high-rate biofilter Articles

  • Biofilter Applications in the Coatings Industry.

    Soaring energy costs and the high cost of ‘end-of-pipe’ pollution control equipment has caused companies and regulatory agencies to re-evaluate ‘unconventional’ means of achieving VOC and HAP emissions control. The coatings industry is an excellent candidate for alternative, unconventional controls, as VOC and HAP reductions have not been as strident as has been the case in many other industries. ...


  • Longer Life For Biofilters

    Biofilters are the odor control system of choice at composting facilities. Despite similar capital costs, the biofilters are generally less costly to operate than chemical scrubbers. The key to keeping operating costs in check, however, is to get the maximum use out of the biofilter media, thus avoiding the time and money needed to do media replacements. Allen Boyette, senior engineer and manager ...


    By BioCycle Magazine

  • Biofilter Applications in the Coatings Industry

    Soaring energy costs and the high cost of ‘end-of-pipe’ pollution control equipment has caused companies and regulatory agencies to re-evaluate ‘unconventional’ means of achieving VOC and HAP emissions control. The coatings industry is an excellent candidate for alternative, unconventional controls, as VOC and HAP reductions have not been as strident as has been the case in many other industries. ...


  • A High Performance Biofilter for Toluene Emission Control

    A high performance biofilter was designed at the Université de Sherbrooke in Québec. This laboratory-scale biofilter was used for the treatment of gas streams polluted with toluene present in low or high concentration. A maximum elimination capacity of 135 g.m -3 .h -1 was achieved, and no clogging of the biofilter was observed during the experimental period. The performance of the cleaning ...


  • High VOC Loadings in Biofilters - Petroleum and Industrial Applications

    ABSTRACTMore cost effective alternate technologies are needed to meet the demands of existing and upcoming Federal air regulations. Bio-Reaction Industries, Inc. (BRI) has developed a patented, modular, high-rate, vapor-phase biofilter that has provided such a solution for a major oil company for the past four years. This compact system has adsorbed and digested high VOC surge concentrations ...


  • Pilot-Scale Biofilter Test for Treating Zimpro Odors

    The thermal sludge conditioning process of U.S. Filter/Zimpro Corporation, Rothschild, Wisconsin (Zimpro process) is primarily used to improve dewatering characteristics of the waste sludge. The process entails a partial breakdown through oxidation and hydrolysis of complex, high molecular weight organic compounds, such as, proteins, fibers, carbohydrates, and fats. The partial breakdown of ...


    By PRD Tech, Inc.

  • Performance evaluation of an aerobic biofilter with high organics containing synthetic wastewater

    The organics removal performance of a lab-scale aerobic biofilter of volume 0.6 L was studied using synthetic wastewater and waste automobile tyre-tube beads as media. The column study was performed under Chemical Oxygen Demand (COD) in the range of 500-1500 mg/L at an empty bed contact time (EBCT) of 2 h. The treatability constant at 27°C was found to be 41.963. A maximum COD removal efficiency ...


    By Inderscience Publishers

  • Vapor-Phase Biofilters Show Promise for Treating High VOC Emissions.

    Evaluating the Feasibility of Natural AttenuationUsing natural attenuation to remediate organic compounds in groundwater has gained popularity. In some cases, this process can reduce contaminant levels to below risk-based corrective action criteria or regulatory standards without implementing additional remedial action alternatives. However, it is often difficult to prove that natural ...


  • Methane oxidation in water-spreading and compost biofilters

    This study evaluated two biofilter designs to mitigate methane emissions from landfill vents. Water-spreading biofilters were designed to use the capillarity of coarse sand overlain by a finer sand to increase the active depth for methane oxidation. Compost biofilters consisted of 238-L barrels containing a 1: 1 mixture (by volume) of compost to expanded polystyrene pellets. Two replicates of ...


    By SAGE Publications

  • Biofilter Removal of VOCs and Toxics from Airborne Emissions

    Abstract Sewage treatment plants can emit significant quantities of volatile organic compounds (VOCs) and toxic air contaminants, but emission control by conventional methods has been difficult to achieve. The biofilter technology developed in a previous contract can satisfactorily control emissions from these plants and possibly from other sources of high-volume, low-concentration emissions ...


  • Vapor-Phase Biofilters Show Promise for Treating High VOC Emissions

    Evaluating the Feasibility of Natural AttenuationUsing natural attenuation to remediate organic compounds in groundwater has gained popularity. In some cases, this process can reduce contaminant levels to below risk-based corrective action criteria or regulatory standards without implementing additional remedial action alternatives. However, it is often difficult to prove that natural ...


  • High performance of nitrogen and phosphorus removal in an electrolysis-integrated biofilter

    A novel electrolysis-integrated biofilter system was developed in this study to evaluate the intensified removal of nitrogen and phosphorus from contaminated water. Two laboratory-scale biofilter systems were established, one with electrolysis (E-BF) and one without electrolysis (BF) as control. The dynamics of intensified nitrogen and phosphorus removal and the changes of inflow and outflow ...


    By IWA Publishing

  • High VOC Loadings in Biofilters - Petroleum and Industrial Applications (PDF)

    More cost effective alternate technologies are needed to meet the demands of existing and upcoming Federal air regulations. Bio-Reaction Industries, Inc. (BRI) has developed a patented, modular, high-rate, vapor-phase biofilter that has provided such a solution for a major oil company for the past four years. This compact system has adsorbed and digested high VOC surge concentrations (over 90,000 ...


  • Comparison of the biological NH3 removal characteristics of a three stage biofilter with a one stage biofilter

    A three stage and a one-stage bench-scale biofilter with effective heights of 129 cm filled with same type of packing material were operated at different influent concentrations of ammonia in order to investigate their performance in treating waste gas streams. The columns contained a mixture of municipal compost inoculated with thickened municipal activated sludge as a base material and shredded ...

  • High Rate Biological Odour Control Demonstration for Biosolids Exhausts

    Abstract Biorem has successfully demonstrated its high rate odour control system for biosolids exhausts at Ashbridges Bay sewage treatment plant in Toronto, Ontario. The demonstration used XLD™, a biofiltration media engineered specifically for biosolids odours. The system has achieved 95% odour removal in less than 20-s Empty Bed Residence Time (EBRT) despite high concentration of ...


    By Biorem Technologies Inc.

  • A Comparison of an Organic Biofilter and an Inorganic Biofilter for the treatment of Residual odors emanating from a Biosolids De-Watering facility

    The following paper is a comparison of an organic media biofilter and a synthetic media biofilter for the treatment of residual odors emanating from the operation of a biosolids dewatering and truck loading system at the City of Toronto's Ashbridges Bay Treatment Plant. The system compared was an in-ground, header/lateral system operated in a forced draft, up flow, open top configuration. The ...


    By Biorem Technologies Inc.

  • High rate Biological odour control system - Case Study

    ABOUT THE PROJECT Biorem has conducted a successful demonstration of high rate odour control at Preston Wastewater Treatment Plant in Cambridge, Ontario over the last three years. The system treats exhausts from primary clarifier and intermediate pump station. A combination of biotrickling filtration (BTF) and biofiltration (BF) processes was used in a novel horizontal flow ...


    By Biorem Technologies Inc.

  • Numerical modeling of nitrogen removal processes in biofilters with simultaneous nitritation and anammox

    This study developed a simple numerical model for nitrogen removal in biofilters, which was designed to enhance simultaneous nitritation and anaerobic ammonium oxidation (anammox). It is the first attempt to simulate anammox together with two-step nitrification in natural treatment systems, which may have different kinetic parameters and temperature effects from conventional bioreactors. ...


    By IWA Publishing

  • Performance of a biofilter system with agave fiber filter media for municipal wastewater treatment

    Agave plants grow in semi-arid regions and are used for mescal production. However, agave fiber by-products are considered waste materials. Thus, we tested agave fiber as a filter media and biofilm material carrier for removing pollutants from municipal wastewater. Three laboratory-scale biofiltration reactors were used in two trials with five hydraulic loading rates (HLRs = 0.27, 0.54, ...


    By IWA Publishing

  • UrbanGreen BioFilter Provides Cost-Effective Solution for Public Schools

    Low Impact Development Solution for Salem-Keizer Public Schools Salem, Oregon - In November of 2008, voters within the Salem-Keizer Public School district passed a $242.1 million school construction ...

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you