fiberglass container Articles

  • Mercury Removal from Nerve Gas Ton Container Rinse Waters

    IE was retained by a United States Army subcontractor to perform a process determination with analytical verification for the treatment of the rinse water from decontaminated nerve gas agents. The Pentagon Munitions Deconstruction Committee (PMDC) fully reviewed and approved the process developed. The wastewater was generated from the rinsing of 2,000-pound (ton) containers in a punch/drain/rinse ...


    By Integrated Engineers Inc.

  • Monroe`s Multi Stage Oil Mist Collector solves synthetic fiber plant`s oil mist problems

    Challenge A synthetic fiber plant's manufacturing operations produced a large amount of oil mist. The oil mist consisted of heavy oil droplets, smoke, and sub-micron vapors. The manufacturer required the air to be cleaned of the oil mist and other pollutants before discharge into the atmosphere. Solution The plant examined various types of oil mist ...

  • Sacramento State – upgrading sewer to “green”

    Tidelands Construction Company installed a new Flowtite Septic Tank on the campus of California State University in Sacramento. This upgraded sewer system was part of a school-wide “green” building initiative. The governing body at one of California’s finest universities began a large-scale “green building” project designed to reduce the school’s harmful ...

  • How to Repair Pipes Quickly with Minimal Service Disruption

    If this has not yet happened to you, it will. The time is 5:30 a.m. and your guests are just beginning to wake when you get an emergency call informing you that a pipe has sprung a leak. What are your options? Will you shut down the water for a few hours, leaving your guests without water to brush their teeth, take their showers, or flush the commodes while you cut out and replace the bad ...


    By InduMar Products, Inc.

  • Case study - Client: University of South Florida, Tampa, Fl

    Project: Rooftop rainwater to flush toilets. Patel Center for Global Solutions. Challenge: The Patel Center is the first LEED certified building at the university of South Florida, and sustainable water practices were an important objective for the building's stewards. With an estimated occupancy of 700 students and 70 teachers and employees per day, the system needed to ...

  • Fabric structures as cost - Effective solutions in recycling applications

    With regulations becoming increasingly stringent and budgets continuing to shrink, recycling and other solid waste facilities are looking for innovative solutions for physical plant upgrades. In order to reduce processing costs and protect the environment, many treatment plant operators are choosing tension fabric buildings. Glass Recycling – Covered Containers Tension ...


    By Waste Advantage Magazine

  • Controlling condensation- controlling mold

    You know those water stains on the ceiling tiles in your office that you are certain are caused by a leaky roof. Of course, the maintenance man thinks your crazy, since your office is not on the top floor. He dutifully changes the ceiling tile and a month later the water stain is back but this time it has those little black circles that look like mold colonies. Sound familiar? There seems to be ...

  • Controlling condensation - controlling mold

    You know those water stains on the ceiling tiles in your office that you are certain are caused by a leaky roof.  Of course, the maintenance man thinks your crazy, since your office is not on the top floor.  He dutifully changes the ceiling tile and a month later the water stain is back but this time it has those little black circles that look like mold colonies. Sound familiar? There ...

  • Monitoring Air/Fuel Mixtures in Glass and Glass Fiber Manufacturing case study

    Measurement of Premix Gas. To produce the desired flame in a glass forehearth or when making fiberglass (glass fiber) insulation, an air/fuel pre-mixer is used. The pre-mixer combines compressed natural gas or propane with air and this mixture is then piped to the process burners At the burner, a fuelrich or fuel-lean flame is produced depending on the air/ fuel ratio selected. In many ...

  • Large Midwestern Electronics Div. of a Transportation Co. uses a local regeneration company that mistakenly mixes water purification resin with lead treated resin

    "I just called a local water treatment dealer and a salesperson came to discuss the application. He recommended his fiberglass tanks for my operation..." discussion: A manufacturing engineer contacts a major USA water purification company with a local regeneration dealership to get a DI water supply for his cleaner. The dealership is an independently owned franchise that does not ...

  • Pharmaceutical: HCI Fumes Eliminated at Two Plants Case Study

    Little Maintenance Needed On Jet-Venturi Scrubbers; New Solutions Of Plant Problems: Two plants -Tenneco Chemicals, Reading, Pennsylvania and Hoffmann-La Roche, Nutley, New Jersey – are preventing the escape of HCl fumes from their plants by the use of jetventuri wet scrubbers and separators. Fiberglass-reinforced polyester construction of scrubber units is major factor that ...


    By CR Clean Air Group, LLC

  • A new approach for fixing leakages in Qatalum, QAT case study

    Qatalum is the largest aluminium smelter plant ever launched in one phase and is a joint venture between Qatar Petroleum and Norsk Hydro. Its annual capacity is 585,000 metric tons of primary aluminium. Qatalum also ensures a stable supply of electricity by a 1350 MW natural gas power plant but this requires an effectively function of the cooling water system. Project description ...


    By AMEX GmbH

  • Polymer Concrete for Structural Restoration and Corrosion Protection of Concrete Support Columns

    Introduction A large copper mine and refinery in the western United States had a dilemma. Their cell house, which contains over 1,500 cells, each holding more than 20,000 gallons of electrolyte, had experienced severe corrosion and structural degradation of the support columns for the tanks. These columns support the cells in their solvent extraction and electrowinning process. This ...


    By Sauereisen Inc.

  • MRF design challenges with Rumpke Columbus

    Striking a Balance: When it came time to expand the capabilities of its Columbus, Ohio, material recovery facility, Rumpke turned to Machinex. At each of its 11 recycling facilities, Cincinnati-based Rumpke Recycling tries to balance the needs of the residents it serves as well as those of its consuming customers. This philosophy is evident in the upgrade the company recently completed ...


    By Machinex Industries Inc.

  • Wet Flue Gas Desulfurization System

    Installing the optimum wet flue gas desulfurization technology, B&V Energy is bringing superior multi-pollutant removal technology to the North American utility marketplace. To help make a positive impact on the global environment and to comply with the Clean Air Interstate and Clean Air Mercury Rules, Dayton Power & Light needed to remain in compliance as more stringent air quality ...


    By Black & Veatch Corporation

  • Severe Drought and Collapsible Water Storage Tanks and Pillow Bladders

    The U.S. Department of Agriculture's Drought Monitor has recently published information indicating that up to 95 percent of Texas is experiencing either "severe" or "exceptional" drought conditions this year. According to the National Weather Service, Texas experienced the hottest period (June through August 2011) on record in the U.S. In addition, the Lower Colorado River Authority (LCRA) ...


    By Interstate Products Inc

  • FORENSIC study at a Northern New Jersey service station: the mixing of old and new gasoline

    In 2000, a client purchased a gasoline service station in northern New Jersey. A few days after receiving possession of the property, he received a letter from a State regulatory agency informing him that an investigation surrounding a leaking waste oil UST was required. He was unaware that a waste oil UST had existed; automotive repairs were not part of his or the previous owner’s business ...


  • Evaporator concentrates brine pond for about 1 cent per gallon

    The Facility Eagle-Picher Industries has an 8-acre hazardous waste surface impoundment pond at its Electro-Optics Division plant in Quapaw, Oklahoma. The Problem By the time Eagle-Picher contacted Aqua-Chem ICD, the impoundment pond had been in use for more than 20 years and contained more than 5 million gallons. Environmental regulation required the plant ...

  • EPA Study: 83% of diesel tanks have moderate to severe levels of corrosion

    The EPA has released the results of the largest survey to-date on corrosion levels in underground storage tanks (USTs) containing diesel fuel -- and the results are staggering. The research showed that 83 percent of the USTs studied exhibit moderate to severe corrosion. Worse, only 25 percent of the owners of those tanks with corrosion were aware of it prior to the study. ...


    By Tanknology Inc.

  • Town of Manhattan Wastewater Treatment Plant

    The Manhattan treatment plant is a 400,000 GPD plant in two trains, containing six 24 x 5.0 Bio-WheelTM. It is able to nitrify and denitrify, with two anoxic basins ahead of the aeration basins. Two conventional flight and scraper clarifiers are used. Three Penn Valley RA S/MLSS pumps are located in a separate pump room. The plant is designed for a future expansion to 0.8 MGD. At this time the ...


    By H2O Innovation

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you