chlorine gas generator Articles

  • On-Site Chlorine Generation Feasibility Study

     ABSTRACT Gaseous chlorine has been effectively used for disinfection in drinking water and wastewater treatment for decades. While various regulatory programs have placed numerous restrictions on the uses of this chemical due to its hazardous nature, recent focus on the possibility of a terrorist attack at a drinking water or wastewater facility, has underscored the potential hazard ...

  • Do You Need a Microfiltration or Ultrafiltration Membrane System for Your Plant?

    Determining whether or not an industrial plant needs a microfiltration (MF) and/or ultrafiltration (UF) membrane system isn’t always as straightforward as it seems. While these systems are not essential for every industrial process, when thoughtfully implemented within an intake, process, or waste stream, they can go a long way in improving a facility’s efficiency and/or cutting ...


    By SAMCO Technologies, Inc.

  • Chlorine Dioxide gas detection: A comprehensive guide

    Introduction Some years agoago, the bleaching process in the paper industry was changed from using Chlorine (Cl2) as bleaching agent to Chlorine dioxide (ClO2). This was a challenge forThis posed a major challenge to industrial hygienists, as there were no sensors or detectors available that were specific to Chlorine dioxide: There was no sensor technology for gas detectors available that ...

  • Chlorinated hydrocarbons - Case Study

    Example: Pharmaceutical industry Similar tasks: Chemical industry The Pharmaceutical industry uses different processes to create chlorinated hydrocarbons. In a regenerative thermal oxidiser (RTO) the chlorinated organic contaminants are destroyed at high temperature. Chlorinated hydrocarbons - among others - are converted into hydrogen chloride which produces a ...

  • International Chlorine Header Project

    Project: CHLORINE HEADERS AND TRANSFER DUCT REPLACEMENT Client: Major chlor-alkali plant in the Middle East General Scope: All four chlorine gas collection headers, each one 24” through 42” diameter, and all 54” diameter chlorine gas transfer duct from headers to chlorine coolers was installed in ...


    By Fibrex Corporation

  • Controoling chlorine costs

    The most widespread disinfectant used in the treatment of drinking water is chlorine, which can be applied in a variety of ways. History has taught us that, in bacteriological terms, chlorinating water is a proven way of disinfecting drinking water. After all, more than 75 years have passed since chlorine was used to disinfect drinking water for the first time. Many years of experience have shown ...


  • Controlling the addition of Chlorine into a Process

    There are several methods for controlling the addition of chlorine into a process. These methods include flow proportional injection, ORP (oxidation reduction potential) or a residual chlorine analyzer. Each method measures a different process characteristic. Depending on the specific type of process being controlled, there generally is a best choice for controlling the injection of either ...


    By Walchem, Iwaki America Inc.

  • Sanitation Using Ozone & Chlorine

    For nearly 100 years, ozone has been used all over the world for water sanitation. It is nature’s strongest oxidizer and has a byproduct of pure oxygen. Chlorine, on the other hand, is a very effective, time-proven chemical, but is ineffective against hard-to-kill microorganisms such as cryptosporidium. It also has some unpleasant byproducts. Together, however, these two substances can ...

  • Utilisation of landfill gas for the generation of energy

    The gases in landfill sites that develop during degradation processes, largely contribute to the greenhouse effect and additionally harbour considerable safety and health hazards. However, they are also often rich in methane and therefore a potential energy carrier. In many countries much of this potential for the generation of electricity and heat from landfill gas still exists. Furthermore, ...


    By Hofstetter BV

  • From Gas to Liquid: Large-Scale Chlorination System Conversion

    Abstract A number of wastewater treatment facilities using gas disinfection have decided to convert to liquid disinfection for several reasons including safety, regulatory, security, and economic factors. An optimal technology plan should be developed to facilitate the conversion. This presentation provides a case study of a large chlorine disinfection system, and demonstrates key issues of ...

  • Landfill remediation with refrigerants and chlorinated solvents

    PROJECT DESCRIPTION Between 1979 and 1980, industrial and hazardous wastes were disposed of at the Site in a series of unlined pits, each of which was used for a particular type of waste disposal. It is reported based on evaluations of manifests that approximately 3.4 million gallons of hazardous liquid wastes and between 3,700 and 4,100 tons of solid wastes were disposed of in the pits ...


    By GEO Inc

  • Key Operating Strategies for Chlorine Disinfection Operating Systems

    ABSTRACTChlorine has been used as a standard for disinfecting wastewater for many years. While being the standard There are many levels of automation for control of disinfection. To select the best control approach for your facility both control strategies and chlorination chemistry must be understood. Permit conditions must also be fully identified; organism concentrations and operational data. ...

  • International Chlorine Header Project - Case Study

    Project: CHLORINE HEADERS AND TRANSFER DUCT REPLACEMENT Client: Major chlor-alkali plant in the Middle East General Scope: All four chlorine gas collection headers, each one 24” through 42” diameter, and all 54” diameter chlorine gas transfer duct from headers to chlorine coolers was installed in 1996. The service of this ...


    By Fibrex Corporation

  • Case study - Emergency equipment for the absorption of chlorine in hospitals

    Chlorine is a strong oxidant that in normal conditions and in its pure state formsdichlorine, a toxic gas with a yellow-greenish colour formed by diatomic molecules (Cl2) that are about 2.5 times heavier than air and have an unpleasant smell. Among its multiple applications and due to its powerful oxidising nature, it is widely used forwater purificationin sewage treatment plants and as ...


    By Bioconservacion SA

  • Determination of polydimethylsiloxane–seawater distribution coefficients for polychlorinated biphenyls and chlorinated pesticides by solid-phase microextraction and gas chromatography-mass spectrometry

    Applications of solid-phase microextraction (SPME) in the measurement of very hydrophobic organic compounds (VHOCs) are limited, partly due to the difficulty of calibrating SPME fibers for VHOCs. This study used a static SPME strategy with ...

  • Surface Decontamination of Poly-Chlorinated Biphenyls (PCBs) using DeconGel� Formulations 1101 and 1102

    OBJECTIVE:  Surface decontamination determination of DeconGel® formulations 1101 and 1102 on aluminum, carbon steel, and concrete surfaces contaminated with PCB (Aroclor 1016) oil following a modified version of Environmental Protection Agency (EPA) SW-846 Method 8082A, “Determination of PCBs by Gas Chromatography”. ...


    By KT Chemicals, Inc.

  • Field Detection of Chlorinated Alkenes in Well Water using the FROG-4000 Portable GC - Case Study

    Introduction Defiant’s FROG 4000, a portable GCPID system, was used to identify and determine the concentration of chlorinated alkenes in several extraction wells located in Tacoma Washington. Split samples were taken at each well and sent to an offsite lab for analysis. This case study examines the field exercise and highlights the high degree of agreement between the offsite lab and ...


    By Northern ANI Solutions Ltd.

  • Gas Safety in Confined Spaces

    Introduction An offshore worker ensures a vessel is safe to enter; a plant manager enters a small plant room; a contractor inspects the lining of a sewage pipe.  All these personnel face common dangers, despite working in widely different industries.  Gas-related injury poses a serious threat in any confined space where the free movement of air is limited. A confined space ...

  • Gas Detection in Public Swimming Pool Facilities

    Recreational facilities’ indoor swimming pools provide a venue for exercise, competition and fun for all ages as patrons splash, swim, dive and float around in the crystal clear water. To keep the water fit to swim in requires a disinfectant maintenance program commonly using Chlorine, or Chlorine and Ozone. Chlorine is a powerful, corrosive disinfectant and in both gas and liquid forms it ...

  • A Four Channel Gas Detector for Wastewater Treatment Plants

    Common hazardous gases found in wastewater treatment plant facilities are hydrogen sulphide, methane, ammonia, carbon monoxide, chlorine and oxygen deficiency. Some facilities may also use ozone, chlorine dioxide or sodium hypochlorite with the chlorine during the sanitization treatment process. Furthermore, sulphur dioxide is often used to de-chlorinate the water once the treatment process is ...

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you