fermentation monitoring system Articles

  • QIC-Biostream - exhaust gas analysis of small scale fermenters

    Summary The application of the Hiden QIC-Biostream gas analysis system is to monitor the off-gas and vapours from up to 80 small scale fermenters for yield optimisation and process screening. Introduction Biotechnology is an extremely important area for the 21st century and information relating to yield of a product is crucial to most Biotech ...


    By Hiden Analytical Ltd.

  • CO2 Monitor For Breweries: Carbon Dioxide Safety and How to Stay Safe

    Carbon dioxide is a necessary byproduct of the brewing process, yet too much CO2 can be dangerous to employee health. In Germany, two workers died at the same brewery in 2012 due to hazardous levels of CO2 present in beer mixing and pressure tanks. Learn more about how CO2 levels can get out of control during the beer brewing process and ways to protect your staff from this deadly gas.  ...

  • Case study - N°AA2 – Ambiant air monitoring – WWP TRSMEDOR deodorisation

    Context & Challenges Globally, the wastewater treatment is the first public health issue. Urban development leads to urbanization near waste water treatment plant and extension of sewerage network. These aspects induce to an augmentation of sulfur compounds (H2S, mercaptans and sulfides) which are very corrosive, odorant and toxic. To monitor this compounds online CHROMATOTEC® ...


    By Chromatotec Group

  • Why a CO2 monitor may be needed? Where carbon dioxide leaks occur

    Do you work with carbon dioxide (or CO2) in your industry? If so, then you may need a carbon dioxide monitor to check for gas leaks that could pose a hazard to your workplace safety. Learn common scenarios where carbon dioxide can leak and see how a CO2 detector can minimize your risk.  Industries Where CO2 Monitors Can Make a ...

  • Treatment plant protected by effluent monitor at major drinks factory

    The installation of a BioTector continuous TOC (Total Organic Carbon) monitor to police the front end of Cobevco’s wastewater treatment plant has enabled tight control of the treatment process. Delivering results 20 times faster than laboratory techniques, the monitor at the Elton facility in Cheshire provides advance notice of organic overload so that the plant is able to instantly divert ...


  • Case study N°AA1 – Ambiant air monitoring – WWP TRS MEDOR H2S filter

    Context & Challenges Globally, the wastewater treatment is the first public health issue. Urban development leads to urbanization near waste water treatment plant and extension of sewerage network. These aspects induce to an augmentation of sulfur compounds (H2S, mercaptans and sulfides) which are very corrosive, odorant and toxic. To monitor this compounds online CHROMATOTEC® ...


    By Chromatotec Group

  • Greenbelt Resources Selected to Manufacture First Commercial-scale, Vapor-capture System for EcoPAS

    Greenbelt Resources Corporation (OTC: GRCO) an innovator of sustainable energy production systems, today announced that it was selected by EcoPAS, a California company, to manufacture its PAS (Passive Alcohol System) – a revolutionary pollution control device that captures and transforms gaseous ethanol emissions into quality spirit products.  The ...

  • Latest analytical technology ensures biogas efficiency

    Anaerobic Digestion (AD) relies on the ability of specific micro-organisms to convert organic material into a gas that can be used to generate electricity. However, these bacteria require specific conditions if they are to function effectively and instrumentation specialist company HACH LANGE has developed a range of online, portable and laboratory instruments that have enabled a large number of ...


  • Largest Hofstetter Installation

    Type     HOFGAS®- LPM 7000  Commissioning     2003 Site     Landfill Pinto (ES) SituationOne of the Europe’s largest landfill sites is located in the Pinto region, south of Madrid, where a modern waste treatment and energy recovery system is currently being developed. Urbaser S. A. is implementing a new plant ...


    By Hofstetter BV

  • Weda-Eurotier-Novelty Feeding Technology: Excellent 4PX PLUS

    “Excellent 4PX PLUS“ - Modern, Intuitive, Individual The Modern Control Program for House Units Each house unit is an individual one. And for this reason, every farmer has his own idea of the priority of the information from his house. Exactly for meeting with these special demands, the Lower Saxonian manufacturers of house equipment, WEDA Dammann & Westerkamp, have ...


  • Case study - China Resources Gas Group Ltd

    Anaerobic fermentation project with waste water in Qidong Jiangsu Province, China.  The purification project was set up in order to connect the biogas to the city’s gas pipeline. The customer’s challenge Biogas upgrading: the Group aims to make use of what would ordinarily be a by-product – waste water.  Gas is extracted from a water treatment process, ...

  • Using Anaerobic Biomass Digestion to Produce Hydrogen and Biofuel

    For many years, hydrogen has been considered as an alternative to fossil fuels. Now, Scientists are aiming to develop an environmentally friendly method to produce hydrogen from biomass by optimizing anaerobic digestion systems.1 Climate change, dwindling fuel resources and energy prices have spearheaded intensive efforts to detect and optimize ...


    By Edinburgh Instruments Ltd

  • CO2 Gas Hazards in the Brewing Industry

    The hazards associated with CO2 in the brewing industry are well known, yet people still die needlessly every year in tragic and completely avoidable accidents in breweries. Just last year in Germany, which has a good safety record, two workers died in separate incidents at the same brewery. In the first incident, the owner was found dead with his head and torso in a beer mixing tank. It is ...

  • A multi-parameter analyzer helps a Kentucky treatment plant step up to the plate and meet a new phosphorus limit in its permit

    In 2001, the Lexington Fayette Urban County Government West Hickman Creek Wastewater Treatment Plant in Nicholasville, Ky., was starting Phase II of its third upgrade since 1972, when the state imposed a phosphorus limit. Total phosphorus hovered around 6 mg/l, but the permit required 1 mg/l monthly average and 2 mg/l daily maximum from May through October. Engineers from Tetra-Tech, the ...

  • Revisiting the Karlovac Brewery Incident

    As a gas monitoring company, we have been made aware of many tragic incidents concerning gas leaks. One of the most obscure and tragic is the incident which happened at the former Karlovac Brewery in Karlovac, Croatia in 2007. Karlovac Brewery (Karlovačka pivovara) was founded in 1854 and is one of Croatia’s most famous breweries, brewing national ...


    By Analox Sensor Technology

  • Greene King Brewery gas leak – carbon dioxide in breweries

    On Thursday 15 October 2015, a carbon dioxide leak occurred at the Greene King Brewery on an estate in Bury St Edmunds in Suffolk. Emergency services were sent to the incident and nearby residents were evacuated as a precaution. Twenty people were rescued from the building, and the incident was quickly taken control of. ...


    By Analox Sensor Technology

  • Sensors & Automation to Simplify Bioprocess Operations

    Utilising sensors & automation to simplify bioprocess operations means that more work can be done in less time. By automating the routine tasks carried out in the lab, valuable time can be devoted to more important tasks. Here are two practical examples of automating routine tasks in upstream and downstream bioprocessing with relatively simple instrumentation. Automated ...


    By Broadley-James Ltd

  • ORP and pH Based Control of SBR Cycles for Nutrient Removal from Wastewater

    ABSTRACTContinuous monitoring of multiple process functions were conducted involving removals of BOD, TSS and nutrients, in each cycle of the SBR reactor at the wastewater treatment plant of the City of Carrabelle, FL. On line, real time, monitoring of pH, oxidation reduction potential (ORP), dissolved oxygen (DO), ammonia-N, nitrite-N, nitrate-N and orthophosphate-P demonstrated excellent ...

  • Janssen Pharmaceutical Case Study

    Background Janssen (formerly Centocor Inc), a subsidiary of Johnson & Johnson, runs a state-of-the-art biopharmaceutical manufacturing facility in Cork, Republic of Ireland. The plant consists of a 10,000m² production building along with a central utilities building, a laboratory and administration block, waste water treatment plant and warehousing/storage. The facility ...


    By Scannell Solutions Limited

  • Bioaugmentation is a cost-effective and sustainable remediation alternative

    Selecting a remediation alternative that is compatible with the natural soil and ground water conditions is not only a more sustainable approach, but leads to significant savings. Comparison between bioaugmentation and other remediation methods in the five recognized sustainability criteria demonstrates the advantages of bioaugmentation. While this paper is nota complete quantitative analysis, it ...


    By CL Solutions, LLC

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you