Intereco S.a.s

24 products found

Intereco S.a.s Products

  • WWTP Pre-Treatment

  • Intereco - Penstocks

    Intereco - Penstocks

    INTERECO produces penstocks to intercept of channels and a level regulators or flow rates. Several models, from those for the channel to those with seal 3 or 4 sides range, with the possibility to choose the manual or motorized models.

  • Intereco - Grits for Screening of Waste Water

    Intereco - Grits for Screening of Waste Water

    The screening of waste water is one of the preliminary mechanical treatment to which the waste water is subjected at the entrance of the treatment plants to remove and reduce suspended and floating materials. INTERECO produces chain vertical bar screens, rotating comb grid, arc and belt types, like request by the project.

  • Intereco - Sand Trap System

    Intereco - Sand Trap System

    INTERECO produce sand classifiers to separate sand/grit from sewage; complete by an air-lift. The unit is installed in a concrete circular tank, completed by a diametral support bridge. It is composed by: Drive unit completed of gear mechanical speed variator. Thrust roller bearing to support shaft and mixer. Lower plastic bearing.

  • Intereco - Sand / Grit Classifier

    Intereco - Sand / Grit Classifier

    The unit is composed by: Inlet and settling chamber, properly inclined to convey solids to the screw channel Screw channel internally coated with antiwearing material Shaft less screw Water tank completed with discharge pipe Gear reducer drive unit Amperometric relay for overload protection (to be installed in the control panel) As standard, hot tip zinc coated carbon steel with AISI 304 S.S., bolts and nuts. Under request all frame in AISI 304.

  • WWTP Treatment - Primary - Secondary

  • Intereco - Model Radial +1/3 - Diametral Bridges

    Intereco - Model Radial +1/3 - Diametral Bridges

    INTERECO produces this unit to be installed in a circular concrete basin, composed by: Diametral bridge with walking grate, hand rail, foot guard. Elicycloidal gear reducer/direct coupling drive unit. Transmission shaft, double arms, support beams. Bottom scraper. Vertical thickening beams. Soft inlet cylinder. Sludge feed pipe. Peripheral Thomson weirs. Overload protection with current relay. Hot dip zinc coated carbon steel made with AISI 304 S.S.,...

  • Sludge Treatment

  • Intereco - Model EM/BSB/BTB/BKB - Manual and Automatic Polyelectrolite Preparation Units

    Intereco - Model EM/BSB/BTB/BKB - Manual and Automatic Polyelectrolite Preparation Units

    Manual and Automatic polyelectrolite preparation units, complete with one (EM), two (BSB) or three(BTB) tanks, connected with a siphon system, to realise an ageing on FIFO basis; the two tanks are used for powder dissolution (a 700 rpm propeller mixes water with polyelectrolite) and for solution storage. Up to 30 Kgs/hr in 8 different models; For powder and/or emulsion; With electrical switchboard or connection box.

  • Intereco - Model TF Series - Belt Filter Table

    Intereco - Model TF Series - Belt Filter Table

    Belt filtering table TF is used instead of a static thickener, with expensive concrete works, to thicken sludge before a digestor or a following dewatering unit (as belt press, plate filter press, centrifuge). Belt filtering tablet TF is complete with a vertical cylindrical reactor (with a variable speed mixer) to help sludge and polyelectrolite to react and separate from water. Flocculated sludge is discharged on the belt and is thickened to a solids...

  • Intereco - Model Rotoset Series - Dynamic Thickeners

    Intereco - Model Rotoset Series - Dynamic Thickeners

    Dynamic thickener ROTOSET with a sludge capacity up to 60 m3/hr. The unit is complete with vertical cylindrical reactor with impeller for a perfect sludge/polyelectrolite mixing, with a centrifugal filter cloth washing water pump, able to recycle the thickener filtrate, this to avoid water consumption and the increasing of the WWPT hydraulic head. ROTOSET is assembled on a hot dip zinc carbon steel frame (Skid).

  • Intereco - Model GRA - Paddle Double Mixer

    Intereco - Model GRA - Paddle Double Mixer

    The increasing request for sludges with a dryness percentage higher then 30%, can be satisfied, without very expensive incenerators, with Intereco’s granulation system. This very low running cost and no polluting system uses a double screw mixer “GRA”, in which the cake coming from the belt press is mixed with quick lime (CaO). Better then other devices, with the discontinuous double screw, cake is broken in very fine pieces while...

  • Sludge Treatment - Belt Press

  • Intereco - Model EDOM Series - Belt Presses

    Intereco - Model EDOM Series - Belt Presses

    EDOM belt presses cover a small-medium range (500 to 1300 mm width), used in small municipalities and industries with their water treatment plants. Standard production is made with frames in hot dip zinc coated carbon steel, rollers and tank in AISI 304 SS. On request, EDOM may be made entirely in AISI 304 SS or AISI 316 SS. Belt presses can be supplied with self cleaning nozzles system, making it possible the use of water from clarifiers.

  • Intereco - Model EDOM/L - Belt Filter Presses

    Intereco - Model EDOM/L - Belt Filter Presses

    EDOM/L Belt presses with a pre-gravity zone and a sludge turnover, in size from 500 to 1200 mm belts width. This model is particularly apt for sludge with a low solids content (below 1.5% SS). Achieved capacity increases are up to 50% compared to the same standard belt press EDOM.

  • Intereco - Model EDOM and CAB - Belt Presses

    Intereco - Model EDOM and CAB - Belt Presses

    After a twenty years long experience of units installed all over the World, INTERECO produce belt press to 3000 mm belts width. Apt for any type of sludge: Biological, chemical, paper milk dairy, inert and tanneries. To save money for the shipment, it is no necessary to use wood cages. For a belt press CAB 2000 is enough a 20” Flat Rack. Belt press EDOM and CAB 2500-3000 are divided in two parts, to be assembly in site. Also for these reasons,...

  • Electrocoagulation

  • Intereco - Electrocoagulation System

    Intereco - Electrocoagulation System

    INTERECO is introducing a new technology Electrocoagulation to remove as sludge both heavy metals and most organic compounds. It is, at last, the industrial realization of the laboratory theory consisting of having a current pass through wastewater to make the suspended solids and most dissolved salts react as normal flocculated sludge.

  • Reverse Osmosis and Ultrafiltration

    The newest technology for clarifying, concentrating separation of pollutants, or diluted substances, recoverable or undesiderable, organics and inorganics, in several uses.

  • Intereco - Model UF/NF/RO - Mobile Pilot Unit

    Intereco - Model UF/NF/RO - Mobile Pilot Unit

    Mobile plant for testing and working process definition in industrial waste waters. The unit has been designed to work in different conditions (UR, nano filtration, RO) both continuously and in batch (with tanks), analysing various parameters in all the steps of the process.

  • Intereco - Milk Concentration for Reverse Osmosis and Ultrafiltration

    Intereco - Milk Concentration for Reverse Osmosis and Ultrafiltration

    UF unit working in a cheese production process. In a single stage pass it concentrates milk, dividing it from the most aqueous part of whey (lactose and salts) retaining fats and proteins. In this case for Egypt, beside to the savings to have due to the volume reduction, the goal was to minimize salt content in the produced cheese. The unit can work both continuously and in the batch, with 2 mc/h feed and concentration ratio up to 75%. Normally or...

  • Intereco - Potable Water Reverse Osmosis System

    Intereco - Potable Water Reverse Osmosis System

    This unit for brackish well water has two pre treatment stages (sand filter and physical-chemical) and a RO pass, designed to produce 8 mc/h of potable water with a feed of 16 mc/h. It is completely automatic, with control on working parameters and chemicals dosing. Capacity: feed 16 mc/h, permeate 8 mc/h; brine 8 mc/h.

  • Intereco - UF Potabilization Unit

    Intereco - UF Potabilization Unit

    This unit has been designed to produce potable water from surface water (lake, river) removing color, turbidity, bacteria and microorganism. The UF system has been installed inside a container together with a diesel power unit. To be used as natural disasters emergency unit. Sold to a Norwegian company but with Chinese Army as end user.

  • Intereco - Demineralised Water Reverse Osmosis / Wastewater RO System

    Intereco - Demineralised Water Reverse Osmosis / Wastewater RO System

    Twin RO unit to produce demineralized water and to treat waste water in a aluminium anodization process. The first section produces water at 5 μS/cm from well water, for the final washing tank. The second purifies and recycles water coming from the various washing tanks. The two sections, both with a PLC can work separately or together.

  • Intereco - Waste Recycle and Demineralization RO Unit

    Intereco - Waste Recycle and Demineralization RO Unit

    In this process, rinse waters from a stainless steel etching process (with small capacity), the same unit is used for the two different purpose. Beside separating pollutants reducing the volume of waste to be disposed, recycle permeate as side effect quality of final product has been improved, not having any more stains due to salts in tap water. After the production period, the same unit, with working parameters changed by a PLC, produces enough...

  • Intereco - Ultrafiltration Unit

    Intereco - Ultrafiltration Unit

    Water coming from a frozen fish defrosting process is sent to a UF unit. Concentrate is all the organic part, while water and NaCl, permeate, are recycled. Besides volume reduction of waste, water recycling there is also the recovery of salt used in the process, which had to be added to tap water.

  • Intereco - Leachate Mobile Unit

    Intereco - Leachate Mobile Unit

    This unit has been assembled on a trailer to be used in two public landfills. The process is one chemical-physical unit (it could be UF), followed by two stages RO, due to the high concentration of pollutants. Completely automatic with PLC, to discharge in surface water.