tank inspection Articles

  • Advanced Aboveground Storage Tank Inspections – In-Service Robotics Tank Inspections

    This paper describes the advanced in-service tank inspection methods available for use in the inspection of aboveground storage tanks (AST) in the petroleum and petrochemical industry. ASTs are subject to several federal and state regulations requiring tank owners to perform tank floor/bottom integrity, seals system, and deck fittings inspections on a routine basis. The conventional procedure for ...


    By Trinity Consultants

  • Scrubber Removes Grease and Particulates from Air Exhaust

    Operating Issue A food-industry leader in Alabama operates several pork-sausage cookers that exhaust over 4,000 ACFM of moisture and pork grease. The operator installed Electrostatic Precipitators (ESPs) to treat the exhaust but these systems performed poorly and generated high maintenance and operating costs. Additionally, these systems were antiquated and required significant capital ...


    By Pollution Systems

  • Integrity Inspection of Above Ground Storage Tanks

    40 CFR 112.7 requires integrity inspection of containers subject to this regulation. Where applicable, inspection to a nationally recognized standard is required. Where there is no standard, good engineering judgment is allowed. This paper discusses commonly used national standards for inspection and methods of implementing common and less common inspection strategies. It gives owner/operators ...

  • Steel Fire Sprinkler Tank Inspection Case Study

    These images show the steel fire sprinkler tank before any preparation work and then after preparation. The steel fire sprinkler tank was fully relined with Acothane DW. A Logistics company in Berkshire recently had an R.O.V Inspection carried out on their Fire Tank, we also provided them a sprinkler tank maintenance. The sprinkler tank inspections confirmed significant amounts of corrosion to ...


    By Acothane UK Ltd

  • `Advanced Aboveground Storage Tank Inspections - In Service Robotics Tank Inspections,` presented at the 2004 NPRA Environmental Conference

    Abstract This paper describes the advanced in-service tank inspection methods available for use in the inspection of aboveground storage tanks (AST) in the petroleum and petrochemical industry. ASTs are subject to several federal and state regulations requiring tank owners to perform tank floor/bottom integrity, seals system, and deck fittings inspections on a routine basis. The conventional ...


    By Trinity Consultants

  • Underground Water Tanks: Understanding the installation process is the first step in safety inspections

    Underground storage tanks are increasingly becoming essential components of building projects, driven by rising interest in on-site rainwater and graywater collection and reuse. As a result, building officials may need to expand their expertise to include these products and their components. Some safety inspection work is obvious; for instance, checking that the installer or project owner ...


    By Xerxes Corporation

  • New Inspection Facility

    CPS was awarded the contract to design and build a new inspection facility for a specialist alloy manufacturer. The contract included the design and construction of a new production building, electrics and processing equipment. The building works included the design and construction of a new building complete with 6 hoist overhead crane, production office and bunding with chemical resistant ...

  • How To Survive An OSHA Inspection

    Untitled Document While there's little upside to facing an Occupational Safety and Health Administration (OSHA) inspection, it is possible to ...


    By 3E Company

  • Maintenance for septic tanks

    Septic tanks are widely used for on site sewage treatment for domestic homes which are not connected to the sewer system. Little attention is given to the septic tank until there are problems such as smells or poor drainage or ponding on the surface. A little maintenance of the septic tank can be very helpful in maintaining performance of the septic tank. The outflow from a septic tank percolates ...


    By Biofuture Ltd

  • Two models for tank cleaning

    Fluid treatment specialist Algae- X International, Fort Myers, Fla., has expanded its Mobile Tank Cleaning (MTC) series with two new models. The MTC 500-AFR is an adjustable flow rate system for use with a wide range of tank sizes and fluid types such as diesel, biodiesel and hydraulic fluid. The MTC 1000-LX is the next generation of Algae-X’s MTC 1000 unit, now with stainlesssteel plumbing and ...


    By AXI International

  • Maersk line - ballast tank cleaning

    Overview The following is an internal document from Maersk highlighting the use of SpillAway's NavalKleen II product for the bioremediation of No.6 heavy fuel oil that had leaked into the ballast tank of SL Atlantic. At the point that SpillAway were asked to help, the contaminated ballast water had been removed and the tank physically cleaned, however, residues left in the tank were still ...


  • ROV Inspections of Water Towers: Underwater Drone Used to Save Diver’s Time

    Mountain West Commercial Diving currently uses their Deep Trekker underwater drone to conduct ROV inspections or potable water towers. Aim to exceed the client’s expectation while adhering the highest standards in industry compliance and safety; that is the goal of Mountain West Commercial Diving (MWCD). Based out of Hazelton, Idaho, MWCD has over 25 years of experience in successfully ...


    By Deep Trekker Inc.

  • Transforming an oil tank into a clean water tank - case study

    It would be an almost impossible task, many would claim, to turn an 86 diameter large Orimulsion 400 tank, that has been out of service for years, into a clean watertank. But this was whatEcologica was contracted to do for their client ENELS.p.A. ENEL S.p.A. chose Italian-based Ecologica S.p.A. as service provider for this tank clean atthe ENEL Central e Federico power plant in Brindisi as they ...


  • Keeping Tanks Online and Divers Out of the Water

    Huntley’s Sub Aqua Construction brings piece of mind to customers with regular and efficient mini remotely operated vehicle inspections Huntley’s Sub Aqua Construction (HSAC) is a commercial diving company based in Kentville, Nova Scotia, Canada. Operating since 1994, HSAC recently added a Deep Trekker mini remotely operated vehicle (ROV) to their team to improve potable water ...


    By Deep Trekker Inc.

  • Five Critical Parts For Your Steel Storage Tank

    Every year, we sell hundreds of parts for bolted tanks and welded steel tanks. Even though many ground storage tanks needing parts were not originally manufactured by Superior Tank Co., Inc., we can provide standard replacement components for steel storage tanks or can fabricate custom parts and accessories to ...


    By Superior Tank Co., Inc.

  • Tank cleaning in Abu Dhabi case study

    In 2008 we signed an agreement with an Abu Dhabi based industrial and utilities contractor. They wanted to increase their portfolio by offering tank cleaning services. Over a period of four months we trained a number of their operators and sourced new equipment to enable them to approach new clients. In 2009 we were awarded a contract to clean two crude oil tanks. Utilizing local labour, the new ...

  • Bridge Height Limits Transport of Cl02 Storage Tanks

    Located in Northern Ontario on the Trans Canada Highway is a bridge that enables pedestrians and vehicles to cross the Spanish River. The bridge itself holds no place in the annals of Canadian history. It is in fact, quite unremarkable as a typical bridge found in the area. However, the Spanish River Bridge represented a major problem for an engineering project rquired by a local Bleach Pulp ...


    By Fabricated Plastics Limited

  • EPA Study: 83% of diesel tanks have moderate to severe levels of corrosion

    The EPA has released the results of the largest survey to-date on corrosion levels in underground storage tanks (USTs) containing diesel fuel -- and the results are staggering. The research showed that 83 percent of the USTs studied exhibit moderate to severe corrosion. Worse, only 25 percent of the owners of those tanks with corrosion were aware of it prior to the study. ...


    By Tanknology Inc.

  • Exploring the need for rainwater tank maintenance: survey, review and simulations

    Rainwater tanks are a common feature of the urban landscape in Australia and globally. In Brisbane, Australia, provision of alternative water in new homes is mandatory and to meet this requirement rainwater tanks are considered an important option. The water savings of rainwater tanks can help defer investments in supply infrastructures. An emerging concern is that there is currently no ...


    By IWA Publishing

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you