...


    By EnviroChemie GmbH

  • Titanium Scrap Metal Processing

    Background A world-class processor of titanium scrap had a wash system whose cleaning solution was becoming contaminated with both free floating unemulsified tramp oil and emulsified water soluble oil that was being washed off of titanium turnings. As the level of oil contamination increased over time in the wash solution, cleaning effectiveness diminished. The processor uses a metric, ...

  • Hyde ultrafiltration for tumbling/vibratory deburring applications

    Challenge Fabrication manufacturer has an issue with discharging tumbling water from two vibratory deburring systems. Customer Hartzell Manufacturing Industry Medical, Electronic and Bank Security Product Hyde Ultrafiltration System Business Benefits Realized ...


    By PRAB, Inc

  • Custom-designed belt skimmer meets unique needs of large international automaker

    Graham Smith, a sales engineer for the UK division of Abanaki Corporation, Oil Skimmer Division, headquartered in Chagrin Falls, OH, was called upon by a large Japanese automaker with operations in Europe to solve a unique problem—retrieving automotive wax and reclaiming water at the end of an extremely busy production line. The engineer discovered a unique situation. At the end of the ...


    By Abanaki Corporation

  • Methods of Purification

    Water Innovations Water Systems Carbon Filtration is used for several reasons. Its primary purpose is the reduction of chlorine to less than 0.1 ppm. Chorine can damage softener resins, reverse osmosis membranes, and mixed bed deionization resins. Activated carbon will also help control tastes and odors, provide organic and hazardous organic chemical ...


    By Water Innovations, Inc

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you