Techase Sludge Dryer - Multiple Heat Sources, Low Carbon, Smart
With the popularization of low temperature drying technology in the field of deep sludge dewatering, its market share has gradually expanded. However, subsequent problems are also increasingly prominent. The problems of single heat source, high electricity cost, no waste heat is available on site lead to the limitation of sludge resource disposal technology, and run counter to the purpose of energy conservation and emission reduction. In face of the problems, Techase has promoted new technology, sludge resource disposal + energy saving and emission reduction.
Solar Energy + Waste Heat Multiple Heat Sources
1.Solar clean energy is introduced, energy conservation and pollution reduction can be realized with strong environmental protection.
2.Multiple energy supplying ways with the same drying system (electricity / waste heat / solar energy) , wide range of application.
3.Compared to heat pump and waste heat drying system, lower operation cost, the saving energy ratio can be up to 30% ~ 50%.
4.The exchanging heat part has strong corrosion resistance and reliable & stable system.
5.Technical uniqueness. There is no other relevant products and technology in market.
Solar Energy Utilization System
Solar energy can be used directly and changed into hot water
1. Joint research and development with Tongji University and Shanghai Jiao Tong University, and the hot water temperature can be raised to 90℃.
2. Energy conversion efficiency is greater than 55%.
3. The Service life is more than 15 years.
4. It can be installed in workshop, pool, flat ground, etc.
Techase new technology -- low temperature drying not only completely realizes the goal of sludge reduction, harmless and resource utilization, but also carries out a breakthrough reform in the treatment process. The new technology saves energy to the greatest extent, meets the process requirements of energy saving and emission reduction, and reduces resource waste.
More information: firstname.lastname@example.org