electronic metering pump Articles

  • Replacement Fill Control Valves with Electronic Flow and Metering Improve Pressure, Stop Leakage and Prevent Valve Failures

    The City of Modesto, California is situated 90 miles east of San Francisco and has approximately 200,000 residents relying on 200,000 of gallons of water a day. The City needed to upgrade three water storage tanks that hold approximately 750,000 gallons each. After years of using motor operated valves to fill water storage tanks, the city recognized that there were just too many problems. ...


    By Singer Valve Inc.

  • The mystery of electronic water treatment unveiled

    The problems of scale are well known to those living and working in "hard" water areas. Scale is the undesirable consequence of water supplies becoming super-saturated with dissolved minerals.  These problems are of greater significance if found in industrial water systems and commercial buildings. Scaling problems commonly occur, even in "soft" water areas, when a fluid stream is ...

  • Sizing and Selecting the Proper Metering Pump: Part 1 of 2

    A typical agriculture or process application can consume large amounts of chemicals during daily operations. While the volumes may be large, though, they must also be very precise, with exact amounts delivered according to strict injection schedules. The pressures—from very high to very low—that the chemicals are injected at must also be governed precisely. This demand for ...


    By Modern Pumping Today

  • Pump metering wastewater chemicals operationally effective and cost efficient

    Pumps are the heart of wastewater treatment systems and pump metering chemicals is critically imperative to required wastewater treatment! Different types of pumps are designed for unique wastewater treatment pump applications. Centrifugal pumps are used for general wastewater pumping. Positive Displacement pumps are used for pumping heavier solids. Chemical Metering Pumps are used for pump ...

  • Electronic water treatment reduces fouling in heat exchangers

    The deposition of material on heat transfer surfaces is called fouling which significantly impacts on the thermal and mechanical performance of heat exchangers. Fouling increases the overall thermal resistance and lowers the overall heat transfer coefficient of heat exchangers as well as impeding fluid flow, accelerating corrosion and increasing pressure drop across the heat ...

  • What You Need to Know about Electronic Automation of Hydraulically-operated, Diaphragm-actuated Control Valves

    Hydraulically controlled, diaphragm-actuated control valves are the mainstay of the waterworks industry to control pressure, flow, level, pump control, and at times to meter. These automatic control valves are controlled by pilots to do specific tasks and are mainly single-set-point systems. With the need to remotely actuate and control the valves and the applications becoming more complex, ...


    By IWA Publishing

  • Purifying wastewater with Peristaltic Industrial Tube Pumps

    The Challenge A leading multi-national electronics company with numerous plants across South Korea has for many years been using Metering pumps for dosing Aluminium Sulphate in their wastewater treatment facilities. The plant engineers approached the local Verderflex distributor Dong-Il Ent Co Ltd, looking for a solution to the following problems ...

  • Wastewater Plant Relies on Thermal Flow Meter for Co-Gen Power Gas Blending Process

    The Rahway Valley Sewerage Authority (RVSA), which operates a large wastewater treatment plant in New Jersey, embarked on a green co-generation waste-to-energy project to power a portion of its operations. The plant performs primary, secondary, tertiary and sludge treatment processes in serving over 250,000 residential customers and 3000 industrial and commercial customers in a 40-plus square ...


    By Modern Pumping Today

  • Joint German-Polish sewage plant satisfied with Allweiler pumps after 12 years

    An example of successful German-Polish collaboration In May 2010 the Gubin sewage plant celebrated its twelf-year anniversary. This plant processes wastewater from the cities Guben and Gubin, located on opposite sides of the Neisse River. It is the only German-Polish project of this type to operate successfully for the long term. Major elements of the plant include 17 progressing cavity ...


    By ALLWEILER GmbH

  • Quarry dewatering compliance

    Louis W. Bray Construction installed a Greyline Area-Velocity Flow Meter in 2009 to meet Ministry of Environment regulations. Their permit stipulated effluent limits plus monitoring, sampling and flow measurement of wastewater discharged from the site to the South Raisin river. The Ontario Water Resources Act requires flow monitoring for any quarry dewatering greater than 50,000 liters per day. ...


    By Greyline Instruments Inc.

  • Quarry Dewatering Compliance

    Louis W. Bray Construction installed a Greyline Area-Velocity Flow Meter in 2009 to meet Ministry of Environment regulations. Their permit stipulated effluent limits plus monitoring, sampling and flow measurement of wastewater discharged from the site to the South Raisin river. The Ontario Water Resources Act requires flow monitoring for any quarry dewatering ...


    By Greyline Instruments Inc.

  • Leaks and spills - LNAP and DNAPL detection and clean up

    Any tank can leak. Most leaks can be cleaned up and responsible operators need equipment that does what’s needed. With an ATEX Zone 0 certified interface meter site operators can successfully achieve LNAP and DNAPL detection when monitoring petrochemical sites, tank farms, petrol station forecourts, landfills or remediation sites. If site technicians detect ...


    By Geotech

  • Contact-free indirect measurement

    The non-contact mode of measurement is very interesting for hygienic applications in the food-, pharmaceutical- and cosmetics industry, as well as for industrial applications with thick, adhesive and solid containing liquids. Experience has shown that conventional volumetric flow meters quickly come to their limit, while other measuring procedures are often very complex and/or are not suitable ...


    By Lutz Pumpen GmbH

  • Monitor Dredging Slurry Flow from Outside the Pipe

    Dredging Equipment Manufacturers Choose Non-Contacting Greyline Flow Meters The Challenge Thousands of dredges are operated to maintain navigation channels in our rivers, lakes and harbours and to mine sand and gravel for the construction industry. Managing and optimizing production from a dredge requires continuous monitoring of pipeline pressure, vacuum ...


    By Greyline Instruments Inc.

  • Maintaining level of acidulants in the food industry case study

    Reducing delivery costs and time by utilizing Solid's SmartScan 25L for level measurement of acidic liquids in Gadot Biochemical factory. Gadot Biochemical Industries Ltd. (GBI) located in Israel, is a prominent world-wide supplier of ingredients and fine chemicals for the food, cosmetic, detergent, and pharmaceutical industries, and specializes in the manufacture and development of Citric Acid, ...

  • Lowara plays key role in Ashgabat 2017 games

    Ashgabat in Turkmenistan is set to be the home of the fifth Asian Indoor and Martial Arts games in 2017. Construction teams are working hard to meet the fast approaching deadline of this multi-phase project, with phase two and three nearing completion. Totaling over 1,466 square meters, the multi-purpose sports facility, comprising 30 venues, is positioned at the heart of Turkmenistan’s ...

  • Preventing rain water flooding case study

    SmartScan 50 helps preventing rain water flooding by providing an efficient level measurement solution in a pop. 1M city. The municipality has been struggling for years with heavy flooding of rain water during winter time that damaged large parts of the city and caused distress to its residents. As a result, a long drainage pipe was laid between the city's shore and the flooded parts. This huge ...

  • Remote controlled `Pit Hog™` dredge removing sludge from aeration lagoons at Los Alisos, California, Waste Water Treatment Plant

    The Los Alisos Water District Water Reclamation Plant is removing raw sewage solids, decayed algae and microorganisms, and algae-laden sludge from its aeration lagoons using a Liquid Waste Technology (LWT) remote controlled lagoon dredging system. The tertiary wastewater treatment plant treats four million gallons per day. Officials of the Lake Forest, California facility initiated the buildup ...

  • Controlling level of toxic liquids for the foam industry case study

    Solid provides a durable solution for level controlling of toxic liquids, using the SmartScan 50L ultrasonic measurement gauge. Polymers Ashkelon Industries located in the city of Ashkelon, is a major supplier of foam for the furniture and mattresses industry in Israel. The company has a long-standing reputation in manufacturing of foam in various shapes and sizes for mattresses, furniture and ...

  • Portable Monitoring Instruments Solve Flow Rate Mystery

    The Glen Walter Sewage Collection System was built to service 1080 customers in 1989. At the time the population was 850 but by 1995 the sewage treatment plant had already reached capacity. Shawn Killoran took over the Operations Manger position in 1999 and, along with the Mayor and Council, he immediately had concerns about the excess flow. The Township started by video taping all of the lines ...


    By Greyline Instruments Inc.

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you