light recovery separation system Articles

  • Separation principle of decanting centrifuge

    KOSUN DC series decanting centrifuge is used in separating suspension of solids phase with particle diameter(d≥2μm) for drilling mud and fluids handling. Ruggedly built for oilfield and industrial services, it is especially effective in environmentally sensitive areas. It delivers high fluid-recovery rates and ...


  • Free-Product Recovery Methods and Issues

    During my 33 years in the environmental field, I have been involved in a lot of sites with free product.  In the 1980’s light non-aqueous phase liquids (LNAPL) such as gasoline were removed by the following methods: Bailing with a hand bailer from a well Pumping with a 2 pump system (depression pump and product pump) Pumping with a total fluids pump and separating ...


    By Enviro-Equipment, Inc.

  • Refinery remediation: fuel recovery and recycling

    Introduction The site is a former refinery that occupied approximately 64 acres of land in West Texas. Refinery operations produced all grades of gasoline, tractor fuels, diesel, distillate products, and fuel oils and operated between 1939 and 1954. As a result of past waste management practices, releases to soils and ultimately ground water occurred, resulting in the formation of a ...

  • Integrated solar and wind energy powers oil recovery system

    Recovery of free-product petroleum at the former St. Croix Alumina (SCA) site in Kingshill on St. Croix, VI, is addressing ground-water contamination caused by past releases of fuel and refined petroleum at SCA. The oil recovery system employs wind-driven turbine compressors (WTCs), wind-driven electric generators (WEGs), and photovoltaic (PV) panels to power pneumatic and electric submersible ...

  • Analytical Solutions for Free-Hydrocarbon Recovery using Skimmer and Dual-Pump Wells

    Accidental release of petroleum hydrocarbons to the subsurface may occur through spills around refineries, leaking pipelines, storage tanks or other sources. If the spill is large, the hydrocarbon liquids may eventually reach a water table and spread laterally in a pancake-like lens. Hydrocarbons that exist as a separate phase are termed light non-aqueous phase liquids (LNAPL). The portion of the ...


    By QED Environmental Systems

  • Green Light for Recycling – Biogas has an exciting future - Case Study

    The tipping lorry of the container vehicle moves up. In minutes, its load of food residue is emptied and starts its course to energy recovery. "Energy for tomorrow" is the slogan of the Danpower Group for a reason. Danpower sees the biogas sector as a key growth factor for the future. Twenty five biogas plants are currently in operation, one of which is in Bad Köstritz/Thüringen. ...


    By HSM GmbH + Co. KG

  • Liquid-phase non-thermal plasma-prepared N-doped TiO2 for azo dye degradation with the catalyst separation system by ceramic membranes

    This study strived to improve the photocatalytic activity by using liquid-phase non-thermal plasma (LPNTP) technology for preparing N-doping TiO2 as well as to separate/recover the N-dope TiO2 particles by using ceramic ultrafiltration membrane process. The yellow color N-doped TiO2 photocatalysts, obtained through the LPNTP process, were characterized with UV–Vis spectroscopy, X-ray diffraction ...


    By IWA Publishing

  • Austin AI QXR-M – Technology to improve metal recovery from non-ferrous residues

    Existing technology has been used for some time to separate light non-ferrous alloys from heavier non-ferrous alloys; however, over the past three years, there is a significant added value in performing additional separations to recover specific high dollar alloys. Examples of such are separating pure copper from copper alloys (brass and bronze) or wrought from cast aluminum. The only way to do ...


    By Austin AI, Inc.

  • Ivey-sol technology has potential to increase oil recovery of oil-sands waste by 15-25 percent

    Alberta’s oil sands are comprised of one of the world's largest sources of bitumen, containing an estimated 1.6 trillion barrels. About two tonnes of oil sands must be dug up and processed to produce one barrel of oil. Oil sands recovery processes include extraction and separation systems to remove bitumen from sand and water. Separating the oil from the sand is difficult and costly, and getting ...


    By Ivey International Inc.

  • Common challenges relative to the use of Decanter Centrifuges for barite recovery in the oil & gas industry

    When centrifuges are properly deployed, they can have dramatic effects on drilling performance. In fact, without them, many of the advances made in drilling would not have been considered achievable. Classically, we believe that centrifuges can achieve two common goals: Reduce the content of drilled fines, specifically colloidal solids, and Perform barite recovery in order to reduce ...


    By Elgin Separation Solutions

  • Lowmac Alloys Recycling Services - Case Study

    Alloys offer a broad range of recycling services, to companies all over the west of Scotland, from their two main bases at Irvine and Ayr. The company needed a two-phase upgrade of their existing facility to handle an increasing and diverse workload, which included metal recovery, fines extraction, wood, hardcore, hard plastics, ferrous and non-ferrous materials among others. This demanded a ...

  • Lowmac Alloys upgrades Recycling Services - Case Study

    Lowmac Alloys offer a broad range of recycling services, to companies all over the west of Scotland, from their two main bases at Irvine and Ayr. The company needed a two-phase upgrade of their existing facility to handle an increasing and diverse workload, which included metal recovery, fines extraction, wood, hardcore, hard plastics, ferrous and non-ferrous materials among others. This ...

  • Do not make the waste energy saving lamps into a scourge

    As early as August 1, 2008, the national list of hazardous waste had been the recovery of the energy saving lamps included. However, for waste energy saving lamps may harm caused to the environment and human health, the public did not know. Until now, energy saving lamp recycling policy is still blank. How future waste disposal? Than ordinary incandescent lamp,  ...

  • Alcázar de San Juan Waste Management plant, Spain - Case Study

    The Alcázar De San Juan Waste Management Plant Now Has Four Titech Autosort Units The latest remodeling of the Municipal Solid Waste (MSW) Management Plant in Alcázar de San Juan (Ciudad Real, Spain) includes two new TITECH autosort 4 optical sorting units. Overview The Municipal ...


    By TOMRA Sorting (TITECH)

  • Changing from manual to automated tank cleaning saved time and money case study

    At ESSO’s Fawley Refinery in the UK, the cat slurry tanks were in need of cleaning. Two main objectives were outlined for the project: Minimum downtime and minimum waste generation. The BLABO automated system proved its strength on both accounts. Over time, the Fawley Refinery cat-fines sludge tanks had built up calalytic fines strata and consolidated sediments at the bottom. A thorough ...


    By Oreco A/S

  • Basic Aspects of Carpet Steamers and Its Right Use

    Carpet steamers are powerful cleaning systems that expertly utilize the cleaning action of steam to thoroughly clean carpets, eliminate germs, and remove all types of foul odors emanating from carpets. These rug wash systems are unmatched when it comes to eliminating dried deposits and grease stuck on carpeted surfaces. For best results, you must understand how to use these machines the right ...


    By Daimer Industries Inc.

  • Centralised treatment of oil sludge and other industrial waste

    Centralised treatment of various sources of industrial waste has been established in many European countries over the last decade. Many facilities are still equipped with non state of the art technology and therefore cannot fulfil the broad field of applications with regard to industrial waste remediation. econ's international client decided to be one step ahead and erected a new econ industries ...


    By econ industries GmbH

  • Usen

    “Oil is not only an important sector of our industry but also a symbol of the independence of our country, of the hope for a better future”. These were the words of President Nursultan Nasarbayev in September 1999, commemorating the 100th anniversary of the formation of the oil and gas industry. The oil industry in Kazakhstan has existed for more than 100 years, however a significant boom in this ...


    By Flottweg SE

  • Centralised treatment of oil sludge and other industrial waste - case study

    Centralised treatment of various sources of industrial waste has been established in many European countries over the last decade. Many facilities are still equipped with non state of the art technology and therefore cannot fulfil the broad field of applications with regard to industrial waste remediation, econ's international client decided to be one step ahead and erected a new econ industries ...


    By econ industries GmbH

  • Coke Manufacturing Industry - Pollution Prevention Guidelines

    Introduction Pollution Prevention Guidelines to provide technical advice and guidance to staff and consultants involved in pollution-related projects. The guidelines represent state-of-the-art thinking on how to reduce pollution emissions from the production process. In many cases, the guidelines provide numerical targets for reducing pollution, as well as maximum ...


    By The World Bank

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you