flare burner Articles

  • Performance of the low-emission flare

    Job report / Elbisgraben (Bale / Switzerland) The summer of 1992 had finally arrived. The 5MW low emission furnace in the district heating station Liestal was ignited, supplied with landfill gas from Elbisgraben landfill. Since then the plant has been running continuously and the comprehensive measurements taken, verify that all targets aimed at have been achieved: plant ...


    By Hofstetter BV

  • 1:60 Control Range with Flare

    Type     HOFGAS®- LPM 3000/2500  Performance     2,500 Nm³/h, 12,500 kW Location     Central England (GB) Initial Situation The landfill site is situated in the middle of the Sheffield region. Over time, the city limits and the landfill site have grown together. Therefore, the operator is particularly ...


    By Hofstetter BV

  • Development of Low noise landfill gas flare

    Summary: Increasing requirements of the environmental standards and planning permission conditions create more challenges to the equipment providers. Environment Agency guidance demands low emission levels and local planners put low noise levels in their conditions for landfill sites. Achieving both at the same time with conventional equipment was found problematic. Biogas Technology has ...


    By Biogas Technology Limited

  • 5000Nm3/h HT Flares in Sao João, Brazil

    Type      HOFGAS®-Efficiency 5000 Performance     3x 5,000 Nm3/h, 75,000 KW Location     Sao João (BR) Technical requirements Surplus combustion of 15,000 Nm3/h landfill gasCompliance with the UNFCCC regulationsHigh temperature combustion at 1,000-1,200°CHolding time ≥ ...


    By Hofstetter BV

  • Pollution reduction from flares by swirl vanes in a cross-flow

    The effect of swirl on the performance of a flare stack was experimentally investigated as a passive control technique for combustion in a cross-flow. The burner comprised a circular fuel nozzle with a co-annular airflow, swirled by a concentric vane swirler, with a crosswind of air at the flare tip. It was found that the flames issuing from swirl-vane flare tip were shorter and had wider flame ...


    By Inderscience Publishers

  • Up in Smoke – How the climate and our health suffer from flaring

    It’s like burning banknotes. Latest statistics from the World Bank (WB) indicate that the amount of gas flared each year is enough energy to supply electricity to several small countries or many millions of households. The flaring of 140 billion cubic metres (bcm) a year releases large quantities of greenhouse gases into the atmosphere – and that is not only bad news for the climate, ...


    By GLOBE Foundation

  • Case study - Landfill waste gas abatement

    For over 43 years Catalytic Products International has designed and manufactured specialized oxidation systems for use in controlling process-related VOC emissions. The QUADRANT-NRV Series Thermal Oxidation System is designed for use with the low-volume/high-BTU waste gas stream emitted from many landfill gas purification processes. As we utilize our Venturi Burner Package to process the waste ...

  • Low emission combustion of landfill gas

    Type     HOFGAS®- Efficiency 2000 (3x) Commissioning     July 2002 Site     Ämmäsuo Landfill (Espoo, FI)  SituationÄmmässuo landfill is located in Espoo, about 20 km from Helsinki. The landfill is the largest one in Finland and one of Europe’s largest. In order to reduce the greenhouse gas emissions and eliminate ...


    By Hofstetter BV

  • Expansion of waste water treatment plant, Switzerland

    Type     HOFGAS®- IFL2c Commissioning     2005 Site     WWTP Bern (Berne, Switzerland) Initial Situation The purification services provided by WWTP Region Bern so far are no longer adequate. The expansion project comprises new constructions, the new organic waste water treatment stage and the associated sludge liquor ...


    By Hofstetter BV

  • What do a brewery and a wastewater treatment facility have in common? More than you think

    You may think that a brewery and a wastewater treatment facility are about as similar as day and night, hot and cold, old and young. But they have more in common than you think. ABUTEC has worked with both to ensure their waste-to-energy systems function at top capacity. Bell’s Brewery in Kalamazoo, Michigan, needed a way to save money, ensure compliance and practice sustainability. ...


    By ABUTEC LLC

  • High temperature combustion of landfill gas

    Type     Compact plant HOFGAS® - Efficiency 250 Commissioning     December 2001 Site     Storkohmo landfill, Kokkola (FIN) Situation Storkohmo landfill is located 400km north of Helsinki on Finland's west coast near the city of Kokkola. Based on local legislation requirements ( reduction of green house gas emissions ) the ...


    By Hofstetter BV

  • High Temperature Combustion of Biogas

    High Temperature Combustion of Biogas Efficient combustion of biogas Controlled and concealed combustion Combustion temperature > 900°C Residence time more than 0.3 s Insulated combustion chamber High safety standard The HOFGAS® - IFL4c high temperature flare provides safe and environmentally-friendly combustion of biogas. The exhaust gas ...


    By Hofstetter BV

  • Biomass gassing as an effective source of energy

    Type     HOFGAS®- IFM4c 4000/2100 Performance     2100 Nm3/h / 3500 kW          Location     Limoges (FR) Situation A prestigious gassing plant for biomass is being built in the heart of France. The owner is promising himself a significantly higher level of efficiency through ...


    By Hofstetter BV

  • Large-scale application

    Type      HOFGAS®- Ready 2500 (2x) Commissioning      2002 Client      Cleanaway (Pitsea, GB) Situation The 2.8km2 big Pitsea landfill is located 50km east of London. It takes 2 to 3 years until the process of a landfill releases constantly gas. To compensate the initial unsteadiness, the 2 compact units ...


    By Hofstetter BV

  • Low emissions from large plants too

    Type     HOFGAS®- LPM 3000 Performance     3’000 Nm³/h, 15’000 kW Location     Scotland (GB) SituationEvery year, 150’000 tonnes of waste from Edinburgh, Lothian and the Borders Region are brought to the Dunbar landfill site. The waste is transported by rail to the site. In 2002, the UK Environmental Agency ...


    By Hofstetter BV

  • Safe disposal of exhaust gas from storage tanks in Finland

    Type     HOFGAS®--IPM 6500 and 4 xHOFGAS®- IFM4c 15000 Performance     Blower station 6,500 Nm³/h - Flare burner 4x1,650 Nm³/h / 4x15,000 kW Client     Neste Jacobs Oy (FI) Situation Every fortnight a tanker delivers oil from Russia to Finland. The tanker docks at the port of Naantali and the oil is conveyed to storage ...


    By Hofstetter BV

  • Maximizing Energy Recovery through Digester Gas Management System Enhancement

    ABSTRACTAdvanced anaerobic digestion practices and maximum energy recovery call for a digester gas system that reliably allows for complete biogas collection and utilization. This paper will describe the planning, design, and construction of a new digester gas management system at the East Bay Municipal Utility District’s (District) Main Wastewater Treatment Plant. The need for an upgraded ...

  • Treatment Options for Molten Sulfur Storage

    Documento sin título ...


    By Merichem Company

  • Why high temperature combustion of landfill gas?

    Due to the accumulation of knowledge and the tightening of environmental law, the landfill technology has increasingly become concerned with the management of trace compounds in landfill gas. With landfill gas, contamination is through sulphur, chlorine, fluorine, halogenated hydrocarbons and heavy metals. Other trace elements such as volatile organic compounds (VOC), impose environmental ...


    By Hofstetter BV

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you