cooling tower water Articles

  • Determining Proper Cooling Tower Size

    To maximize water-based cooling tower benefits, the appropriate tower size must be selected, requiring the identification of several critical factors. Cooling towers are a relatively inexpensive and reliable way of expelling heat from a number of industrial processes, including nuclear & thermal power plants, petroleum refineries, petrochemical plants, food processing plants, as well as HVAC ...


    By Delta Cooling Towers, Inc

  • Cooling Tower Blowdown Water

    Comparison of electrolytic oxidation v. ozone as biocide and reducing rate of TDS build-up in Cooling Tower Blow Down Water. Performed by Pureflow PtY Ltd of Singapore at Singapore Polytechnic Institute. Open evaporative cooling systems have been widely used throughout industry to remove heat from process systems and modern buildings for the purpose of air conditioning. As a result, due to this ...


  • The Use of Ozone in Cooling Towers

    Ozone has been successfully applied to industrial cooling water systems with the resultant improvement in operational efficiency due to increased heat transfer, reduced system corrosion, improved environmental impact and reducedon-going chemical expenditure. The aim of this paper is to provide practical advice on the options available for the application of ozone and the potential benefits which ...

  • FILTRATION IN COOLING TOWERS

    The installation of AZUD HELIX AUTOMATIC filtration equipments in cooling towers is one of its commonest applications. It allows the reduction of the total solids in suspension in the water, and: - Helps to maintain an optimal efficiency of energy in the heat interchange process. - Reduce the accumulation of particles in the components of the cooling systems. - Reduce the growing of ...


    By Sistema Azud, S.A.

  • Hospital cooling tower application

    The Challenge: One of the largest teaching hospitals in Illinois wanted to improve safety and “green” operations in their cooling tower water treatment chemical regimen without sacrificing effectiveness. The Solution: Replacement of bulk bleach with on-site generated MIOX® mixed oxidant solution, Earthwise reduced the hospital's liability from ...


    By MIOX Corporation

  • Cooling Tower Drift Elimination

    ABSTRACTIn certain cases cooling tower drift (mist) can overwhelm conventional lower efficiency chevron mist eliminators.  This paper explores an alternative strategy to control drift in those cases.  The author uses a case history to illustrate conditions that can be expected to cause uncontrolled drift and to discuss a solution.  The author acknowledges that the information presented is ...


    By Kimre, Inc.

  • Ozone treatment for cooling towers

    Abstract The use of ozone as a maintenance treatment for cooling towers has good potential for operation and maintenance savings in the Federal secior. A small amount of ozone acts as a powerful biocide thai decreases or nearly eliminates the need to remove quantities of water from the cooling tower in order to decrease the concentration of organic and mineral solids in the system. ...


    By Zentox Corporation

  • Cooling tower case study

    Cooling towers have always been difficult to control. Algae grow in the cooling tower itself and on the grids used. In addition to micro-organisms and biofilm, they reduce the efficiency of the cooling tower. Furthermore the risk of spreading Legionella is a serous factor to be reckoned with. Many of the traditional methods to fight algae are either insufficient, cumbersome, environmentally ...


    By LG Sonic

  • How to Save with Cooling Tower Credits

    Cooling towers dissipate heat from recirculating water used to cool chillers, air conditioners, or other process equipment to the ambient air. Heat is rejected to the environment from cooling towers through the process of evaporation. Therefore, by design, cooling towers use significant amounts of water. The thermal efficiency and longevity of the cooling tower and equipment depend on the proper ...


    By WaterSignal

  • Enumeration of Legionella pneumophila in cooling tower water systems

    Legionella pneumophila, the causative agent of Legionnaires disease, is known to colonise and frequently grow in cooling tower waters. Disease is acquired by inhaling aerosol contaminated by legionellae. Determination of the count of Legionella pneumophila in cooling tower waters may, therefore, be useful for risk assessment. In our survey, 103 water samples from 50 cooling towers were examined ...


    By Springer

  • Chiller & cooling tower water treatment - case study

    Overview There are three main challenges for treating cooling water in both open and closed loops: scale, corrosion and biogrowth. Water System Challenges The traditional chemical treatment calls for chemicals to deal with these challenges. When scale is present, the condenser’s ability to transfer heat is reduced, causing higher pressure and higher ...

  • "A Non-Chemical Water Treatment for Cooling Towers"

    Untitled Document Introduction This paper will describe a case study of a ...


    By Dolphin WaterCare

  • An Economical Solution to Cooling Tower Drift

    ABSTRACT In certain cases cooling tower drift (mist) can overwhelm conventional lower efficiency chevron mist eliminators. This paper explores an alternative strategy to control drift in those cases. The author uses a case history to illustrate conditions that can be expected to cause uncontrolled drift and to discuss a solution. The author acknowledges that the information presented is ...


    By Kimre, Inc.

  • Pulse-Power Water Treatment Systems for Cooling Towers

    Untitled Document Introduction “Pay me now or pay me later…” It’s ...


    By Dolphin WaterCare

  • Study cooling tower - Case Sudy

    Case study of a cooling tower application to prevent biofilms ensuring a legionella free environment and maintaining the efficiency of the ...

  • It’s Time to Rethink Cooling Tower Filtration

    ABSTRACTThe dissipation of ambient or process heat in large HVAC systems, manufacturing facilities, power generation plants, refineries, metal mills and forges, chemical plants and food processors is most often accomplished by cooling towers. These simple structures facilitate the transfer of unwanted energy (heat) from a transport liquid (usually water) to the atmosphere. The bane of cooling ...

  • AZUD LUXON filters for Cooling Towers applications

    AZUD LUXON screen filters are especially suitable for cooling towers applications, due to advantages as the minimal backwashing water needs, its low pressure loss, its small footprint, its high capacity for organic and solid particles removal and less maintenance labors. AZUD LUXON filters are made of carbon steel (housing), stainless steel (filtering element) and are suitable to work at ...


    By Sistema Azud, S.A.

  • Northern Indiana Power, NIPSCO cooling tower

    A new onsite mixed oxidant system at the R.M. Schahfer Generating Station of Northern Indiana Public Service Co. (NIPSCO) in Wheatfield, IN, has yielded substantial treatment chemical cost savings and improved summer operation compared to the control unit cooling tower. NIPSCO, an electric and gas utility and subsidiary of NiSource Inc., was approached about the system during a biannual ...


    By MIOX Corporation

  • Use of cooling tower blow down in ethanol fermentation

    Reducing water consumption in bioethanol production conserves an increasingly scarce natural resource, lowers production costs, and minimizes effluent management issues. The suitability of cooling tower blow down water for reuse in fermentation was investigated as a means to lower water consumption. Extensive chemical characterization of the blow down water revealed low concentrations of toxic ...


    By IWA Publishing

  • Mixed-oxidant application in cooling tower maintenance

    Tests using the MIOX-generated mixed-oxidant solution instead of oxidizing biocides (chlorine or bromine) for cooling tower maintenance, and eliminating all other biocides, in first an established cooling tower and subsequently in two new cooling towers found: (1) aerobic bacteria counts consistently less than 1000/mL in the cooling water (no colonies on the standard Easicult TTC1 dip slide ...


    By MIOX Corporation

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you