tank farm operator Articles

  • Electro-hydraulic actuators deliver improved safety at India’s tank farms

    Following an accidental fire at the IOCL Jaipur Terminal, an extensive review of safety measures recommended by the MB Lal Committee has resulted in the introduction of failsafe actuators for critical tank farm applications. These valves, known as ROSOV (Remote Operated Shut-off Valves), now provide tank overfill protection at the majority of storage facilities owned by the Indian oil industry. ...


    By Rotork

  • Tank terminal demonstrates the electrically operated solution for ESD Valves - case study

    Overview Since the disastrous fire at the Buncefield fuel depot in 2005, much has been done to ensure that such a catastrophic accident should not happen again. Led by COMAH (Competent Authority/Industry Standards Task Group), safeguards have been put in place by the petroleum industry to provide additional safety and environmental protection to tank storage installations. Endorsing the ...


    By Rotork

  • Building Farm And Food Scrap Digesters

    In the past several weeks, we received invitations to two ribbon cuttings for newly installed farm-based digesters — one at a dairy farm in western Massachusetts and another at a swine operation in North Carolina. We also received a press release from the University of California, Davis, about its new food scraps digester on campus. And then there were a few new projects that we had been ...


    By BioCycle Magazine

  • Sea water treatment for shrimp farming - Case Study

    Global demand for seafood remains high, yet farming shrimps in aquaculture is a tricky business. Disinfection and desalination systems significantly improve the water quality in the breeding tanks, thereby improving the shrimp survival rate. Task Aquaculture - a growth market Shrimps are a popular delicacy, especially in Europe and the USA. According to the ...

  • Farm site BTEX closure achieved within one year

    Soil and groundwater at the former Feley Farms Site (Michigan, USA) was impacted by gasoline constituents that originated from former USTs. The leaking tanks were removed in 1995; based on the reported petroleum-contaminated water seeping into the excavation hole along the surface of the bedrock during the tank removal process, groundwater monitoring was recommended. The results of the 1996-97 ...


  • Safety device for bottom drainage of fuel storage tanks

    General   One of the routine procedures at a fuel storage tank farm is the periodic draining of water which accumulates at the bottom of the storage tanks. ...


  • Kirk Environmental complete GBP£3m environmentally friendly farm AD facility in Rural Cumbria case study

    Kirk Environmental was appointed the Main Contractor for the second Farmgen on farm AD plant in Cumbria. The plant at Dryholme Farm, near Silloth, is now fully operational and supplying enough electricity to power over 1,000 homes to the national grid. The supply and construction by Kirk Environmental included 3 Glass Coated Steel Digestion tanks complete with BIODOME® Double Membrane Gas ...

  • Choosing a safe and environment friendly tank cleaning method case study

    Choosing an environmental friendly tank cleaning method is imperative for BP-Gelsenkirchen GmbH (Ruhr Oel) due to a very strict legislation in the Ruhr district. The environmental legislation in North Rhine Westphalia is known for being one of the most stringent in the world, and the authorities have imposed a series of specific regulations to minimise emissions. For example, hydrocarbon ...


  • Landmark farm project uses XEBEC’s gas purification system to deliver pipeline-grade natural gas to Michigan Gas Utilities customers case study

    Fennville Biogas Project at a Glance: Type: Animal waste to pipeline-grade natural gas and electricity generation Claim to fame: First commercial facility in North America to generate both pipeline-grade methane and electricity from animal waste Location: Scenic View Dairy, Fennville, Michigan Animal waste received ...


    By Xebec Adsorption Inc.

  • Rotork is ‘one-stop actuation shop’ for storage tank expansion project - Case Study

    Overview Rotork has demonstrated its ability to be a one-stop shop for valve actuation products and services for an oil storage tank expansion project in Holland. Rotork's activities have encompassed the supply of intelligent electric actuators for isolating, modulating and failsafe valves, digital control systems, valve gearboxes, valve adaptation, workshop motorisation, on-site ...


    By Rotork

  • Efficient Operation of Lighting, Hot Water and Air Conditioning: Hotel Inter Continental Sydney

    To improve its environmental performance and save nearly $300,000 per year, the Hotel Inter Continental Sydney changed some practices that seemed insignificant in themselves but which collectively, wasted massive resources. The changes cost around $275,000 and no adverse affect on guest amenity. They included lowering the power of lights that were too bright, lowering the temperature of ...


  • KTC EDIBLES - Case Study

    DAF system to separate oils from their effluent was unsuccessful. Thus, meeting compliance was a challenge. Off-spec oily water was tank-farmed which had become unmanageable. Discharge limit of 1000 mg/l COD was often exceeded by a factor of 4-5 times. The Water Authority was scheduled to terminate discharge if no solution presented. The effluent from five sources was piped to a centralized ...


    By FogBusters, Inc.

  • Biogas CHP supplies in Uruguay electricity and heat case study

    Dreyer & Bosse Kraftwerke as a seasoned manufacturer of CHP (Combined Heating and Power) has provided a complete CHP system of series Vita for generating heat and power for a wool producer in Uruguay. The biogas cleaning system including biogas cooler and activated carbon filter were ordered and delivered as well for a smooth operation. There are 3.9 millions of sheep at this farm, about 40% ...

  • Fre-energy 250m3 DIY Installed Biogas Storage

    Following the installation in 2011 of our 250m3 biogas holder at Much Fawley Farm near Hereford, Fre-energy decided to purchase a second Base Biogas Holder for use with their own Anaerobic Digester located at Lodge Farm near Wrexham, which just happens to be the largest organic farm in Wales. Their unique AD tank design incorporates a clever mechanism for in-process de-gritting which greatly ...


    By Base Structures Ltd

  • Solving a messy problem: Covering wastewater treatment in Halton region Ontario, Canada case study

    The Regional Municipality of Halton or Halton Region is located in Southern Ontario, part of the greater Toronto area. Halton owns and operates seven wastewater treatment plants for four Ontario cities in its jurisdiction. These plants are designed to treat wastewater from homes and businesses turning the effluents into biosolids. Turning waste into food requires a process that starts with the ...


    By CST Industries Inc

  • Maintaining level of acidulants in the food industry case study

    Reducing delivery costs and time by utilizing Solid's SmartScan 25L for level measurement of acidic liquids in Gadot Biochemical factory. Gadot Biochemical Industries Ltd. (GBI) located in Israel, is a prominent world-wide supplier of ingredients and fine chemicals for the food, cosmetic, detergent, and pharmaceutical industries, and specializes in the manufacture and development of Citric Acid, ...

  • Food and Beverage - L&S Sweetener Company - case study

    Application L&S Sweeteners of Honey Brook, Pennsylvania, had wastewater disposal issues resulting from the cleaning process for trucks bearing various liquid sweeteners, which must be cleaned between shipments per USDA requirements. Wastewater Description The company’s wastewater was derived from the cleaning of liquid sugar products from tank ...


  • GTI Supplies Innovative Cover for Waste-to-Energy Digester

    The Customer: LaForge Bioenvironmental operates a waste-to-energy facility in a northwest farming community of New Brunswick, Canada. The system is located on a 1,000 acre (405 hectare) mixed farming operation, which includes the LaForge Holsteins dairy. LaForge planned to expand its 500kW combined heat and power (CHP) system to more than double the capacity by converting an existing holding ...

  • Liquid waste off-gas treatment - Case Study

    Application Biffa Waste Services operate a major waste disposal site at Kilsyth in Scotland where they handle many types of industrial liquid effluent. This can give rise to a range of emissions from both the tank farm and the road tanker deliveries. In addition, significant NO2 and nitric acid fume releases can arise from process upset conditions. ERG provided an emergency NO2 ...

  • Manure Spills: Prevention, Detection, Control Options, & the Role of Anaerobic Digesters

    An internet search for manure-related spills can lead to an exhausting list of news articles and images of catastrophic environmental damage. In Wisconsin alone, the ...


    By BIOFerm™ Energy Systems

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you