fire-tube oil boiler Articles

  • Newtownabbey - oil fired boiler case study

    Customer: Ian Perris Location: Newtownabbey, N Ireland Heating System: Oil Fired Bosch Boiler Installed: 2007 This is a four bedroom 3,800 sq foot detached built in 2000. The owner installed the Vortex in 2007 as oil was on the rise and their energy usage was also increasing. Prior to fitting ...


    By Vortex Energy Saver

  • Pakistan SZS Gas Fired Steam Boiler

    Heavy Oil, Light Oil, Residual Oil, Natural Gas, City Gas, and Blast Furnace Gas can be used as Fuel. The boilers can also be applied to generate electricity at some districts where electricity power is in short. So are a variety of industrial productions, living and remote areas, and oil field. Even they can be used as a power plant boiler startup. SZS series oil & gas boilers are ...


  • Energy efficiency and emission reduction of TPM, PM2.5, and SO2 from natural gas and fuel oil fired boiler exhausts

    Fully 8% of all of Canada’s energy consumption occurs in gas and fuel oil fired boilers in commercial and institutional facilities1, with proportional amounts of greenhouse gases, particulate matter, and other pollutants. Recently particulate matter, and in particular that smaller than 2.5 microns (PM2.5) has garnered specific attention due to attributed health effects as demonstrated by ...

  • EPA finalizes boiler NESHAP

    EPA published the final National Emission Standards for Hazardous Air Pollutants (NESHAP) for industrial, commercial, and institutional boilers and process heaters at both major and area sources of hazardous air pollutants (HAP) emissions. EPA developed separate rules for units at major sources of HAP emissions (greater than 10 tons per year [tpy] of any single HAP and/or greater than 25 tpy of ...


    By Trinity Consultants

  • Monitoring flammable gas in boiler houses

    The most common fuels in use for space and water heating are Oil, Natural Gas and Liquid Petroleum Gas (LPG). By far the most popular, clean and cost effective solutions are utilising Natural Gas or LPG. The traditional safety measure derived from the time of oil fired boiler houses is the use of a fusible link placed above the each boiler. The fusible link is intended to melt if it becomes ...

  • Catalytic boilers with catalytic fluidised bed

    In this paper, conditions of work, special features and problems of boilers with catalytic fluidised bed are described. The specific conditions, when the catalyst layer remains stationary and granular or becomes spouting, are also considered. There are some main zones in the catalytic boilers with fluidised bed, which characterise such boilers and which must exist in them under normal working ...


    By Inderscience Publishers

  • EPA issues final rules for boilers

    The U.S. Environmental Protection Agency (EPA) reports that more than 200,000 boilers, process heaters and incinerators will be impacted by a set of Clean Air Act regulations issued on February 21, 2011. Since EPA first proposed the ...


    By Bergeson & Campbell, P.C.

  • Cumulative exergetic assessment of LPFO utilised steam boilers

    This paper relates to a study on the energy and exergy resources, transfers, consumption and losses in the combustion and heat exchanging units of industrial steam boilers. Mass, energy and exergy analyses, which included the physical and chemical exergies of material streams, were used to investigate the energy resource utilisation of Low Pour Fuel Oil (LPFO) in industrial steam boilers. The ...


    By Inderscience Publishers

  • The potential of energy conservation and emission reduction for the Chinese boilers

    With the publication of the coal convert to gas fired boiler policy, to control the pollution from the resource, all the provinces has removed, stopped and reformed to the high energy saving coal fired boilers. It is reported that there is a huge space in the energy saving and emission. low combustion, high energy saving potential the Chinese industrial boiler has a wide market,and most of them ...


  • Navigating NSPS subpart Db for boilers: a case study

    Over the past year, Trinity assisted a chemical company with the permitting and installation of a new 220 MMBtu/hr package boiler. The new natural gas-fired boiler replaces coal-fired units that were installed in the 1940s. Navigating through the numerous, and at times conflicting, regulatory requirements applicable to such a unit has been challenging. With careful planning and implementation, ...


    By Trinity Consultants

  • Heywoords - non condensing boiler case study

    Customer: John Hart Location: Heywards Heath, West Sussex Heating System: Open Vented Oil Fired Non Condensing Installed: 10/07 Property: 17TH Century house which had been added to over the years. Problem: A small 17th century cottage that had rooms ...


    By Vortex Energy Saver

  • Proposed boiler MACT sets aggressive emission limits

    On June 4, 2010, U.S. EPA proposed National Emission Standards for Hazardous Air Pollutants (NESHAP) for industrial, commercial, and institutional boilers and process heaters at both major and area sources of hazardous air pollutants (HAP) emissions.  EPA proposed separate rules for units at major sources of HAP emissions (greater than 10 tons per year [tpy] of any single HAP and/or greater ...


    By Trinity Consultants

  • New boiler MACT and affiliated rules proposed

    EPA proposed three related rules (with final rules expected by December 16, 2010), intended to reduce the emission of hazardous air pollutants (HAPs) from industrial, commercial, and institutional boilers and process heaters as well as commercial and industrial solid waste incinerators. Simultaneously, it also proposed a definition of solid waste that could potentially affect some units currently ...


    By Trinity Consultants

  • Common Boiler Feed Water Treatment Issues and How to Avoid Them

    When treating boiler feed water (the combination of boiler makeup and condensate return water), several issues can arise that cause boiler scaling, corrosion, fouling, and system failure. Below, we break down the most common boiler feed water issues and how to avoid them to help ensure system efficiency and operational safety. While treating boiler feed water is extremely ...


    By SAMCO Technologies, Inc.

  • Scaling vs. Corrosion: Why It Matters for Your Boiler Feedwater System

    When using boilers for an industrial plant and process, one of the most important things to implement is the appropriate treatment of the boiler feedwater before it has a chance to scale and corrode equipment. Before beginning any process with a boiler, understanding the makeup and return water chemistry/characteristics, the manufacturer’s requirements for the boiler (what pressure it ...


    By SAMCO Technologies, Inc.

  • MVC technology to recover oil from SAGD facility

    The Facility The SAGD Facility is called “Orion” and consists of 4 major processes: Steam Generation, Injection/Recovery Wells, Deoiling and Water Purification, for recovery of oil. The Players Aquatech will be working alongside Shell Canada (formerly BlackRock Ventures), the developer and IMV Projects, the integration engineers. ...

  • One of the largest ipp power plants in the middle east uses membrane desalination for boiler feed water

    The Facility Sidi Krir Unit 3 & 4 Power Plant, developed by InterGen and Edison SpA, is located about 30 kilometers west of Alexandria, Egypt. It is a natural gas fired power plant and at 685 MW generating capacity, is the largest IPP thermal power plant in the Middle East. The plant consists of two power blocks, which share a common membrane based Seawater Desalination system ...

  • Cost effective boiler makeup system using membrane desalination for power plant in dominican republic

    The Facility Andres Power Plant, developed by Caribbean Thermal Electric LLC, is located in Boca Chica, near Santo Domingo, Dominican Republic. It is a 300 MW gas fired combined cycle power plant and is one of the largest IPP power plants in the Dominican Republic and will supply electricity to Corporacion Dominicana de Electricidad. The plant consists of two power blocks, which ...

  • European Oil and Gas from Exploration to End User

    Made up of a team of senior specialists dedicated to innovation and dependability in the field of combustion technology; CS Combustion Solutions' (CS) staff use their 25 years of expertise in engineering, supplying and commissioning of vertical and horizontal combustors for a wide range of applications to find the best results for each individual requirement. "We are a company that specialises in ...

  • Estonia eager to teach world about oil shale

    AUVERE, Estonia (AP) — Home to the creators of Skype and the first country to use online voting, Estonia relishes its image as a technological pioneer. But the tiny East European country's most far-reaching economic achievement could come from how it has learned to squeeze oil from a rock. About 200 feet (60 meters) below ground in northeastern Estonia, very close to the Russian border, ...


    By Associated Press

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you