CB Micro-Carbon II Series Filter Cartridges Brochure (PDF 117 KB)

CB MICRO-CARBON® II SeriesFilter CartridgesData Sheet 1656-CHigh Efficiency Carbon Block Filtration• Economical Alternative to Granular Activated CarbonCartridges• FDA Listed Materials Make this a Suitable Filter for FoodService Applications• High Porosity Design Maximizes Utilization of Carbon toPrevent Premature Plugging• Proprietary Manufacturing Process Yields a Filter withGreater Dirt Holding Capacity• DOE End Configuration• Absorbs Oil VaporTypical Performance SpecificationsFilter Grade1:5 µmInitial ? P (psi) @ Flow Rate (gpm):9 3/4" (24.8 cm)/10" (25.4 cm): 0.95 psid (.07 bar)@ 1 gpm (3.8 lpm)20" (50.8 cm): 0.85 psid (.06 bar)@ 2 gpm (7.6 lpm)Chlorine Reduction @ Flow Rate (gpm)2:9 3/4" (24.8 cm)/10" (25.4 cm): >6,000 gallons (22,713 l) @ 1 gpm (3.8 lpm)20" (50.8 cm): >12,000 gallons (45,425 l)@ 2 gpm (7.6 lpm)Maximum Operating Temperature:180°F (82.2°C)FDA Listed Materials:All polymeric materials are listed for food contact applicationsin Title 21 of the U.S. Code of Federal Regulations.Product SpecificationsMaterials of Construction:Filter Media: Bonded Porous Activated Carbon With Polyethylene Binders3End Caps: PolypropyleneInner/Outer Wraps: PolypropyleneNetting: PolyethyleneGaskets: Buna NDimensions (nominal):Outside Diameter: 2 7/10" (6.9 cm)Inner Diameter: 1" (2.5 cm)Lengths: 9 3/4" (24.8 cm), 10" (25.4 cm),20" (50.8 cm), 30" (76.2 cm)Liquid Flow Rate vs. Differential Pressure1 - Micron rating based on 85% or greater removal of a given particle size.Data obtained from actual particle counts using AC Fine Test Dust.2 - Chlorine reduction data is for 2 ppm free chlorine to <0.5 ppm.3 - Take binders into consideration when determining chemical compatibility.109876543210Differential Pressure (psid)Flow Rate (lpm)Flow Rate (gpm), Water at 68°F (20°C)0.60.40.20 BAR (x100 = kPa)0 10 20 30Flow rate is per 10" (25.4 cm) cartridge. For liquids other than water,multiply differential pressure by fluid viscosity (cP).1 2 3 4 5 6 7 8 9 105 µmVisit us on the Web at www.pall.com2200 Northern Boulevard.East Hills, New York 11548-1289 1.800.FILTERS toll free516.484.5400 phone516.484.3216 faxwww.pall.com webinformation@pall.com e-mailPall Corporation has offices and plants throughout the world in locations including: Argentina,Australia, Austria, Belgium, Brazil, Canada, China, France, Germany, Hong Kong, India, Indonesia,Ireland, Italy, Japan, Korea, Malaysia, Mexico, the Netherlands, New Zealand, Norway, Poland,Puerto Rico, Russia, Singapore, South Africa, Spain, Sweden, Switzerland, Taiwan, Thailand,United Kingdom, United States, and Venezuela. Distributors are located in all major industrialareas of the world.Bulletin #1656-2C 3/04© Copyright 2004, Pall Corporation. Pall, and and Micro-Carbon are trademarks of Pall Corporation. ® Indicates a Pall trademark registered in the USA. is a service mark of PallCorporation.ApplicationsOrganics Taste, Chlorine ParticulateOdor, Color RemovalWater:Drinking ? ? ? ?Bottle Washing ? ? ? ?Rinse Water ? ? ? ?Single Pass ? ? ? ?Recirculating Use Pre-filterChemicals:Single Pass ? ? ?Recirculating Use Pre-filterWARNING:Do not use with water that is microbiologically unsafe or of unknown quality without adequate disinfection before or after the system.NOTE:These cartridges contain a very small amount of carbon fines (very fine black powder). After installation, flush the cartridgefor a minimum of 5 minutes to remove all traces of the fines before using the water. You should run (flush) the tap at least 20seconds prior to using water for drinking or cooking purposes. This is particularly important if the tap has not been used daily.CAUTION:Filter must be protected against freezing, which can cause cracking of the filter and water leakage.Part Numbers/Ordering InformationC ? P – CB5 (e.g., C20P–CB5)Code Cartridge ? Lengths(nominal)9.75 9.75"10 10"20 20"30 30"