scr catalyst Articles

  • 80-95% NOx Reduction SCR without the use of urea

    A new, patented catalyst developed by scientists at the U.S. Department of Energy's (DOE) Argonne National Laboratory that can reliably and economically reduce between 95 percent and 100 percent of the nitrogen oxide (NOx) emissions from diesel fueled engines has been licensed to Integrated Fuel Technologies, Inc. (IFT), a Kirkland, Wash.-based start-up company. IFT plans to integrate the ...


  • Staten Island Ferry, Alice Austen, SCR demonstration project case study

    In December of 2003, the Port Authority of New York and New Jersey (PANYNJ) undertook a project to retrofit the Staten Island Ferry vessel, Alice Austen, with selective catalytic reduction (SCR) and diesel oxidation catalyst (DOC) exhaust aftertreatment.  Alice Austen was selected for the first SCR demonstration project as it is one of ...

  • Selected Literature from Johnson Matthey`s Environmental Catalysts and Technologies Division

    SSEC Literature: High Temperature SCR Zeolite Catalyst for NOx Control / SCR Catalyst for NOx Control Stationary Lean Burn Engines / SCR Systems for NOx Control Stationary Lean Burn Engines / Gas Turbine Oxidation Catalyst for the control of CO and VOCs / Oxidation Catalysts for the Control of CO, VOC, HC / BanditoTM - Modular Catalytic Converter for the Control of NOx, CO and THC / Band-ItTM - ...

  • Selective catalytic reduction of nitric oxide over copper oxide and cerium oxide catalysts

    The selective catalytic reduction of nitric oxide with hydrocarbons in an oxygen-containing simulated flue gas has been investigated for a series of copper oxide and cerium oxide alumina supported catalysts at 600–775 K. The activity of these catalysts for the reduction of NO by methane or propane has been investigated in simulated flue gas. The effects of sulphates on the catalyst, and of water ...


    By Inderscience Publishers

  • The selective catalytic reduction of NO with propane over Ni loaded on H-USY in the presence of excess oxygen

    The abatement of NO with propane in the presence of excess oxygen has been investigated on several kinds of commercial USY (Ultra Stable Y zeolite) in the Na-form (Na-USY) and H-form (H-USY) or wet impregnated to various extents with Ni ions (Ni/USY) catalysts. Experimental results indicated that Ni/H-USY loaded with 15% Ni showed comparatively better catalytic activity for Selective Catalytic ...


    By Inderscience Publishers

  • A selective catalytic system for greenhouse gas (NOx) emission reduction at a 2–ethyl hexanol plant

    Trends of ambient NOX levels in the Jubail Industrial City, Saudi Arabia, are increasing, and the regulators have identified areas requiring substantial reductions to control the atmospheric NOX concentrations. In this study, a Selective Catalytic Reduction (SCR) system for the control of NOX ...


    By Inderscience Publishers

  • NOx in Non-Utility Industries - Part II - Control options and monitoring methodology

     This the second in a two-part series. Part I, which appeared in our June 2001 issue focuses on air emission origins of nitrogen oxides (NOx) in non-utility industries. Choice of the NOx control technology is dependent on many factors, including regulatory requirements, technical feasibility, cost and public perception. Figure 1, compiled based on publications [1-5], presents a summary of ...


  • Minimizing ammonia consumption in DeNOx plants – Case Study

    Flue gas denitrification Combustion processes result in emissions that can be harmful to the environment, in particular carbon dioxide (CO2), sulfur dioxide (SO2), nitric oxides (NOx), and dust. Therefore, measures are implemented in power stations and other plants comprising combustion processes to reduce emissions. For flue gas denitrification, besides front-end primary ...

  • Dredging Up Power

    Caterpillar Marine was selected to power three 3500 m³ trailing suction hopper dredgers for the Jan De Nul Group with Cat 3500E IMO III and EPA Tier 4 certified engines. Cat said the 3500E incorporates selective catalyst reduction (SCR) after-treatment technology with closed-loop NOx sensing and application optimized performance for minimized owning and operating costs. “Embedded ...

  • Chemical Aspects of NOX Scrubbing

    With the passage of the 1990 Clean Air Act Amendments, many chemical and metal industries and utility producers will now be required to further limit the amount of NOX (Nitrogen Oxides) produced. NOX is a precursor to ozone in the atmosphere, and is believed to be a major contributor to acidic deposition (acid rain). Formation of ozone: NO2 + Hv ...


  • Reaching Euro VI emissions limits

    The requirements of low and lowest detectable exhaust analysis has prompted Eco Physics to launch a broad range of analyzers for NO/NOx detection. Emissions tuning is one of the targets of the EURO VI regulations as well as US EPA 2010, which are: Reduction of Particulate Matter (PM) and reduction of Nitrogen Oxides (NOx). In the past 15 years – since the first European regulation for exhaust ...


    By ECO PHYSICS INC.

  • A Modelling Approach to the Design Optimization of Catalytic Converters of IC Engines

    ABSTRACT In this paper, a modelling approach to the design optimization of catalytic converters is presented. The first step of the optimization is the model-assisted sizing of catalysts. For ...


    By DCL International Inc.

  • Allweiler pumps in exhaust gas treatment systems in ships

    As environmental regulations become more stringent, waste gas treatment systems are growing in importance. H+H Umwelt- und Industrietechnik GmbH of central Germany has been using Allweiler progressing cavity pumps as a core component of these systems since 2003. The company has been manufacturing catalytic waste gas treatment systems since 1998. Originally they focused on applications in block ...


    By ALLWEILER GmbH

  • The Right Mix for Clean Air

    Reducing air pollution is an increasingly important topic all around the world. Many governments—also in developing countries—set new limits for emissions such as nitrogen oxides in flue gas. Sulzer offers advanced mixing technology for flue gas cleaning. The installation in a large power plant shows that these high-performance mixers can cope with the most difficult requirements. ...


    By Sulzer Management Ltd

  • NOx in Non-Utility Industries - Part I NOx in Non-Utility Industries - Part I - Air emission origins, best control solutions and monitoring methodology for nitrogen oxides

     Problems with reducing nitrogen oxides (NOx) are widespread in the general process industries. These industries, together with medium size utility and power generators contribute about 15 percent of global NOx emissions. The emission sources addressed include various heaters employed in chemical and petrochemical plants, nitric and sulfuric acid plants, glass furnaces, iron and steel mills, ...


  • Pharmaceutical Manufacturer Turns NOx Regulations Into an Opportunity – With a 6-Figure Annual Chemical Savings as a Bonus.

    This project was for a major manufacturer of a tabletted OTC analgesic. The manufacturing process was being redesigned, and a critical aspect of the work was the re-engineering of a reactor in the initial stage of manufacturing. The client’s original process, which used nitric acid to dissolve a metal, exhausted virtually 100% nitrogen oxide (NO), a toxic, wholly non-water-soluble gas that reacts ...


    By Tri-Mer Corporation

  • The Chemical Aspect of NOx Scrubbing

    With the passage of the 1990 Clean Air Act Amendments, many chemical and metal industries and utility producers will now be required to further limit the amount of NOx (Nitrogen Oxides) produced. NOx is a precursor to ozone in the atmosphere, and is believed to be a major contributor to acidic deposition (acid rain). Formation of ozone: NOx is produced in a variety of ...


    By CR Clean Air Group, LLC

  • Intelligent Pollution Control

    The world faces difficult pollution control decisions. For every dollar spent on pollution control, there is an alternative investment in health improvement. For every dollar spent on reducing one pollutant, there is an alternative to reduce another. The most prudent course to make the best investment should include: Intelligent uncertainty Intelligent classification of options ...


    By The McIlvaine Company

  • Navigating NSPS subpart Db for boilers: a case study

    Over the past year, Trinity assisted a chemical company with the permitting and installation of a new 220 MMBtu/hr package boiler. The new natural gas-fired boiler replaces coal-fired units that were installed in the 1940s. Navigating through the numerous, and at times conflicting, regulatory requirements applicable to such a unit has been challenging. With careful planning and implementation, ...


    By Trinity Consultants

  • Mercury Control Demonstrations

    C1.1 | Halogens and Sulfur in Coals and their Influence on Co-benefit Mercury Capture Bernhard Vosteen | President, Vosteen Consulting Gmbh Not only the range of the coal mercury content itself, but also the range of the native halogen and sulfur contents in coal are of great influence on co-benefit mercury capture, wet and dry. The ...

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you