sludge level News

  • Calculate Gallons of sludge in a Conical Bottom Circular Tank

    Explains basic formula format, discusses elements; Utilizes same basic formula as volume calculation of Tank and Cone, Explains difference of Side Wall Depth and Sludge Level, Converts Volume as Cubic Feet of Tan and Cone to Total Gallons and finally requests subscribing and interacting. View "Calculate Gallons of sludge in a Conical Bottom Circular Tank" Video on ...

  • Small But Nice: New IQ SENSOR NET for 2-4 Sensors

    Up to 4 sensors, up to 20 parameters The new controller is available as a 2- (DIQ/S 282) or 4-channel (DIQ/S 284) version. Besides the reagent free measurement of COD, all other common parameters can be measured. By the combination of multi-parameter sensors, up to 20 different values can be recorded and displayed. So everything is ready to monitor and control your small- or middle-size ...


    By WTW - a xylem brand

  • The New Radio Module MIQ/WL PS

    The right measurement at the right location – without cables, easy installed 1 Master, several Slaves – save costs with every additional measuring point Compatible for IQ Sensor Net System 182 and System 2020 With the wireless communication within the IQ Sensor Net you avoid to run long cables and enable the ideal measuring location for your sensors. For example, the sludge ...


    By WTW - a xylem brand

  • Small but nice: New IQ SENSOR NET for 2-4 sensors

    Up to 4 sensors, up to 20 parameters The new controller is available as a 2- (DIQ/S 282) or 4-channel (DIQ/S 284) version. Besides the reagent free measurement of COD, all other common parameters can be measured. By the combination of multi-parameter sensors, up to 20 different values can be recorded and displayed. So everything is ready to monitor and control your small- or middle-size ...


    By WTW - a xylem brand

  • Hach releases low-maintenance sludge blanket for level monitoring

    Hach’s SONATAX sc optimizes sludge extraction, manages recirculation, and warns of potential solids washouts that may result in costly permit violations. The SONATAX sc probe stays clean by using a magnetic coupled wiper that wipes the face of the probe. The wiper functions with a magnetic connection and without a shaft so there are no o-rings to replace and no need to open the probe housing. ...

  • Pulsar’s Sludge Finder 2 – twin channel, versatile interface measurement

    Remote measurement with Sludge Finder 2 means you can put an end to tedious, time consuming, potentially unhygienic and hazardous manual measurements using gap switches or vacuum tubes. Sludge Finder 2 is a major update to Pulsar’s successful Sludge Finder, designed to reliably measure interface levels in primary, secondary or tertiary sludge tanks and SBR systems. A twin channel device, Sludge ...


    By Pulsar Measurement

  • Hit Your Target!

    This hand-held sludge level detector helps eliminate unnecessary pumping/dredging of clarifiers, tanks and lagoons, and aids in monitoring sludge bed depth for regulatory compliance and prevention of carryover. It uses high-intensity infrared light to locate both sludge blanket and overlying cloudy layer. A thumb-adjustable sensitivity control allows users to detect silt/sludge/bio-solids in ...

  • Travels with Paul - Quarries and Wastewater Treatment Works

    We followed Paul’s visits in February so we could show you just what a Partech sales engineer does! The month started off in Romsey where Paul carried out a site survey at a very muddy quarry… Paul went to see if Partech could help with their flocculent dosing control. The Partech team are pretty certain they’ll be able to offer an excellent solution, but Paul went to lend a ...


    By Partech (Electronics) Ltd.

  • Sludge Monitors and the Top Three Ways they can Help your Business

    One of our recent blogs discussed how wastewater could be used to make money in treatment plants. As a result, we thought we’d take a look at the benefits of sludge monitors and how they can help your business in the water industry. We’ve listed our top three ways sludge blanket can help in the everyday treatment of water. Stop Sludge Escaping! By using one of the Partech 8100 ...


    By Partech (Electronics) Ltd.

  • Pulsar Sludge Finder 2`s, Wirelessly Helping with Final Treatment Compliance

    Pulsar have supplied 14 Sludge Finder 2 sludge blanket detectors to Severn Trent for their Barnhurst STW near Wolverhampton, automating the critical final treatment process to aid Compliance and reduce out of hours call-outs. On this large, well-established site, it would have been impossible to cable the units back to the control cabin, so Pulsar developed an integrated wireless system ...


    By Pulsar Measurement

  • Pulsar's Sludge Finder 2 the Clear Choice for Wessex Water

    Pulsar Process Measurement Ltd have been awarded a five-year exclusive framework contract to supply Wessex Water with Sludge Finder 2 Sludge Interface measurement equipment. Sludge Finder 2 uses an acoustic sonar technology to measure crucial sludge interface levels, drawing on Pulsar's knowledge of echo processing and analysis to identify the changes in density that represent the sludge ...


    By Pulsar Measurement

  • BiOWiSH™ reduces sludge and odor at Texas dairy

    June 30, 2011 For Immediate Release CHICAGO, IL - BiOWiSH™ Manure & Odor Treatment (Beef & Dairy) reduced sludge and odor during a recent case study at a Texas dairy farm. The owner of Wilhelmus Dairy began using the treatment because of concerns about odor and sludge content in the farm's primary lagoon. At the time treatment began, the sludge level in the lagoon was close to ...


    By BiOWiSH Technologies

  • Controlling Sludge in Lamella Clarifiers

    This month we are focusing on the control of sludge blanket build up in Lamella Clarifiers. Lamella Clarifiers, also known as Inclined Plate Separators (IPS) are in common use at Waste Water Treatment Sites as small footprint plant settlement units and are often employed in place of conventional settling tanks. Controlling Sludge Blanket Build up Effluent enters the Lamella Clarifier via an ...


    By Partech (Electronics) Ltd.

  • Pulsar's Sludge Finder 2 Helps Severn Trent to Generate Extra Electricity

    Pulsar Process Measurement have supplied eight Sludge Finder 2 sludge interface monitors to Severn Trent's Stoke Bardolph site as part of a process improvement project that has allowed the company to significantly increase electricity generation on site and return energy to the National Grid In common with many large sewage treatment works, Stoke Bardolph uses the gas produced in the digesters ...


    By Pulsar Measurement

  • SludgeWatch 715 Sludge Blanket Detector

    For our Partech instrument product focus this month, we’re looking at our portable 715 sludge blanket detector. It’s one of our most popular products with distributors all over the world and it’s not surprising as to why people like it so much… This little sludge blanket detector makes it really easy and cost effective to monitor sludge blanket levels in lots of ...


    By Partech (Electronics) Ltd.

  • Partech product focus – 740 Portable Suspended Solids Monitor

    This month we’re taking a closer look at our Partech 740 Portable Suspended Solids Monitor. Our portable products are incredibly popular and it’s no surprise why – not only are they highly accurate but they’re also incredibly easy to use! The 740 monitor is great at offering quick and accurate readings of suspended solids, sludge blanket levels, and turbidity. The robust ...


    By Partech (Electronics) Ltd.

  • 50 Years of WTW at the IFAT

    System 282/284 live and up close The presentation of our new system 282/284 was a complete success. The first hands-on experience for the visitors of our booth resulted in positive feedback throughout. The clear display, the easy menu guide and the standard integrated USB interface and internal data memory make this new monitor a highly sophisticated system. If you connect up to 4 sensors, a ...


    By WTW - a xylem brand

  • Sludge Blanket Monitoring Made Easy!

    At Partech we understand the need for simple, low cost methods for sludge blanket monitoring in a wide variety of settlement tanks. It its important to have reliable detection in order to de-sludge tanks at the most beneficial time, reducing costs and unnecessary work at a later stage in the cleaning process. A sludge interface that is too high can result in pollution incidents caused by ...


    By Partech (Electronics) Ltd.

  • 50 Years of WTW at the IFAT

    The history of the IFAT began in 1966 with 147 exhibitors and 10,200 visitors. 50 years later, these numbers are quite a bit more impressive: As a world fair for environmental technoloqy, the IFAT welcomed 138,000 visitors from 170 countries between May 30 and June 3. WTW was an exhibitor fifty years ago and has been every year since. In our booth, together with our sister company MJK under the ...


    By WTW - a xylem brand

  • How do you remove struvite?

    The photographs above demonstrates what can happen if you don’t control or remove struvite. This is a 14” diameter line used to transfer sludge from an anaerobic digester to a sludge holding pond. Every year this agency would mechanically clean this transfer line. However, every year plant operation notice that it took longer to transfer equivalent amounts of liquid from the ...


    By Jenfitch, LLC

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you