liquid odor control Articles

  • Selection of Bioreactor Media for Odor Control

    The support media is one of the most critical elements of a biofiltration system. In this chapter, biofilters and biotrickling filters will be referred to as “biofilter”, and this distinction will be discussed later in this chapter. The support media’s main function is to provide contact between the gas-phase contaminants and active microbial cultures either immobilized within and/or attached as ...


    By PRD Tech, Inc.

  • How Tempe Controls Manhole Odors

    Untitled Document Summary: The adjacent cities of Tempe and Mesa, Arizona, rely on a combined wastewater collection system comprising 434 miles of sanitary sewer lines and more ...


    By Calgon Carbon Corporation

  • Integrated Odor Control for Solids Handling Operations

    Untitled Document Solids handling operations and solids holding facilities are often major sources of odor at wastewater treatment ...


    By Calgon Carbon Corporation

  • Food Processing: Odor Control in Edible Oil Processing

    Abstract: The problems with odor around a typical edible oil deodorizer are discussed in detail, and a three-step solution to eliminate these problems is presented. The three steps are a distillate recovery system which recovers most of the fatty acid in the deodorizer vapor discharge as a valuable byproduct, a closed loop barometric cooling water system which keeps the fatladen ...


    By CR Clean Air Group, LLC

  • Reducing Odor and VOC Emissions

    The Montgomery County Regional Composting Facility (MCRCF) in Silver Spring, Maryland is designed to process 400 wet tons/day of lime amended biosolids from the Blue Plains Wastewater Treatment Plant (WWTP) in Washington, D.C. Recently, political pressures forced operations to cease at the MCRCF. Although the aerated static pile composting plant’s fate has not been completely decided, its owner, ...


    By BioCycle Magazine

  • Case study - Asphalt plant odor control in North Carolina

    Challenge A hot mix asphalt plant located in a rural area of Xorth Carolina has a community of neighbors living approximately a quarter mile away that began complaining about odors from the plant. The plant typically has several trucks a day arriving at the plant to offload liquid asphalt, with a volume that fluctuates depending on workload. The general amount of liquid asphalt ...


    By OMI Industries (OMI)

  • A breath of fresh air - Wet scrubbing eliminates odors associated with processing discarded liquid from cheese manufacturing

    When International Ingredient Corp.’s drying plant in Monroe, WI, opened in 1994, it was the first plant designed specifically for large-scale drum drying of dairy products for the feed industry. At that time, its only neighbor was a cheese producer. International Ingredient used a land spread technique to process the discarded liquids resulting from its neighbor’s cheese ...


    By Bionomic Industries Inc.

  • A breath of fresh air - Wet scrubbing eliminates odors associated with processing discarded liquid from cheese manufacturing.

    When International Ingredient Corp.’s drying plant in Monroe,WI, opened in 1994, it was the first plant designed specifically for large-scale drum drying of dairy products for the feed industry.At that time, its only neighbor was a cheese producer. International Ingredient used a land spread technique to process the discarded liquids resulting from its neighbor’s cheese manufacturing process. ...


    By Bionomic Industries Inc.

  • Controlling level of toxic liquids for the foam industry case study

    Solid provides a durable solution for level controlling of toxic liquids, using the SmartScan 50L ultrasonic measurement gauge. Polymers Ashkelon Industries located in the city of Ashkelon, is a major supplier of foam for the furniture and mattresses industry in Israel. The company has a long-standing reputation in manufacturing of foam in various shapes and sizes for mattresses, furniture and ...

  • Case study - Covering lagoon stops odor complaints

    Problem: United Liquid Waste Recycling of Watertown, Wisconsin, recycles food and beverage waste into valuable byproducts such as fertilizer. Odors from the anaerobic treatment process needed to be stopped to enable the company to expand. Two lagoon anaerobic digesters needed an affordable odor control system, which had to function whether the lagoons were full or empty. ...

  • Compact scrubber for biosolids odors saves $500,000

    A new scrubber at a Camden, NJ bio solids processing facility uses advanced technology to cut the cost of odor control. The system was designed, built and installed by Bay Products with process design assistance from Lantec Products. A single tower is used to remove malodorous gases from air in two stages having separate sumps for the recirculated scrubbing solutions. The lower stage absorbs ...


    By Lantec Products, Inc.

  • Treatment of unpleasant odors in municipal wastewater treatment plants

    The purpose of this paper to present a case study on how to address the odor problem from secondary sources within a municipal wastewater treatment plant (WWTP) by first identifying the locations of the problem and second by evaluating alternative treatment technologies. The WWTP of Chania is a typical 100,000 equivalent inhabitants-facility in a warm semi-arid environment which is located close ...


    By IWA Publishing

  • Mariposa compost facility odor remediation update

    Staring in the winter of 2006 the staff at the Mariposa Compost Facility worked quickly to make process changes to bring odor issues under control. Here is the latest chapter in their story. Odor (incident) Logs In January 2007 the Local Environmental Agency (LEA) provided "odor logs" to the county residents that were troubled by the compost facility's odors. The odor logs were ...


    By Engineered Compost Systems

  • Pilot-Scale Biofilter Test for Treating Zimpro Odors

    The thermal sludge conditioning process of U.S. Filter/Zimpro Corporation, Rothschild, Wisconsin (Zimpro process) is primarily used to improve dewatering characteristics of the waste sludge. The process entails a partial breakdown through oxidation and hydrolysis of complex, high molecular weight organic compounds, such as, proteins, fibers, carbohydrates, and fats. The partial breakdown of ...


    By PRD Tech, Inc.

  • Innovative Q-PAC® packed two stage odor control scrubber saves $500,000

    Two stages in one 12 ft (3.7 m) tower treat 68,500 cfm (116,400 m3/hr) using high-capacity packing A new scrubber at a Camden, NJ biosolids processing facility uses advanced technology to cut the cost of odor control. The system was designed, built and installed by Bay Products with process design assistance from Lantec Products. A single tower is used to remove malodorous gases ...


    By Lantec Products, Inc.

  • Lift Station Odor Control Using CARUSOL Treating a Wastewater Collection System in a Mid-Western Township - Case Study

    Summary A mid-western township is responsible for operating and maintaining a combined sewer collection system consisting of 150 miles of pipeline and 28 pumping stations. The township does not treat the wastewater, instead contracting with a neighboring city for this service. The township has two final lift stations that transfer the collected wastewater to the neighboring system ...


    By Carus Corporation

  • Case study - Wastewater lagoon cover stops odor complaints

    Problem: United Liquid Waste Recycling (ULWR) successfully recycles food and beverage waste into valuable by-products such as fertilizer. Odors from their anaerobic treatment process needed to be stopped to enable ULWR in Watertown Wisconsin to expand. Their two lagoon anaerobic digesters needed an affordable system to control odors. ULWR injects their valuable fertilizer into farm fields twice ...

  • Helping Laurel Asphalt to Fight Foul Odors and Be Good Neighbors

    One of the unavoidable byproducts of the asphalt production process is a mixture of volatile hydrocarbons, mercaptans, hydrogen sulfide, and heat, which may cause a unique mixture of foul odors. When this happens, many asphalt producers have to contend with neighboring residents – often homes and businesses – that bring their odor complaints to both the media and local town-hall ...


    By OMI Industries (OMI)

  • Bio-augmentation process reduces odors and organic sludge build-Up

    Efficiently operating a wastewater treatment plant within budget and permit limits gets more challenging by the day! Plant administrators are constantly facing the battle of costly sludge disposal, noxious odor control and rising electricity expense. The City of Meridian, Mississippi also fell into this category until it made the decision in 2005 to utilize a product marketed by Reliant Water ...


    By Reliant Water Technologies

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you