produced water treatment system Articles

  • Produced water treatment technologies

    Abstract Produced water is a complex mixture of organic and inorganic compounds and the largest volume of byproduct generated during oil and gas recovery operations. The potential of oilfield produced water to be a source of fresh water for water-stressed oil-producing countries and the increasing environmental concerns in addition to stringent legislations on produced water discharge into ...

  • Pulp & Paper Water Treatment - A look at optimizing water resource management

    Application Case Study (Pulp/Paper Operations) The pulp and paper industry has traditionally been a consumer of large amounts of fresh water and power. Recently, increased focus has been given to the optimized efficiency of paper mills and to the environmental sustainability footprint of the industry. Therefore, water resource management has become a more critical factor ...

  • Water treatment in a pinch - installing a temporary produced water polishing system

    An oil company experienced produced water treatment system upsets and CETCO Oilfield Services was chosen to deliver and operate a temporary treatment system until problems with the permanent installation could be resolved. CETCO Oilfield Services personnel and equipment arrived on the platform, set up their reliable produced water polishing system, and began operations. CETCO personnel were on ...


    By CETCO Energy Services

  • Talisman - produced water treatment to <30 ppm

    Client: Talisman Buchan Alpha - UK Following successful trial work, CETCO supplied a single 48” CrudeSep® vessel skid to treat produced water for discharge overboard. Talisman then purchased a second 48” CrudeSep vessel skid to further reduce its overboard oil in water discharges in line with regulations. CETCO’s CrudeSep system treated approximately 12,000 bbls/d of produced water on the Buchan ...


    By CETCO Energy Services

  • BP Petrojarl Foinhaven - produced water treatment

    Client: BP/PGS Petrojarl Foinaven - UK CETCO were approached by BP/PGS regarding potential fluids handling problems on the Petrojarl Foinaven FPSO when bringing on two new wells during September 2001. CETCO mobilised a RFV 4000 DF Adsorption Skid containing CETCO’s patented CrudeSorb® media to treat the oily water phase of the well returns for discharge directly overboard. During a two week ...


    By CETCO Energy Services

  • Advanced Water Treatment and Evaporation Systems Produce High Efficiency

    AQUATECH IS CHANGING THE GAME in the water recycling industry through its SmartMOD Modular Evaporator System and HEVAP High Efficiency Evaporation Process for SAGD Water Treatment. For over 30 years, the company has focused exclusively on desalination, water reuse, and zero liquid discharge with water purification technologies suited for global industrial, upstream and ...

  • Produced water treatment from a to Zinc - reducing levels of Zinc in a produced water stream

    Problem At vast depths, the ocean floor consists of layers of decaying plant and animal matter, containing chemicals like sulphate and zinc, which has built up over the years. When operators are drilling, the matter is disturbed and the various chemicals are released into the water. Since the mid 1980’s the pace of exploration, production, and development in the deep waters of the Gulf of Mexico ...


    By CETCO Energy Services

  • Case study - Veolia MPPE Technology - TOTAL F 15A Offshore - NL

    Offshore Gas Produced Water treatment-Unmanned Operation Operational since 2002 Robust against salt, surfactants, Corrosion inhibitors Fulfilling TOTAL’s environmental goal beyond present legal requirements Challenge Unmanned operation Remote control Practically no space on existing ...

  • Determining Proper Cooling Tower Size

    To maximize water-based cooling tower benefits, the appropriate tower size must be selected, requiring the identification of several critical factors. Cooling towers are a relatively inexpensive and reliable way of expelling heat from a number of industrial processes, including nuclear & thermal power plants, petroleum refineries, petrochemical plants, food processing plants, as well as HVAC ...


    By Delta Cooling Towers, Inc

  • Case study - Procurement and installation of a Biogas desulphurization unit at the Chania WWTP

    A proposal based on Bioconservacion’s technology was selected as the winning bid in the public tender released in 2015, covering the design, procurement and construction of a biogas desulfurizing unit to be installed in the waste water treatment plant in Chania, Greece. With a population over 100,000, Chania is the second largest municipality in the Greek island of Crete. Its waste water ...


    By Bioconservacion SA

  • Evaluation of hybrid treatments to produce high quality reuse water

    Four tertiary hybrid treatments to produce high quality reused water, fulfilling Brazilian drinking water regulations, from a slaughterhouse's secondary treated effluent were evaluated. The pilot plant with a capacity of 500 L h−1 was set up and consisted of these stages: pre-filtration system (cartridge filter 50 micron, activated carbon filter, cartridge filter 10 micron), oxidation (H2O2) or ...


    By IWA Publishing

  • MPPE for Vermilion (Total) Harlingen Gas Produced Water treatment case study

    MPPE for removal of: Dispersed oil (aliphatics) Dissolved and dispersed aromatics (BTEX, PAHs) Since June 1994 Produced water from offshore gas Condensed water from glycol regeneration unit Dissolved and dispersed aromatics (BTEX): 1,500 – 2,500 ppm → < 0.5 ppm Dispersed oil (dispersed ...

  • Cooling Water System at Major Canned Food Producer in the United States

    Cooling operation for canning line replaces stabilized bromine and achieves greater biological control. LOCATION Tomato Canning Plant in California, USA EQUIPMENT & CHEMISTRY Vault M15 MIOX’s Mixed Oxidant Solution (MOS) PREVIOUS DISINFECTION Bromax 7.1 (Stabilized Bromine) ...


    By MIOX Corporation

  • New process for Reusing produced wastewater

    Abstract: In November 2002, a new facility at the Liaohe Oilfield in Liaoning Province, China was commissioned to treat 20,000 m3/day of produced wastewater. The aim of the process is to provide water quality which is suitable as feed water for the high pressure, once-through steam generators. The performance during the first 8 months of operation has been demonstrated. Due to the unique ...


    By Eco-Tec Inc.

  • Treatment of coal bed methane produced water using short bed ion exchange

    Abstract: The water produced during the recovery of natural gas from coal beds, coal bed methane - CBM, is often a major problem in developing this resource. A pilot study of a short bed ion exchange process treating CBM produced water is presented. The paper will discuss background issues related to CBM produced water, alternate treatment methods, short bed technology, pilot plant test data, and ...


    By Eco-Tec Inc.

  • A clear solution - hiflow process for produced water treatment delivers outstanding results for Taylor energy

    Taylor Energy, which specializes in energy exploration and production in the Gulf of Mexico, utilized CETCO Oilfield Services new Hi-Flow technology to increase oil and gas production in a field where the existing facility was at capacity with the amount of produced water it could handle. The two phase Hi-Flow process works to treat produced oilfield wastewater by separating/adsorbing the small ...


    By CETCO Energy Services

  • VSEP filters produced water, saving money while protecting the environment

    Every few years, Oil companies will reevaluate new technologies on the market for oily wastewater treatment. Technological improvements have been especially significant in the area of membrane filtration. New Logic Research has developed a proprietary membrane filtration system that is uniquely suited for treatment of Produced Water, Barge and Bilge Water, and Drilling Mud. The use of a ...


    By New Logic Research, Inc.

  • GWT Case Study - Produced Water - Oil/Gas Industry

    GWT Case Study - Produced Water  Treatment/Reuse - Oil/Gas Industry Challenge A large oil processing company wanted to reuse their produced water from several oil wells applications. The water contained hydrocarbons, sulfate, TSS, BOD/COD, dissolved salts and high levels of iron ...

  • Produced water recovery at Seneca Resources using short bed ion exchange

    As a result of water restrictions in the Bakersfield, California area Seneca Resources has installed a new produced water recovery system. The paper reviews this process, which consists of water knock out and clarification tanks, an IGF unit, a specialized nutshell filter, and a short bed ion exchange softener that is regenerated with salt. The water being treated has a TDS level of 4,000 - ...


    By Eco-Tec Inc.

  • StatoilHydro Kollsnes - MPPE for removing toxic load of gas produced water

    MPPE for removal of: Dispersed oil (aliphatics) Dissolved and dispersed aromatics (BTEX, PAHs) Summary:  2005: Bio treatment collapsed Bio recovered < 3 motnhs after MPPE installation >99% removal of aliphatics, aromatics and PAHs MPPE removes toxic load not biodegradable ...

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you