producing lime slurry Articles

  • Cement and Lime Kilns case study

    Cement and Lime Kilns PROCESS DESCRIPTION Cement, lime and gypsum manufacturing processes have in common the mixing of inorganic minerals calcined at high temperatures typically using rotary kilns (vertical kilns are also used). CEMENT Regular Portland cements are the usual products for general concrete construction. The raw ...

  • Pathogen Inactivation by a Closed Alakaline System

    ABSTRACTThe efficiency of advanced alkaline disinfection in closed systems has been demonstrated to depend on the balance of ammonia concentration, pH, exposure time, temperature, total solids content, post-treatment storage time and mixing effectiveness. When the alkaline system is a closed one, an additional pathogen stressor is added: pressure. The effect of the alkaline dosing has been ...

  • ENEL power, italy – fusina project – ZLD plant for FGD wastewater treatment

    The Facility The Fusina Power Plant is equipped with four coal-fired units with a total capacity of 975 MW capacity (1 x 165 MW + 1 x 170 MW + 2 x 320 MW). The Environmental Refurbishment (Flue Gas Desulpharization, (FGD)) project includes a new DeSOx system for common for units #1 & 2; two DeNOx systems, one each for unit #1 & 2. Units #3 & 4 are already equipped with DeSOx ...

  • ENEL power, italy – sulcis project – ZLD plant for FGD wastewater treatment

    The Facility The Sulcis Power Plant is equipped with 1 x 345 MW fluidized bed boiler and 1 x 240 MW conventional boiler. This coal-fired power plant is located in Sardinia Island and has a total of 585 Mwe capacity. The units normally fire imported coal with < 1% Sulphur. The flue gases are treated sequentially by SCR-DeNOx with ammonia as the reagent. This is followed by a high ...

  • Solidification/Stabilization

    Introduction: As for in situ solidification/stabilization (S/S), ex situ S/S contaminants are physically bound or enclosed within a stabilized mass (solidification), or chemical reactions are induced between the stabilizing agent and contaminants to reduce their mobility (stabilization). Ex situ S/S, however, typically requires disposal of the resultant materials. Under CERCLA material can be ...

  • ENEL power, italy – la spezia project – ZLD plant for FGD wastewater treatment

    The Facility The La Spezia Power Plant is equipped with 1 x 600 MW coal-fired power unit and 2 x 350 MWe gas-fired combined cycle power units for a total of 1300 MWe. The unit normally fires imported coal with < 1% Sulphur. The flue gases are treated sequentially by FGD absorber. It is equipped with a 1 x 100% DeSOx lines with an absorber. The blow down from the absorber, along with ...

  • Enel power, italy – brindisi project – ZLD plant for FGD wastewater treatment

    The Facility The Brindisi Sud Power Plant is equipped with four coalfired units each of 660 Mwe capacities. These units normally fire imported coal with < 1% Sulphur. The flue gases are treated sequentially by SCR-DeNOx with ammonia as reagent, High efficiency ESP to remove fly ash and wet limestone gypsum forced oxidation DeSOx. Each unit is equipped with a 2 x 50% DeSOx lines each ...

  • Common Treatment Technologies for Radionuclides in Soil, Sediment, and Sludge

    Unlike organic contaminants (and similar to metals), radionuclides cannot be destroyed or degraded; therefore, remediation technologies applicable to radionuclides involve separation, concentration/volume reduction, and/or immobilization. The most commonly used treatment technology for radionuclides in soil, sediment, and sludge is solidification/stabilization (S/S). This treatment technology is ...

  • Wastewater Treatment & Recycle

    Fresh water is a scarce commodity; this fact is well acknowledged by one and all. People at all levels be it general public, governmental bodies, and industries understand the implications of good quality water availability in terms of quantity, cost and wastage. As a consequence, there is a growing consensus on wastewater treatment for recycle/reuse. This paper briefly describes the treatment ...

  • Acid mine drainage treatment

    Acid mine/rock drainage is a rampant problem in the world today. The above photo depicts acid drainage at an abandoned mine in the Yukon Territory of northwest Canada. This mine shares a similar history to thousands of other mines throughout the world. It was in operation for six short years in the 1950’s, producing gold ore. Its profitability eventually failed and it was abandoned. In the ...


    By WesTech Engineering, Inc.

  • Dredging Abrasive Materials? Learn about SRS Crisafulli’s New Dredge

    The Rotomite-6000-C, SRS Crisafulli’s newest self-propelled dredge, broadens the Rotomite-6000’s capabilities to include removal of highly abrasive materials. The Rotomite-6000-C also increases the customer’s return on investment (ROI) by cutting sludge ...


    By SRS Crisafulli, Inc.

  • Re-agent dosing - Sodimate installs standardised equipment to meet the specifications of each plant case study

    Water quality refining is the most essential step in water treatment processes. When done properly, it guarantees palatable taste characteristics suitable for drinking water. The reliability and accuracy of the processes for storing, metering, and dissolving the required re-agents are indispensible for successfully completing this final treatment. Outlined below is a case story about Viry- ...


    By Sodimate, Inc

  • Belgian egg processing

    Between 3 and 4 million eggs are broken daily, 5 days a week, to produce egg-white, egg-yolk, and some mixed egg products for a total of 900 - 1000 tons of end-products per week. All is done under the highest hygienic standards. The wastewater treatment plant was built 10 years ago, when the egg breaking capacity was at 1.5 million eggs per day and was engineered for handling an expansion up to 3 ...


    By BluePlanet Labs

  • Egg plant treatment in Belgium

    DESCRIPTION OF WASTEWATER TREATMENT FACILITY Between 3 and 4 million eggs are broken daily, 5 days a week, to produce egg-white, egg-yolk, and some mixed egg products for a total of 900 - 1000 tons of end-products per week. All is done under the highest hygienic standards. The wastewater treatment plant was built 10 years ago, when the egg breaking capacity was at 1.5 million eggs per day and ...


    By BluePlanet Labs

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you