odor control process Articles

  • Food Processing: Odor Control in Edible Oil Processing

    Abstract: The problems with odor around a typical edible oil deodorizer are discussed in detail, and a three-step solution to eliminate these problems is presented. The three steps are a distillate recovery system which recovers most of the fatty acid in the deodorizer vapor discharge as a valuable byproduct, a closed loop barometric cooling water system which keeps the fatladen ...


    By CR Clean Air Group, LLC

  • Case study - Meat processing odor control

    Overview For its first two years of production, a food manufacturer based in South Wales, England, focused its production on potatoes. Neighborhood residents voiced no complaints about odors during this time period. However, as new production lines (including barbequed meats and curried chicken) were added, the complaints began, and it became clear that odor abatement equipment was needed ...

  • Landfill Closure - Odor Control

    Products & Equipment Used: Pneumatic Foam Unit 1600/40 AC-645 Long Duration Foam AC-904 Long Duration Foam Application summary: The Michigan Department of Natural Resources required an emissions control measure during the closure of an Ann Arbor Solid Waste Landfill cell. The odors that were emanating from the landfill during ...


    By Rusmar Inc.

  • Odor Control Advances at Composting Facility

    The Rockland County (New York) Cocomposting Facility began operations in February, 1999, processing biosolids from the five publicly owned treatment works (POTWs) in the county. The Rockland County Solid Waste Management Authority (RCSWMA) owns the facility, but contracted with Waste Management of New York to design, build and operate (DBO) the 110 wet tons/day agitated bin composting facility ...


    By BioCycle Magazine

  • Control of biosolids cake odors using the new biosolids odor reduction selector process

    ABSTRACT Recent introduction of more efficient dewatering devices that generate higher solids concentrations in dewatered cake has been plagued with the non-desirable side effect of more odorous dewatered biosolids. Previous research has shown that the production of volatile organic sulfur compounds (VOSC’s) such as methanethiol (MT), dimethyl sulfide (DMS), and dimethyl disulfide (DMDS) ...

  • Iowa pork processing plant eliminates waste water treatment odor and reduces odor control costs

    The Problem - Increasing encroachment by new neighbors began causing problems for an Iowa pork processing facility. Though the plant had been there for more than 20 years, new neighbors complained about odors stemming from the waste treatment and composting operations at the plant. The "loud" and frequent complaints of the neighbors brought tremendous regulatory pressure down on the facility. ...


    By Benzaco Scientific, Inc.

  • Integrated Odor Control for Solids Handling Operations

    Untitled Document Solids handling operations and solids holding facilities are often major sources of odor at wastewater treatment ...


    By Calgon Carbon Corporation

  • Mastertaste Savors the Benefits of Cost-Effective Odor Control

    The aromas from savory flavors are detectable even at low concentrations, and pose special challenges for companies who manufacture or use them.    Mastertaste, (Clark, N.J.) a Division of Kerry Group plc, is a leader in the development and production of savory flavors and blended seasonings.  As part of a plant expansion, Mastertaste needed a system to eliminate odors from ...


    By Tri-Mer Corporation

  • Wastewater-Solids Dewatering Odor Control - Case Study

    Background The Milan Wastewater Treatment Plant, located just south of Moline, Illinois, is a 1.7 MGD (6,434 m3/day) activated sludge facility with an average wastewater flow of 700,000 gpd to 800,000 gpd. This facility dewaters primary sludge using a belt filter press (Figure 1). The press operates an average of three times per month, 8 hours per day at a pump rate of 100 gpm. The ...


    By Carus Corporation

  • Case study - Controlling odors at a specialty plastics manufacturer

    Challenge A specialty plastics manufacturer in the eastern United States makes a plastic compound that, because of its unique and desirable properties, is widely used in the automotive industry. Complications arose for this manufacturer because, in the production process, mercaptans are driven off and produce a non-hazardous but offensive nuisance odor problem. The ...


    By OMI Industries (OMI)

  • Manufactured Gas Plant - Odor and VOC Control

    Products & Equipment Used: AC-645 Long Duration Foam AC-904 Long Duration Foam Pneumatic Foam Unit 400/25 Application Summary: Rusmar Long Duration Foam products have been used at numerous manufactured gas plant facilities. Often, tanks containing coal tar were filled with soil and other debris from the site before being ...


    By Rusmar Inc.

  • Controlling Odors from Waste Water Treatment Plants

    INTRODUCTION In recent years, there is growing public awareness of odors from waste water treatment plants, which mainly stems from the following observed trends: The public is less tolerant of objectionable odors from waste water treatment plants; Many waste water treatment plants have seen residential, commercial, or other developments established near the facility ...


    By PRD Tech, Inc.

  • Odor Control System Addresses Community’s Complaints

    The Customer: The Water Pollution Control Authority (WPCA) of the City of Bridgeport, Connecticut, operates two wastewater treatment facilities and maintains the city’s sewer system. The Customer’s Needs: After years of operating successfully in the community, the City of Bridgeport’s WPCA developed an odor problem at its East Side ...

  • Options in Odor Control - New Alternatives and Traditional Technologies

    Untitled Document Summary: The control of odorous emissions from sewage treatment facilities has long been a major issue, especially for facilities located close to ...


    By Calgon Carbon Corporation

  • Town Branch WWTP Controls Odors with Modular Covers

    The Customer: The Town Branch Wastewater Treatment Plant located in Lexington, Kentucky, USA, serves a population of 130,000—about 60 percent of Lexington-Fayette County. The plant began operating in 1919, and currently treats almost 11 billion gallons of wastewater annually. The Customer’s Needs: The Town Branch Wastewater Treatment Plant ...

  • Biotreatment of Organic and Inorganic Odors

    Air emissions from manufacturing operations and waste treatment plants often consist of a combination of odors and volatile chemicals. Odors are inorganic or organic compounds, which are present in low concentrations, typically 20 ppmv or less, which have an unpleasant odor. Volatile chemicals are often present at higher concentrations than odors, but may or may not have any odors associated with ...


    By PRD Tech, Inc.

  • Smart Series-Odor Management

    Tackling odors at composting facilities is a manageable task made simpler by inventorying and treating all sources and tapping into technology advances. Perhaps one of the most difficult realities that had to be faced 15 to 20 years ago by the composting universe is that the phrase, “odor-free” - at least when it comes to composting - is probably an oxymoron. Feedstocks that biodegrade within the ...


    By BioCycle Magazine

  • Reducing Odor and VOC Emissions

    The Montgomery County Regional Composting Facility (MCRCF) in Silver Spring, Maryland is designed to process 400 wet tons/day of lime amended biosolids from the Blue Plains Wastewater Treatment Plant (WWTP) in Washington, D.C. Recently, political pressures forced operations to cease at the MCRCF. Although the aerated static pile composting plant’s fate has not been completely decided, its owner, ...


    By BioCycle Magazine

  • Bio-Solids Process Enhancements Resulting From the Use of Hydrogen Peroxide for Hydrogen Sulfide Odor Control - The San Antonio Experience

    ABSTRACTThe paper will present results of a trial initiated in February 2004 by the San Antonio Water System (SAWS) to quantify the impacts of hydrogen peroxide injection prior to dissolved air flotation thickening of wastewater sludges. Since February 2000, the San Antonio Water System has successfully used iron salts (FeSO4) for odor and ...

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you