coal-fired boiler Articles

  • Tips for turning a coal fired boiler to gas fired boilers

    Smog has been a heated topic among the word. Therefore , gas fired boiler substitute for coal fired boiler become a trend to protect the environment.Since the boiler is a large thermal equipment ,it is requires attention to security incidents in the transformation .Here are some tip from ZG about turning a coal fired boiler to gas fired boiler. First , when turning a coal fired boiler to gas ...

  • what is Desulfurization methods of coal fired industrial boiler

    At pretest,coal is the main fuel of industrial boiler in china,sulfur in the coal nearly all transform into sulfur dioxide after combustion without desulfurization,the sulfur dioxide will cause serious environmental&n ...


  • Tips of installing the coal fired hot water boiler

    After buying an coal fired hot water boiler as being the heat power, the other thing the enterprise should think about is to install it. As all of those other boilers, the installation work likewise need the customer’s attention. Because the installation quality is directly connected ...


  • A novel approach for modelling of NOx emission reduction in a tangentially fired coal boiler

    In this research paper, predictive modelling of NOx emission of a 210 MW capacity pulverised coal–fired boiler and combustion parameter optimisation to reduce NOx emission in flue gas is proposed. The effects of oxygen concentration in flue gas, coal properties, coal flow, boiler load, air distribution scheme, flue gas outlet temperature and nozzle tilt were studied. The data collected from ...


    By Inderscience Publishers

  • Coal Fired Boiler two-stage flue gas desulfurization (FGD)

    A major pulp and paper mill located in New England, USA was faced with a control order to reduce SO2 and a schedule challenge to meet the order deadline and steam requirements. In addition, the customer was looking for ways to save reagent cost. Macrotek was selected to design and build two wet FGD systems for two 100,000 lbs/hr medium sulfur coal fired boilers. The design included a two-stage ...


    By Macrotek Inc.

  • Overview of mercury control in coal-fired power plants

    During combustion, the mercury (Hg) in coal is volatilized and converted to elemental mercury (Hg0) vapor in the high temperature regions of coal-fired boilers. As the flue gas is cooled, a series of complex reactions begin to convert Hg0 to ionic mercury (Hg2+) compounds and/or Hg compounds (Hgp) that are in a solid-phase at flue gas cleaning temperatures or Hg that is adsorbed onto the surface ...

  • Mercury speciation and distribution in a 660-megawatt utility boiler in Taiwan firing bituminous coals

    Mercury speciation and distribution in a 660-MW tangential-fired utility boiler in Taiwan burning Australian and Chinese bituminous coal blends was investigated. Flue gases were simultaneously sampled at the selective catalytic reduction (SCR) inlet, the SCR outlet, the electrostatic precipitator (ESP) outlet, and the stack. Samplings of coal, lime, bottom ash/slag, fly ash, and gypsum slurry ...

  • Relative Accuracy Testing of an X-Ray Fluorescence-Based Mercury Monitor at Coal-Fired Boilers

    ABSTRACT The relative accuracy (RA) of a newly developed mercury continuous emissions monitor, based on X-ray fluorescence, was determined by comparing analysis results at coal-fired plants with two certified reference methods (American Society for Testing and Materials [ASTM] Method D6784-02 and U.S. Environment Protection Agency [EPA] Method 29). During the first determination, the ...

  • Flue gas Hg measurements from coal-fired boilers equipped with wet scrubbers

    The U.S. EPA has indicated they are considering additional SO2 and NOx emission reductions, and EPA is under a consent agreement to propose mercury reduction regulations by 2004 for the utility industry. The boiler manufacturers and the utility industry have developed improved combustion modification techniques to reduce NOx emissions. These advanced ...


    By Inderscience Publishers

  • Techno-economic evaluation of revamping of coal-fired power plants in India

    A techno-economic feasibility study has been conducted to investigate the revamping of two 32 MWe Pulverised-Coal (PC) boilers with a number of firing options. The options investigated were: (1) conventional PC revamping, (2) replacement with a new PC boiler, (3) PC to Circulating Fluidised Bed (CFB) revamping, (4) replacement with a new CFB boiler, and (5) Bubbling Fluidised Bed (BFB) revamping. ...


    By Inderscience Publishers

  • Exergoeconomic analysis of a Kalina cycle coupled coal–fired steam power plant

    This paper presents exergoeconomic analysis of a Kalina cycle coupled coal–fired steam power plant using specific exergy costing (SPECO) methodology. Cost–balance and auxiliary equations are developed and solved. The results indicate that in the topping cycle, the boiler and the turbine contribute maximum to the formation of product cost. High value of exergoeconomic factor for the boiler ...


    By Inderscience Publishers

  • Experience on coal reburn in a utility boiler

    Reburning is an in-furnace combustion modification technology for the reduction of NOx. By staging the introduction of the fuel, an environment is created where NOx generated by the combustion of the main fuel supply is subsequently consumed by the hydrocarbon radicals arising from the reburn fuel under reducing conditions. ENEL has retrofitted unit No. 4 of Vado ...


    By Inderscience Publishers

  • Coal fired power plant achieves ZLD for FGD wastewater

    The Facility Illinois’ City of Springfield’s Dallman Power Station’s three coal-fired units and soon to be installed fourth unit, are equipped with flue gas desulfurization (FGD) systems (scrubbers) to control sulfur dioxide (SO2) emissions. The Problem A sharp increase in boron concentration in the FGD wastewater required that The City ...

  • Difficult Complex Decisions For Coal-fired Power Plant Operators

    Changing fuel prices, government regulations and technology all combine to make decision making difficult for operators and developers of coal-fired power generation facilities around the world. Power plant designers in developing countries face new local environmental regulations plus additional requirements stipulated by lenders such as the World Bank. In the developed world, the regulations ...


    By The McIlvaine Company

  • Fire prevention measures in gas fired boiler’s operation

    Gas fired boiler is a kind of industrial boiler using natural or coal gas as fuel,its fuel is risky,especially,fire leakage in the operation is easy to ...


  • Problems of catalytic boiler safety and their role in designing and operation of gas-fired boiler

    In the following paper, some problems of safety for catalytic boilers with fixed and fluidised beds are discussed. The reason is to protect the boiler from gas and fuel-air mixture explosion. For it the conditions excluding the transition from catalytic combustion to flame must be observed, and they are presented in the article for different combustible gases. A special attention has been paid to ...


    By Inderscience Publishers

  • How to prolong the service life of biomass fired boiler

    Because of the shortage of energy and environmental deterioration caused by the extensive use of fossil fuel,biomass fired boiler has played a more and more important role in the industrial boilers.Therefore,we need to focus on the following aspects of work to ensure its normal operation and prolong its service life: ...

  • Whitly Bay - Gas Fired Boiler case study

    Customer: J.P. Westall, Hexham Location: Whitely Bay Heating System: Gas fired, with 15 radiators Installed: 06/07 System problems The heating system in question is a gas fired system with problems of banging and rattling. Half the radiators were not heating properly and ...


    By Vortex Energy Saver

  • ZG chain grate biomass fired boiler in Pakistan

    The new chain grate boiler system with chain grate stocker permits a wide range of biomass fuels including Bagasse, crop stalk, mustard stalk, cotton stalk, rice husk, coffee grounds, de-oiled bran , wood waste , Coconut shell ,roasted chaff, lignite, paper sludge, coal,corn cob, spent grain with high ash contents to be combusted in an efficient manner with the added advantage of automatic ...


  • Pakistan SZS Gas Fired Steam Boiler

    Heavy Oil, Light Oil, Residual Oil, Natural Gas, City Gas, and Blast Furnace Gas can be used as Fuel. The boilers can also be applied to generate electricity at some districts where electricity power is in short. So are a variety of industrial productions, living and remote areas, and oil field. Even they can be used as a power plant boiler startup. SZS series oil & gas boilers are ...


Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you