process monitoring system Articles

  • Train derailment prompts contaminated land investigation - Case study

    On March 30th 2015 a long freight train, transporting a variety of goods including lumber and chemicals, wound its way through the state of Mississippi. At around 5pm, part of the train failed to negotiate a curved portion of the track in a rural area near Minter City, resulting in the derailment of nine railcars, one of which leaked chemicals onto agricultural farmland and woodlands. Emergency ...


    By Gasmet Technologies Oy

  • Integrate noise measurements into your existing Process Monitoring and Control Systems.

    The ZE:908 is a small and lightweight power supply and acoustic conditioning unit for the Cirrus MV:200 microphone preamplifiers and MK:170 Outdoor microphone units. Many industrial plants have a variety of process sensors strategically placed around their site so that safety, environmental impact and efficiency can be monitored and managed, in real time, from one or more control rooms. The ...


    By Cirrus Environmental

  • Real-time process dynamics monitoring in Anammox reactors

    Process dynamics in Anammox systems were evaluated through continuous monitoring of pH, oxidation reduction potential (ORP) and conductivity in two separate newly started-up sequencing batch reactors, one seeded with an enriched Anammox sludge and the other seeded with mixed activated sludge. The pH and ORP profiles exhibited characteristic patterns depending on the process dynamics during early ...


    By IWA Publishing

  • Monitoring the performance of moisture purifiers for process gases

    Problem Statement Moisture purifiers are a big aid in keeping moisture levels under control inside a process chamber. They are provided by manufacturers with certain life expectancies, which vary depending on the moisture content of the gas being purified. As a result, it is difficult to determine which gases have a high moisture content and which moisture purifier is becoming ...


    By CIC Photonics, Inc.

  • Continuous monitoring of moisture present inside a process chamber

    Problem Statement Moisture inside a process chamber is a big silent killer during wafer production. When production yield goes down, it is hard to pinpoint the source of the problem. Most of the time wafers need to be sent to labs for analysis, while production is stopped. If the problem is related to a high level of moisture inside the reactor, there are several factors that can cause ...


    By CIC Photonics, Inc.

  • Gas Detection and Monitoring Systems

    In greenhouse applications, the accurate measurement of a number of environmental parameters such as carbon dioxide concentration, temperature, light intensity, water, humidity, pH and nutrient levels using sophisticated sensors is used to create a controlled environment for optimising plant growth rates while minimising energy usage. Carbon dioxide concentration is also one of the best ...


    By Edinburgh Sensors Ltd

  • The Evolution of Collector Monitoring Systems

    The vast majority of chain and flight collectors in operation throughout the world do not have any form of monitoring system installed to protect against operational failure. Traditional safety devices consist of a shear pin sprocket device, with a limit switch, designed to protect the drive system if a load or torque exceeds the working load of the  ...


    By Brentwood Industries, Inc.

  • Managing continuous emissions monitoring systems

    With recent rulemaking governing compliance determinations in regards to the emissions of nitrogen oxides (NOx) and highly reactive volatile organic compounds (HRVOCs), the Texas Commission on Environmental Quality (TCEQ) required more frequent monitoring which resulted in the installation of more monitoring systems at the facility. This large Gulf Coast refinery decided to utilize the ...

  • Managing Continuous Emissions Monitoring Systems

    Untitled Document With recent rulemaking governing compliance determinations in regards to the emissions of nitrogen oxides (NOx) and highly reactive volatile organic compounds ...


    By Trinity Consultants

  • Monitoring for sustainable development: a systemic framework

    'Sustainable development' is a widely used, but less practised, complex term. Using the idea of 'Viability Loops' (VL) based on a System Dynamics (SD) approach and considering sustainability as an ideal for development efforts, this paper argues that sustainable development should be considered as an unending process rather than a state. Thus, a systemic framework is proposed to 'monitor' systems ...


    By Inderscience Publishers

  • Sterilization System Monitors Temperature and Humidity

    CAS DataLoggers recently provided the temperature and humidity datalogging solution for a decontamination and sterilization facility using Ethylene Oxide (EtO) preconditioning rooms as part of its painstaking safety process. The environment within these rooms needed to be continually monitored for both safety and quality assurance purposes, and the huge ...


    By CAS DATALOGGERS

  • Area monitoring of specific ppb-level constituents utilizing process gas chromatography

    ABSTRACT In most of the industrialized countries worldwide, increasingly stringent environmental regulations require the continuous reduction of a wide range of emission sources and components. Despite local variations concerning concentrations, absolute emission quantity, target priorities and timetables, regulations typically require active compliance and proof thereof. The impact of ...

  • Online Process Analyzer Installed at F.J. Horgan WTP to Monitor Chloramination

    Construction was completed on the City of Toronto's F.J. Hor-gan Water Treatment Plant in 1979, more than 60 years after chloramine had first been used to disinfect drinking water in an Ottawa plant. By then there was little debate about the benefits of chloramination and it was incorporated into the new plant's design as part of the disinfection process. Chloramine is more stable than free ...


    By ASA Analytics

  • New CCTV systems improve security and process monitoring at Corus Group’s UK-based steelmaking plants

    Although closed circuit television (CCTV) systems are commonplace in today’s society, many manufacturing companies have yet to take full advantage of their capabilities, not only as security devices, but also as an aid to monitoring critical processes or machines within a production environment. Corus Northern Engineering Services (CNES), the asset management and condition monitoring arm of ...


  • Modular treatment system neutralizes process water

    A self-contained pH control and monitoring sys- tem for ready mixed operations yields clean water for recycling or permitted discharge to the environment. Fortrans' Model 5000S uses car- bon dioxide gas to neutralize high-pH process water, offering precise alkalinity monitoring and control of water in pits, settling basins and other containment areas, as it lowers total suspended solids. Designed ...


    By Fortrans, Inc.

  • Monitoring Databases

    EHS Data have been providing software and services to our clients to help them manage and report on their Environmental, Health and Safety Data for more than 14 years. This paper deals with the global evolution in environmental concerns and how this changes the data management obligations and requirements of companies. ...


    By EHS Data Limited

  • Collini metal processing plant

    Introduction The submerged membrane bioreactor plant at Collini galvanic industries in the West of Austria is a fine example of process optimization in a complex industrial environment. The plant is owned and operated by Collini and is now in its 3rd year treating wastewater from a metal processing facility. It is sited in an industrial estate and discharges into a small waterway in an ...


    By Kubota Membrane Europe Ltd.

  • Processing technology for radioactive wastes

    For 20 years now, AVA has been delivering innovative mixers, dryers, and systems for environmental and processing technologies. The treatment of highly contaminated materials has always been one of our core competencies. For more than 10 years, AVA Technology has been applied for the processing of radioactive wastes. The application of AVA mixers and reactors may be divided into two main ...


    By AVA GmbH u. Co. KG

  • Optimising logistic processes with rapidM2M

    When delivering products, it is crucial to keep an eye on GPS positions, delivery dates as well as the quality of the products. Machine-to-Machine technology enables you to do so from your office desk. rapidM2M is a technology specially developed for the simple realisation and stable operation of Machine-to-Machine solutions and enables to transmit important data like GPS positions or ...

  • Typical process weighing applications

    Process weighing relates to the weighing of a powder material as part of a production process. The technology includes continually monitoring a material in a silo, discharging material by weight or rate, or even weighing products on the move. This article gives an overview of most of the typical process weighing applications that are used in all sorts of industries: level or inventory measuring ...


    By Hardy Process Solutions

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you