wash water treatment Articles

  • Pulp & Paper Water Treatment - A look at optimizing water resource management

    Application Case Study (Pulp/Paper Operations) The pulp and paper industry has traditionally been a consumer of large amounts of fresh water and power. Recently, increased focus has been given to the optimized efficiency of paper mills and to the environmental sustainability footprint of the industry. Therefore, water resource management has become a more critical factor ...

  • Treatment of Water-Wash Paintbooth Effluents in the Automotive Industry

    During the coating process of car bodies in water-wash spray booth, around 40% of the sprayed paint does not reach the support; these paint particles sprayed into the air are called “overspray”. By using a dawn-draft positive air pressure coming from the ceiling of the cabin, the polluted air is forced vertically downward toward a grating on the floor under which a constant stream of water is ...

  • Treatment of tunnel wash water and implications for its disposal

    The use of road tunnels in urban areas creates water pollution problems, since the tunnels must be frequently cleaned for traffic safety reasons. The washing generates extensive volumes of highly polluted water, for example, more than fivefold higher concentrations of suspended solids compared to highway runoff. The pollutants in the wash water have an affinity for particulate material, so ...


    By IWA Publishing

  • Wash Water Questions and Answers

    When the subject of Wash Water Recycling comes up there are many questions that can arise. The following are a few that are frequently asked are: Will it have an odor? What will its’ clarity be? How much is recycled? The above questions seem very basic but can at times create a complex response because of ...


    By ESD Waste2Water, Inc.

  • Drum & Tote Washing Wastewater Treatment

    55 Gallon Drum 275 Gallon Tote Washing Wastewater Test Floccin™ 909 Treatment 100% Wastewater Reuse This facility receives 55-gallon drums (plastic) and 275 gallon totes (plastic and SS) from several different ...


    By Integrated Engineers Inc.

  • Pressure Washing

    The facility had installed a biological treatment unit for treating the water from their pressure washing their milk trucks and maintenance operations. The system required a lot of maintenance, power costs for the aeration, produced poor water quality, and always smelled. Integrated Engineers was contacted to solve the problem using the Floccin products and a 300-gallon batch treatment unit. The ...


    By Integrated Engineers Inc.

  • Soil Washing

    Introduction: Soil washing is a water-based process for scrubbing soils ex situ to remove contaminants. The process removes contaminants from soils in one of two ways: By dissolving or suspending them in the wash solution (which can be sustained by chemical manipulation of pH for a period of time). By concentrating them into a smaller volume of soil through particle size ...

  • Car Wash Wastewater Treatment - Case Study

    Wastewater Treatment Plant, Robina Car Wash, Qld Case Study: Car Wash WWTP Client: Robina Car Wash Year: 2012 Capacity: 800 l/h BACKGROUND Car washes use very little potable (mains drinking) water by using fine nozzles and high pressure hoses. Linked ...


    By Hydrasyst

  • Bus Washing Facility Wastewater Treatment Case Study

    Industrial Wastewater Treatment Success Stories Bus Washing Facility Waste Water Treatment Astounding Results of Bus Washing Jar Test The sample from ...


    By Integrated Engineers Inc.

  • Car wash wastewater treatment and water reuse – a case study

    Recent features of a car wash wastewater reclamation system and results from a full-scale car wash wastewater treatment and recycling process are reported. This upcoming technology comprises a new flocculation–column flotation process, sand filtration, and a final chlorination. A water usage and savings audit (22 weeks) showed that almost 70% reclamation was possible, and fewer ...


    By IWA Publishing

  • Case Study: Truck Wash

    This facility washes out the internal tanks of tanker trucks. Generating 10,000 gallons/day of wastewater consisting of the residual liquid within the tanks combined with soaps, acids, and caustic cleaning products. The wastewater flowed into a central sump and was pumped into one of their two 5000 gallon Reaction Tanks. The operator then added Ferric Chloride (40 gallons), sulfuric acid (10 ...


    By Integrated Engineers Inc.

  • FUEL-WASH Mercaptan Removal

    Summary Finding the right treating solution to remove impurities from hydrocarbon streams is a challenging task for any refiner and one of the chief research scientists from the Merichem Company found the FreshAWL chemistry as an interesting and plausible solution to assist in their processing systems for the removal of Mercaptans from RSH (Mercaptan Laden) Kerosene. FreshAWL ...


    By FreshAWL, LLC

  • On-site treatment of used wash-water using biologically activated membrane bioreactors operated at different solids retention times

    Biologically activated membrane bioreactors (BAMBis) were operated at suspended solids retention times (SRT) of 7 and 102 days and at full solids retention. The effect of these different approaches of operation on the substrate and nutrient conversion, and on permeate flux, was investigated. Variations in organic loads and aeration intensities were also studied. Permeate flux stabilized during ...


    By IWA Publishing

  • Synthetic dairy wash-water treatment by using an alternating pumped sequencing batch biofilm reactor

    The performance of an alternating pumped sequencing batch biofilm reactor process in synthetic diary wash-water treatment was studied. The system comprises two reactors with two identical plastic biofilm modules. Two centrifugal pumps, one connected to each reactor, alternately move the water from one reactor to the other one, resulting in aeration. At three loading rates (336, 501 and 1080 g ...


    By Inderscience Publishers

  • Golf courses and washing machines: obstacles and opportunities for sustainable water management

    Rising standards of living often boost demand for water-intensive goods and services. Only by managing water consumption — using measures such as water pricing and incentives to adopt new technologies — can we ensure sustainable public water access alongside economic growth. With 19 golf courses already and another 55 planned, Spain's Júcar River Basin offers the enthusiastic golfer a wealth of ...

  • Egg wash wastewater: Estrogenic risk or environmental asset?

    Commercial production of eggs and egg products requires the washing of eggs to remove urinary / fecal material and broken egg residue. In the case of one Ohio farming facility, 1.6 million birds produce 1.4 million eggs per day, using ∼50 mL of wash water / egg or ∼ 70,000 L per day. The aqueous waste stream was evaluated for estrogenicity, to determine if potential for endocrine disruption ...


    By John Wiley & Sons, Ltd.

  • Ozone for Waste water Treatment

    Ozone has been used for many years to treat pathogens such as bacteria and algae in water for applications such as drinking water supplies and air conditioning system cooling water. More recently, most water bottlers have adopted ozone. Ozonated water for treatment of fruit, vegetables, fish, etc. in the U.S. awaited the GRAS approval. Now that has happened, and projects are emerging everywhere. ...


  • Bus Pressure Washing Facility Wastewater Case Study

    Industrial Wastewater Treatment Success Stories Bus Washing Facility Waste Water Treatment Astounding Results of Bus Washing Jar Test The sample from ...


    By Integrated Engineers Inc.

  • Olive mill waste water treatment

    The production of olive oil generates two kind of waste waters: RINSING WATERS: the quantity is subject to change. It can be re-circulated, after the settling to remove the solids, or discharged directly. SLUDGE: vegetation water with additional water, whose quantity is subject to change. In case of traditional oil mills, the hot additional water flows to the inlet of the centrifuge. Part ...

  • Water treatment plant filter improvements

    Client: City of Junction City, Kan. Completion Date: March 2003 Services Provided Filter rehabilitation Air scour system design Construction phase services Project Summary  Burns & McDonnell provided planning, design, bidding and construction services for the City of ...


    By Burns & McDonnell

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you