leak sealing Articles

  • Saline Pond Multi-Layer Liner System - Case Study

    Gas operation benefits from the conversion of a single-liner system to a double-liner with leak detection monitoring Extensive gas operations near the North Saskatchewan River in Fort Saskatchewan, Alberta, are understandably closely regulated. To help the client remain well above compliance requirements and expand their leak detection capabilities, Nilex implemented the ...


    By Nilex

  • Troublesome leaks

    Blowers and Vacuum Pumps employed in evaporator systems have problems with frequent leaks. This includes both the internal and external sealing systems. Beginning with 2016, following numerous tests, CONCES offers all end users of evaporators, new solutions for blowers of various manufactures. A well-sealed Blower and Vacuum Pump guarantees ultimate efficiency  of your sewage treatment ...


    By Conces

  • Designing With Geosynthetic Clay Liners

    In construction, preventing the penetration of liquids and gases is essential to maintaining the integrity of a structure. Often, containment is just as important, especially when dealing with chemical contaminants or other waste. When looking to stop the spread of contaminated liquids and gases, there are few tools as effective as geosynthetic clay liners (GCL). Read on to learn how to design ...


    By Agru America, Inc.

  • Secondary Oil Containment at US Army Corps of Engineers - Big Bend Dam - Case Study

    Big Bend Dam takes its name from the unique bend in the Missouri River seven miles upstream from the dam. Construction of the dam began in 1959 and the embankment was completed in July 1963. Big Bend dam is 95 feet (29 m) high and 10,570 feet (3,220 m) in length. Power generation began at the facility in 1964 and the entire complex was completed by 1966. The hydroelectric plant generates ...


    By Albarrie Canada Limited

  • Closer Look at the Capacity of SLA Batteries and Solar Energy Systems

    Sealed lead acid (SLA) batteries have a reputation for being durable when used to support portable electronic devices. They require minimal maintenance and offer leak-proof capabilities. But when used with solar energy systems, the units present issues that can hinder the potential and performance of the machines. For example, general purpose SLA batteries should not be deep cycled, as ...


    By Larson Electronics LLC

  • The way to Cease Roofing Leaking

     Roofing leakages can happen to acquire a quantity of factors. These people usually start out smaller than average grow over amount of in time so that you can larger difficulties. Nevertheless, a good tiny roofing spill could cause main injury to your home. Besides building wet spot locations by yourself accomplished ceilings, best leaking might lead to mold and mildew growth in addition to ...


    By Ultimate Linings

  • Canal sealing with Bentofix case study

    After the first pilot project installation of a geosynthetic clay liner (GCL) in a 1 km long section of the Havel-Oder-Waterway in 1997/98, approved by the local German Water and Ship Authority a second project followed shortly after. In a 500 m long section of the Dortmund-Ems-Canal a newly developed innovative GCL was installed under water. The installed GCL was Bentofix BZ 13-B, a ...


    By NAUE GmbH & Co.KG

  • Leak Detector Lithium Ion Battery

    Lithium ion batteries have been in the news quite a lot recently, and not all of it has been positive. There have been numerous incidents of different products from airplanes to hoverboards to mobile phones catching fire during charging or operation.  These problems occur when there has been damage to the cells’ structure or to the protective circuit.  The protective circuit ...


    By Restek Corporation

  • DESMI’s Magnetically Powered Pumps Seal the Deal

    For companies pumping dangerous or expensive chemicals, leaks can endanger both personnel and the bottom line. Hermetically sealed, magnetically powered pumps are the state-of-the-play answer. The list of potentially dangerous or simply-too-expensive-to-lose substances being pumped from one part of an industrial process to another somewhere in the world is long. Take isocyanates, for example. ...


    By DESMI A/S

  • Seal Fireplace Dampers With Weatherstripping to Conserve Energy

    Introduction When fireplaces are not being used, they should be sealed with weatherstrip to air seal the damper and prevent wasted energy. The common perception should be that just like doors and windows, fireplaces require weatherstripping to prevent energy loss. Leaking Fireplace Dampers Waste Energy Fireplaces are the largest intentional opening in the ...


  • Temperature and leak monitoring boosts safety and reliability

    Amcor Flexibles Singen GmbH is a manufacturer of printed and unprinted aluminum-based packaging materials and an experienced technical applications specialist. Its plant in Germany, equipped with rolling mills and finishing equipment, turns out approximately 200 million square meters of aluminum foil in various grades every year. High-performance drying equipment is essential for Amcor’s ...


    By ALLWEILER GmbH

  • Leaks and spills - LNAP and DNAPL detection and clean up

    Any tank can leak. Most leaks can be cleaned up and responsible operators need equipment that does what’s needed. With an ATEX Zone 0 certified interface meter site operators can successfully achieve LNAP and DNAPL detection when monitoring petrochemical sites, tank farms, petrol station forecourts, landfills or remediation sites. If site technicians detect ...


    By Geotech

  • Exterior coatings producer blends abrasives with no shaft seal wear

    Since its founding in 1987, contractors have applied over 100 million square feet of Master Wall Inc. products — stucco, coatings, and exterior insulation and finish systems (EIFS) — on residential, commercial and industrial buildings. Master Wall founder and president Steve Smithwick says the company's Aggre-flex EIFS system is "one of the most common commercial cladding in the ...

  • GE Leakwise Application Notes: Leak Detection for a Floating Roof Oil Storage Tank

    Oil Storage Tank with a Floating Roof Floating Roof Drainage Operation Stormwater accumulated on a concave floating roof of an oil storage tank may affect its floatation, making it necessary to immediately drain the water. This is usually done through a flexible pipe, running from the floating roof down the tank, with an outlet above the ground near the bottom of the tank. ...


    By GE Analytical Instruments

  • QuadOa and OGI: how EPA regulations are changing the way we look at gas leaks

    Earlier this year, the Environmental Protection Agency (EPA) published Regulation 40 CFR, Part 60, Sub-part OOOOa, commonly known as Quad Oa, and finally brought optical gas imaging (OGI) firmly into the mainstream. This presents a major shift in the way fugitive emissions are regulated, and the technology that can be used.  Detecting and acting on gas leaks is naturally a major ...

  • EPA studies identify techniques for critical leak testing prior to soil-vapor sampling

    Researchers at EPA’s National Risk Management Research Laboratory (NRMRL) in Ada, OK, are developing quality assurance (QA) measures for soil-gas and sub-slab sampling methods that help differentiate contaminant vapors due to vapor intrusion from background sources. Recent research focused on measures to identify leakage of ambient air into conventional vapor probes, which can significantly ...

  • Is your Plant as tight as you think? Leak Detector for extremely toxic Gases, a Field Test Report

    Leak detection of commodity gases in chemical plants is a day-to-day practice. The sensor technology available for this application is field proven and reliable. No question about it, existing sensors will do the job. However, in plants manufacturing or handling extremely toxic substances, the picture is different. For example, take phosgene. The existing sensor technology for leak detection ...

  • STOP IT Metals & Minerals - Case Study

    From a Mine in Illinois: STOP IT® was used on a rubber hose that had a hole approximately 3/8' wide × 3' long. The hose was 12' in diameter and carried magnetite and water. Four rolls of 4'×12' STOP IT® were used to seal this leak. Quote: 'This pipe was approximately eight feet from the pump and is under a lot of pressure and also moves under pressure. Repairing this hole ...


    By InduMar Products, Inc.

  • STOP IT Refineries & Petrochemical - Case Study

    Major Southern Refinery in Mississippi: STOP IT® was used on a 3/4' diameter galvanized pipe carrying steam condensate. The operating pressure was 135psi with a temperature of 200°F. They used two rolls of 2'×4' STOP IT® to seal the leak. Quote: 'Thanks for providing a quick and economical fix for leaks that do not lend themselves to clamps. Provides time until system shutdown ...


    By InduMar Products, Inc.

  • Great Island Tank 4 and bund refurbishment - case study

    Lining works to refurbish the existing tank farm secondary containment bund and HFO Tank 4 are ongoing at Great Island CCGT project. Lining Tech are contracted in to Balfour Beatty Ireland on this design and build project for the client Tank 4 Works Installation of 1,140m2 of 1mm HDPE leak detection liner to the floor of HFO tank 4 Fabrication and installation ...

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you