voc leak testing Articles

  • New NSPS OOOOa Regulations Affecting Methane and VOC Emissions from the O&G Sector Finalized as of June 3, 2016

    The EPA has issued three final rules that will curb emissions of methane, smog-forming volatile organic compounds (VOCs) and toxic air pollutants such as benzene from new, reconstructed and modified oil and gas sources, while providing greater certainty about Clean Air Act permitting requirements for the industry. The EPA’s amended and new regulations affecting methane (CH4) and VOC ...


    By AEREON

  • VCU Testing for a Major Pipeline Company - Case Study

    Challenge Antea Group was contracted by a major pipeline company to complete a performance test of two marine VCUs and a VOC leak quantification of components during loading of marine vessels. The protocol for both of these tests had been developed by a previous consultant and TCEQ had not yet approved protocol. The client recently purchased the facility and had little information on ...


    By Antea Group - USA

  • Mobile Stationary Source Emissions Testing, Coming to a Facility Near You?

    Last week, Antea Group had the unique opportunity to perform a RATA (relative accuracy test audit) of the emissions from a thermal oxidizer at an ethanol production facility located in Minnesota using a state-of-the-art mobile testing laboratory. During this RATA audit, actual stack emissions levels (including NOx, SOx, CO2, CO, O2, flow rate, temperature, velocity and pressure) from the ...


    By Antea Group - USA

  • Volvo Trucks North America achieves goals for major reductions of air emissions and water use

    Volvo Trucks - North America maintains a strong commitment to its core value of environmental care, as well as responsible corporate citizenship by limiting its environmental impact on the community surrounding its Dublin, Virginia facility. In 2003 and 2004, Volvo continued that tradition of corporate responsibility by launching several ambitious initiatives that significantly reduced air and ...


    By IHS

  • Data Collection for Smart LDAR - Optical Imaging

    Abstract:  Use of infrared cameras to discover gaseous VOCs as part of a Fugitive Emissions Leak Detection And Repair (LDAR) regulatory compliance program is new to the chemical processing and oil ...


    By InspectionLogic Corporation

  • Case study - Engine cell exhaust: Catalytic oxidizer

    Overview Endurance testing of outboard motors for boats has typically been done in lakes and sometimes on barges. This testing was time consuming, presented logistic problems and removed the testing from the R & D department and the factory. When a company in Oklahoma decided to build their own endurance test cell area, the Environmental Protection Agency required them to control the ...

  • Smart LDAR — more cost-effective?

    On December 19, 2008, EPA issued a final rule establishing a voluntary Alternative Work Practice (AWP) to detect leaks of volatile organic compounds (VOC) and hazardous air pollutants (HAP) from process equipment (FR Vol. 73, Number 246), thereby providing the regulated community additional flexibility in complying with leak detection and repair (LDAR) requirements. The AWP allows owners or ...


    By Trinity Consultants

  • New air quality rules challenge oil & natural gas industry

    EPA Administrator signed a suite of proposed new air regulations affecting both the Production/Processing and Transmission/Storage sectors of the oil and natural gas industry. The proposed rules mandate the use of emission controls as well as work practices through two different air regulatory programs – New Source Performance Standards (NSPS) and National Emissions Standards for Hazardous ...


    By Trinity Consultants

  • Case study - World`s largest remediation site

    Overview Hong Kong's Kai Tak Airport, the world's busiest airport in 1997, became the world's largest remediation site once it was closed. When the airport was decommissioned in 1999 in favor of the new Chek Lap Kok Airport, the government planned to rapidly clean up the site for commercial and residential development. After many years of soil penetration by various ...

  • PID in industrial hygiene

    Industrial (or occupational) hygiene places the emphasis on prevention of ill health from work, through recognising, evaluating and controlling the risks. For anyone working with hazardous compounds, these chemicals represent a significant potential source of risk. Modern PID instruments provide reliable detection of over 200 of the most dangerous chemicals, helping to ensure effective industrial ...


    By Ion Science

  • Program developed to ensure long-term O&M and performance of vapor intrusion mitigation

    EPA Region 7 has developed a comprehensive VI program to address the installation and long-term operation and maintenance (O&M) of VI mitigation systems, as well as assessment sampling for future systems, in homes near the Chemical Commodities, Inc. Superfund site (CCI). Region 7's VI Program Implementation Manual, which describes decision processes and procedures as well as roles and ...

  • Case study - ETO sterilizer abatement

    OVERVIEW Product sterilization companies are generally required to utilize a pollution control device for treatment of exhaust gases from their aeration room and sterilization chambers.  In the United States, they need to be in compliance with NESHAP (National Emission Standards for Hazardous Air Pollutants) regulations that dictate a 99% destruction efficiency of EtO (Ethylene ...

  • Field Detection of Chlorinated Alkenes in Well Water using the FROG-4000 Portable GC - Case Study

    Introduction Defiant’s FROG 4000, a portable GCPID system, was used to identify and determine the concentration of chlorinated alkenes in several extraction wells located in Tacoma Washington. Split samples were taken at each well and sent to an offsite lab for analysis. This case study examines the field exercise and highlights the high degree of agreement between the offsite lab and ...


    By Northern ANI Solutions Ltd.

  • Case study - RTOs leave nothing to HAP-penstance

    PROBLEM The United States EPA promulgated a ruling in 40 CFR, imposing strict new standards to reduce emissions of toxic air pollutants from the manufacture of pharmaceutical products, including prescription and over-the-counter drugs. The agency's rule was intended to reduce emissions of a number of air toxins and hazardous air pollutants (HAPs), including methylene chloride, ...

  • Shop Spill Cleanup, Mitigation for Waste Applications

    Spills and effluent water around a shop can cause an operation time and money. Taking simple steps to understand and apply best practices and the right products can mitigate the problematic effects and make any shop safer. If you work in a maintenance shop in the waste industry, you know that one thing is unavoidable—spills. With so many pieces of equipment and so many fluids around ...


    By Waste Advantage Magazine

  • Standard Chlorine of Delaware Remediation

    By designing a 70-foot deep barrier wall, Black & Veatch was able to cut off contaminant source areas from a creek near New Castle, Delaware. The groundwater treatment system that Black & Veatch designed prevents site contamination from reaching the underlying drinking water aquifer. The Standard Chlorine of Delaware Site is a 65 acre area including an abandoned chlorobenzene ...


    By Black & Veatch Corporation

  • Advanced gas detection technology supports arctic greenhouse gas research

    Enormous quantities of greenhouse gases (GHG) exist within Arctic ice and frozen soils, so with the threat of global warming, a clear understanding of the relationship between GHG in the atmosphere and in the ice/soil is vital because melting of permafrost could cause a dangerous climate tipping point. There can be few more challenging environments for monitoring gases, but PhD researcher Martin ...


    By Quantitech Ltd

  • Advanced Gas Detection Technology supports Arctic Greenhouse Gas Research

    Enormous quantities of greenhouse gases (GHG) exist within Arctic ice and frozen soils, so with the threat of global warming, a clear understanding of the relationship between GHG in the atmosphere and in the ice/soil is vital because melting of permafrost could cause a dangerous climate tipping point. There can be few more challenging environments for monitoring gases, but PhD researcher Martin ...


    By Gasmet Technologies Oy

  • Total solution: Gas and particulate analysis in Cement industry

    Cement plants are increasingly required to install continuous emission monitoring systems (CEMS). While these represent a significant financial outlay, a range of other factors also need to be considered when selecting a suitable CEMS. To the inexperienced, selecting a suitable CEM can mistakenly be considered as simply ensuring that the applicable national regulations (eg MACT in the USA, ...


    By Environnement S.A

  • Global solution: Gas and particulate analysis in Cement industry

    Cement plants are increasingly required to install continuous emission monitoring systems (CEMS). While these represent a significant financial outlay, a range of other factors also need to be considered when selecting a suitable CEMS. To the inexperienced, selecting a suitable CEM can mistakenly be considered as simply ensuring that the applicable national regulations (eg MACT in the USA, ...


    By Environnement S.A

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you