pipe rehabilitation process Articles

  • Water Main / Fire Line Rehabilitation

    Problem Dirty brown water and poor water flow were the first clues that a mid-Atlantic commercial property owner had a problem. Then the owner was put on notice by the local fire department that the water supply lines were no longer meeting the required flow requirements. Four hydrants on the owner’s property were flowing between 200 to 300 gallons per minute due to heavy corrosion-induced ...


    By CuraFlo

  • Rehabilitation of Hydrogen Grooving in Sulfuric Acid Line

    Around October 2001, one of the major petrochemical refineries located on the Texas Louisiana Gulf coast needed to rehabilitate 6' and 8” diameter “fresh acid” (98% sulfuric acid) lines. Such lines tend to suffer from internal gouging due to formation of hydrogen gas in voids, which are caused by turbulence at directional changes in the pipe flow such as elbows, etc. This is a natural event, ...


    By InduMar Products, Inc.

  • Trouble Shooting for Trenchless Liner Installation During Sewer Line Rehabilitation

    ABSTRACTLining is being used by the utility industry as a cost effective solution to rehabilitate utility lines. Many types of liners, such as, cured-in-place-pipe (CIPP), fold and form PVC, deformed & reformed HDPE, etc., are being used to restore structural integrity of deteriorated pipes and to reduce inflow/infiltration. Most of the lining installation is carried out without any problem, ...

  • Thermal Power - Rehabilitation of Existing Plants Industry - Pollution Prevention Guidelines

    Introduction Pollution Prevention Guidelines to provide technical advice and guidance to staff and consultants involved in pollution-related projects. The guidelines represent state-of-the-art thinking on how to reduce pollution emissions from the production process. In many cases, the guidelines provide numerical targets for reducing pollution, as well as maximum ...


    By The World Bank

  • Quantitative pipe condition assessment with Pipe Penetrating Radar

    Abstract Pipe Penetrating Radar (PPR) is the underground in-pipe application of GPR, a non-destructive testing method that can detect defects and cavities within and outside mainline diameter (>18 in / 450mm) non-ferrous (reinforced concrete, vitrified clay, PVC, HDPE, etc.) pipes. The key advantage of PPR is the unique ability to map pipe wall thickness and deterioration including voids ...


    By SewerVUE

  • Combined application of Pipe Penetrating Radar and LIDAR for large diameter pipe inspection

    Abstract: Pipe Penetrating Radar (PPR) is the underground in-pipe application of ground penetrating radar (GPR), a non-destructive testing method that can detect defects and cavities within and outside mainline diameter (>18 in./450mm) non-metallic (reinforced concrete, vitrified clay, PVC, HDPE, etc.) underground pipes. Light Detection and Ranging (LIDAR) has become an accepted method for ...


    By SewerVUE

  • Process to Estimate Sanitary Sewer Pipe Remaining Life Provides MWWSSB Remedial Decision Information

    ABSTRACTA condition assessment study for the Water Works and Sanitary Sewer Board of the City of Montgomery’s (MWWSSB’s) West Catoma Interceptor (WCI) was conducted in 1998 and 2003. The WCI was evaluated in 1998 using core sampling, closed-circuit television, and manhole (MH) inspections. Approximately 193 MHs and 65,000 linear feet (LF) of pipe were inspected. A subsequent study conducted in ...

  • Unique technology for monitoring piped water

    INTELLITECT WATER has launched a unique, highly innovative drinking water monitoring technology that will revolutionise the delivery of drinking water. The new technology monitors the quality of water in pipeline distribution networks and for the first time provides reliable data to protect the integrity of the water quality, to enhance customer satisfaction and to improve operational efficiency. ...


    By Intellitect Water Ltd

  • 5 Considerations for Choosing Pipe Bursting

    Homeowners who encounter sewer, drain, and water line problems often dread repairs not just because of the expense, but the major disruptions that they expect. Excavation, torn up lawns, and days of going without water are associated with traditional methods of repair. Fortunately, technology has made it possible to assess and fix pipes with minimal disruption by using a technique called pipe ...


    By TRIC Tools Inc.

  • Company Introduces New Pipe Repair Products

    InduMar Products, Inc., based in Houston Texas, celebrates twenty years of providing pipe repair and rehabilitation solutions to their industrial and marine customers. Well known for their versatile STOP IT® Pipe Repair System the Company also takes pride in offering custom solutions for many pipe leak, reinforcement and corrosion problems. The combination of sealant development and ...


    By InduMar Products, Inc.

  • STOP IT® Pipe Repair System helps keep companies on line

    Since 1986, InduMar Products Inc. has provided a unique solution for the fluid processing industries with the STOP IT Repair System. Refineries, chemical plants, pulp and paper mills and the mining industry all have pipes carrying products that are often highly flammable, toxic or corrosive and the STOP IT system provides a method to restore product and profit flow in minutes instead of the many ...


    By InduMar Products, Inc.

  • A multi-step genetic algorithm model for ensuring cost-effectiveness and adequate water pressure in a trunk/limb mains pipe system

    A water distribution network is the most expensive component of a water supply system; consequently, the overall planning, installation, and rehabilitation processes should be implemented accurately and carefully. The main issue that developing countries are facing is how to optimize the distribution network to meet increasing water demand. To tackle the issue, this paper proposes a new concept ...


    By IWA Publishing

  • Delivering an Enhanced Sewer Condition Prioritization Process

    SCREAM™ is a sewer and manhole condition assessment tool developed by CH2MHill. It has been built into Wallingford Software’s InfoNet asset management solution as one of the standard choices for sewer and manhole condition grading. There is emphasis across the collections systems industry worldwide for sewer condition prioritization methods and manhole condition ranking. Although currently the UK ...


    By Innovyze

  • Multi-sensor inspection robot shows benefits of pipe penetrating radar - Case Study

    Pipe penetrating radar (PPR), the in-pipe application of ground penetrating radar (GPR) is one of the most promising quantitative pipe condition assessment technologies to emerge in recent years. With most of the underground pipe infrastructure reaching the end of their design life there is a need to provide measurable data in order to establish the extent of rehabilitation required or the timing ...


    By SewerVUE

  • Got deteriorating asbestos cement water mains?

    Asbestos has come to be one of the most feared words and materials in the world. Yet, in the 1940s, 1950s and 1960s, more than 600,000 miles of asbestos cement– also called transite – used for its light weight, corrosion resistance, rigidity, ease of handling and installation was installed to handle water throughout the United States. Applications included potable water mains, storm ...

  • Looking for Clues: Hamilton Demonstrates Value of Condition Assessment Program During Investigation of Critical Watermain

    In late 2015, the City of Hamilton, Pure Technologies (Pure) and Robinson Consultants worked together to perform an external investigation of a pipe section in the Woodward Greenhill Transmission Main (WGTM) to gain understanding of what was causing degradation in a specific geographical area. A 2014 condition assessment ...


    By Pure Technologies

  • City Of West Palm Beach Reaches Out To Community With Proactive Approach To Manage Critical Force Main

    The City of West Palm Beach (WPB) makes a concerted effort to engage its citizens. As one of the three largest cities in South Florida, WPB is a vibrant, growing waterfront community with a population of more than 100,000. Since 1974, WPB has experienced exponential growth in its population and correspondingly, in its wastewater ...


    By Pure Technologies

  • Incorporating Condition Assessment into a Comprehensive Asset Management Program

    ABSTRACTIn order to improve asset investment decision-making and achieve sustainable improvements in business performance, utilities must better understand asset condition, asset performance, remaining life and risks. Worldwide, annual expenditure on the maintenance and rehabilitation of water/wastewater reticulation pipes is estimated to be over $33 billion per year, and this is expected to rise ...

  • Reducing Ruptured Reputations – Assessment Tools Reduce Risk of Failure on Sewer Force Mains

    A ruptured sewer pipe can attract a lot of unwanted attention, even when it happens on private property. Last year, hours before celebrities were to arrive at the Golden Globes Awards show at the Beverley Hills Hotel, a reputed sewer pipe burst, spewing a mess of wastewater on the red ...


    By Pure Technologies

  • Atlanta upgrades to InfoWorks CS to aid environmental program

    The City of Atlanta, Georgia, in the USA, has purchased InfoWorks CS to help it meet stringent US Environmental Protection Agency (EPA) and Georgia State Environmental Protection Division (EPD) requirements for discharge of its wastewaters to the Chattahoochee River. The Chattahoochee, one of the smallest rivers in the US supplying a metropolitan area, provides 80% of the city’s water needs. ...


    By Innovyze

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you