mact boiler Articles

  • Boiler MACT Remand Request Granted

    On February 28, 2014, U.S. Environmental Protection Agency (U.S. EPA) requested a remand without vacatur of the set of rules commonly referred to as the Boiler Maximum Achievable Control Technology (MACT) rules. U.S. EPA has also requested a remand of the Commercial and Industrial Solid Waste Incineration (CISWI) rules. On May 15, 2014 ...


    By All4 Inc.

  • Tuning Your Boiler for EPA Boiler MACT Compliance

    The EPA’s Boiler MACT regulations are heating up. Boiler MACT is an EPA rule to limit hazardous air pollutants (HAP) from commercial and industrial boilers and process heaters. Originally proposed in 2011 as a mandate driven by the Clean Air Act,  the rules are Area Source Boiler MACT 40 CFR 63, subpart JJJJJJ for smaller boilers (stores, hotels, apartments, ...


    By Sierra Instruments, Inc.

  • Boiler mact compliance at Boise Wallula case study

    Lundberg Helped Boise Wallula Reduce Emissions with a Geoenergy E-Tube WET ESP A major pulp and paper supplier in the northwest was in need of a cost effective solution to reduce their particulate emissions from a biomass fired boiler. Lundberg provided a Geoenergy Wet ESP to meet their needs. The result was a ten fold decrease in particulate emissions and they now meet current Boiler MACT ...

  • Proposed boiler MACT sets aggressive emission limits

    On June 4, 2010, U.S. EPA proposed National Emission Standards for Hazardous Air Pollutants (NESHAP) for industrial, commercial, and institutional boilers and process heaters at both major and area sources of hazardous air pollutants (HAP) emissions.  EPA proposed separate rules for units at major sources of HAP emissions (greater than 10 tons per year [tpy] of any single HAP and/or greater ...


    By Trinity Consultants

  • Bionomic Boiler MACT Emission Control Technologies

    Introduction Bionomic Industries' extensive line of field-proven, cost effective wet and dry scrubber and electrostatic technology choices can easily and economically help you achieve compliance with EPA Boiler MACT regulations for hydrochloric acid, particulate or mercury control. Bionomics' wide range of equipment enables selection of the best control technology to remove a specific or ...


    By Bionomic Industries Inc.

  • New boiler MACT and affiliated rules proposed

    EPA proposed three related rules (with final rules expected by December 16, 2010), intended to reduce the emission of hazardous air pollutants (HAPs) from industrial, commercial, and institutional boilers and process heaters as well as commercial and industrial solid waste incinerators. Simultaneously, it also proposed a definition of solid waste that could potentially affect some units currently ...


    By Trinity Consultants

  • The Wait Is Over; The New Boiler MACT Is Here

    The Wait Is Over; The New Boiler MACT Is Here    April 29, 2010 was a busy day for U.S. EPA and marked the culmination of months and years of background effort and planning related to air toxic emissions from boilers.  U.S. EPA has released pre-publication versions of four (4) proposed rules on their website that, when finalized, will impact thousands of ...


    By All4 Inc.

  • Boiler mact - what the new emissions limits on industrial boilers mean for you

    Generically known as “Boiler MACT”, the new possible industrial boiler limits directly address emissions of Hazardous Air Pollutants (HAPs) from industrial boilers and indirectly address the way that industrial sources operate their boilers. This white paper explains how Boiler MACT affects you and how to maintain operating flexibility while addressing compliance issues. The most ...

  • Utility MACT and HAPs

    C 6.1  | The Utility MACT Rule: An Industry Perspective Michael  Rossler |  Manager, Environmental Programs, EEI EPA is proceeding with the Utility MACT rulemaking for coal- and oil-based EGUs. The ...

  • Cementing the PC MACT

    On September 9, 2010, the U.S. EPA promulgated the final amendments to the National Emissions Standard for Hazardous Air Pollutants from Portland Cement Manufacturing Industry (40 CFR 63 Subpart LLL), also known as the PC MACT. EPA’s self-proclaimed “historic” rulemaking includes some important implications for cement manufacturers and other sources that may be subject to ...


    By Trinity Consultants

  • Widespread Applicability and Energy Assessment highlight the Proposed New Boiler MACT Rules

    As we reported in last month’s 4 The Record, April 29, 2010 was a busy day for U.S. EPA and marked the culmination of years of background effort and planning related to air toxic emissions from boilers. U.S. EPA has proposed four (4) rules that, when finalized, will impact thousands of facilities. Two (2) of these rules are intended to reduce emissions of toxic air pollutants from boilers ...


    By All4 Inc.

  • How to Get the Most Out of Your Boiler MACT Energy Assessment

    Congratulations!  You’ve made it through the first year of planning for compliance with the Major and Area Source Boiler MACT rules.  That means there are two years left for major sources to come into compliance by January 31, 2016 (or January 31, 2017 for those who requested and received a one-year extension), and just ...


    By All4 Inc.

  • Major Source Boiler MACT Compliance with Oxygen Trim Systems

    The National Emission Standards for Hazardous Air Pollutants (NESHAP) for Major Sources: Industrial, Commercial, and Institutional Boilers and Process Heaters promulgated at 40 CFR Part 63, Subpart DDDDD, commonly referred to as the Major Source Boiler MACT (MSBM) standards, provide multiple continuous compliance options that require monitoring.  Among these options is the use of a ...


    By All4 Inc.

  • EPA Proposed “Franken-MACT” for Utilities

    EPA published the highly anticipated proposed Maximum Available Control Technology (MACT) Standard for the utility sector (40 CFR 63 Subpart UUUUU). When considered together with the growing list of proposed and final rules impacting the utility sector (Transport Rule/Cross-State Rule, Coal Combustion Byproducts Rule, Cooling Water Intake Rule, Regional Haze Rule, revised National Ambient Air ...


    By Trinity Consultants

  • INTO THE VOID...U.S. EPA`s recent boiler MACT and CISWI information collection request

    Background - The United States Court of Appeals for the District of Columbia Circuit (court) has been quite busy in the last few years hearing environmental cases, particularly air quality related topics. On June 8, 2007, the court vacated and remanded two (2) U.S. EPA rules promulgated under the Clean Air Act (CAA)-The Commercial and Industrial Solid Waste Incineration (CISWI) definitions rule ...


    By All4 Inc.

  • The Hammer Falls Again as U.S. EPA Proposes Revisions to `MACT Hammer` Regulations

    Until now, States have been left to interpret the applicability of section 112(j) with little input from U.S. EPA. Some States have adopted a “wait and see” approach and are waiting for U.S. EPA to weigh in on the issue. In the absence of any guidance, some States, such as Pennsylvania, have called for some sources to submit applications that meet the 112(j) requirements. The ...


    By All4 Inc.

  • EPA finalizes boiler NESHAP

    EPA published the final National Emission Standards for Hazardous Air Pollutants (NESHAP) for industrial, commercial, and institutional boilers and process heaters at both major and area sources of hazardous air pollutants (HAP) emissions. EPA developed separate rules for units at major sources of HAP emissions (greater than 10 tons per year [tpy] of any single HAP and/or greater than 25 tpy of ...


    By Trinity Consultants

  • Emission Performance Results for a Liquid Waste Incinerator upgraded to meet the HWC MACT Standards

    Abstract Eastman Chemical Company operates three hazardous waste incinerators at its facility in Kingsport, Tennessee, one liquid waste incinerator and two rotary kilns. The air pollution control systems for these incinerators are being upgraded to meet the MACT standard for existing hazardous waste incinerators. The upgraded air pollution control systems include a vertical, rapid-quench ...


  • Emissions Performance Results for a Liquid Waste Incinerator Upgraded to Meet the HWC MACT Standards

    ABSTRACT Eastman Chemical Company operates three hazardous waste incinerators at its facility in Kingsport, Tennessee, oneliquid waste incinerator and two rotary kilns. The air pollution control systems for these incinerators are beingupgraded to meet the MACT standard for existing hazardous waste incinerators. The upgraded air pollution controlsystems include a vertical, ...


  • EPA issues final rules for boilers

    The U.S. Environmental Protection Agency (EPA) reports that more than 200,000 boilers, process heaters and incinerators will be impacted by a set of Clean Air Act regulations issued on February 21, 2011. Since EPA first proposed the ...


    By Bergeson & Campbell, P.C.

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you