flaring application Articles

  • Application of a Wireless Remote Monitoring System on a Landfill Flare Station

    ABSTRACT The Seminole Road Landfill flare station in DeKalb County, Georgia was previously equipped with an automatic telephone dialer system that contacted the operators of the flare via telephone when the flare station shut down and there were frequent flare station shut downs. During flare station shut downs all repairs required labor intensive response to physically visit the facility to ...


    By Weston Solutions, Inc

  • Greenstars portable monitoring for CHP and flares

    Greenstar’s award-winning KTK landfill site in Kilcullen, Co. Kildare, is unusual in Ireland in that it has three gas engines feeding electricity to the grid and two flares. In Ireland, while flaring is common, engines are not. The flares are run in tandem with engines so that if an engine is ramped down for repair or service, the flare ramps up automatically. All are supplied by 122 ...


    By Geotech

  • Assist Gas Measurement in Flare Stacks

    The Customer The company manufactures solvents, polymers and intermediary chemicals. These products are sold worldwide and are used in the production of automobile interiors, steering wheels, paints, tires, adhesives, furniture, cosmetics and many other consumer and industrial products. The Process The Company’s site is large, thousands of acres, ...

  • Development of Low noise landfill gas flare

    Summary: Increasing requirements of the environmental standards and planning permission conditions create more challenges to the equipment providers. Environment Agency guidance demands low emission levels and local planners put low noise levels in their conditions for landfill sites. Achieving both at the same time with conventional equipment was found problematic. Biogas Technology has ...


    By Biogas Technology Limited

  • Greenstars portable monitoring for CHP and flares case study

    Greenstar's award-winning KTK landfill site in Kilcullen, Co. Kildare, is unusual in Ireland in that it has three gas engines feeding electricity to the grid and two flares. In Ireland, while flaring is common, engines are not. The flares are run in tandem with engines so that if an engine is ramped down for repair or service, the flare ramps up automatically. All are supplied by 122 landfill gas ...


    By Geotech

  • Stacking up: flare Monitoring from LumaSense

    Lenny Shaver, LumaSense Technologies’ director of product management, explains the company’s IR and pyrometer technologies FLARING systems are common in many industries to burn gases before they enter the atmosphere. The safe operation of a flaring system requires the continuous monitoring of pilot flames and flared gases to ensure that vented gases are ignited. As ...

  • Extended exergy accounting applied to the flaring practice in oil fields

    An original procedure based on the Extended Exergy Accounting method is described and implemented in this paper. The goal is the quantification of the environmental externality linked to the chemical pollutants released by an elevated flare stack (SOx and NOx). The extended exergy calculations provide a measure of both the exergy flux ...


    By Inderscience Publishers

  • Case study - LFG pumping trials with Automatic Flare Systems (AFS)

    Application Landfill gas Equipment GA3000 Location United Kingdom Customer Automatic Flare Systems (AFS) Requirement Managing director at AFS, Steve Willacy said, “We want continuous landfill gas monitoring and analysis and to use a data logger to ...


    By Geotech

  • U.S. EPA Proposes Substantial Refinery Flare Operating and Monitoring Requirements

    U.S. EPA is proposing to amend the operating and monitoring requirements for flares at petroleum refineries.  The proposed revisions are complex and are far reaching, and if promulgated, will affect all flares at petroleum refineries.  U.S. EPA’s stated rationale for the proposed revisions is that the ...


    By All4 Inc.

  • Case study - Environmentally friendly vapor combustors, flares and incinerators

    Today’s industry requires innovative, cost competitive solutions to meet the ever growing and changing needs in the market. ABUTEC has developed a full line of “Environmentally Friendly” Vapor Combustors, Flares and Incinerators to meet these demands. The HTF (High Temperature Flare) and MTF (Medium Temperature Ground Flare) offer a flexible and scalable solution to clients in a ...


    By ABUTEC LLC

  • Measurement of Sulfur in Refinery Flare Gas Streams for Compliance with EPA SubpartJ(a) Regulations

    The Challenge Measurement of high range and low range H,S in refinery flare gas streams for compliance with EPA regulation NSPS Subpart J(a). The rule has placed an extra investment and operational burden on petroleum refineries to meet the regulatory requirement. AMETEK offers an economical solution to meet the challenge with an emphasis on lower capital and operating cost along with ...

  • Large-scale application

    Type      HOFGAS®- Ready 2500 (2x) Commissioning      2002 Client      Cleanaway (Pitsea, GB) Situation The 2.8km2 big Pitsea landfill is located 50km east of London. It takes 2 to 3 years until the process of a landfill releases constantly gas. To compensate the initial unsteadiness, the 2 compact units ...


    By Hofstetter BV

  • Oil refinery application case study

    This case study illustrates an application on an oil refinery. Main Reasons for use: Increase efficiency of production Reduce water consumption Reduce excess flaring of gases Background Fushun Oil Refinery No.2 is located in NE China. Fushun has 2 medium sized oil refineries both have installed Wap-Flaro for ...

  • Applications guide to mass flow measurement in the petroleum industry

    The measurement and control of gas flows in production, refinery, and R&D operations has a direct effect on efficiency, costs, safety, and environmental standards. Sierra mass flow meters and controllers pro- vide direct, fast-response measurement at all levels, to make any opera- tion more effective. Here is a brief summary of the advantages they offer the industry. Direct, Wide-Range ...


    By Sierra Instruments, Inc.

  • Green Energy Applications Guide to Flow Measurement

    Provides technical discussion and illustrations for nine (9) different green energy and green-house gas flow measurement applications.  Includes landfill gas, biomass fermentation, wastewater digesters, on-farm biogas recovery, ethanol production/refining, coal mine and coal bed methane (CMM, CBM), biomass gasification, flare gas and flue gas.  Discussion includes overview of each ...

  • Case study - ABUTEC 20 and ABUTEC 100

    Economical flaring solutions for low flow applications. The completely enclosed combustion allows for stack performance testing that isn’t available with traditional utility ...


    By ABUTEC LLC

  • Landfill gas analysis telematics in Slovenia case study

    Application Landfill - waste to energy Equipment AEMS Location Novo Mesto, Slovenia Customer AFS client, Minerva Žalec d.d Requirement The customer specified a 6-channel landfill gas analyser with secure online internet access for data transmission. ...


    By Geotech

  • Heating value

    The CustomerThis Chemical Company is a leading supplier of performance polymers. Their products are used in a wide range of applications including adhesives, coatings, consumer and personal care products, sealants, lubricants, medical, packaging, automotive, paving, roofing and footwear products. The ProcessThe company uses flare stacks to dispose of the waste products ...

  • The reduction of greenhouse gas emissions using various thermal systems in a landfill site

    In this paper, the Greenhouse Gas (GHG) emissions from an uncontrolled landfill site filled with Municipal Solid Waste (MSW) are compared with those from controlled sites in which collected Landfill Gases (LFG) are utilised by various technologies. These technologies include flaring, conventional electricity generation technologies such as Internal Combustion Engine (ICE) and Gas Turbine (GT) and ...


    By Inderscience Publishers

  • Management of organic content in municipal solid waste - a case study of Lahore

    Poor solid waste management (SWM) is one of the leading obstacles for absolute clean and healthy environment. Growing economy of Lahore has rapidly increased growth rate which in turn has flared solid waste generation. Municipal solid waste is contributing heavily to air, water and land pollution and a major portion of municipal waste is organic. Generally considered unfruitful, this organic ...


    By Inderscience Publishers

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you