JUDO JU-WEL Amethyst - Single & Multi Unit Housing Operating Instructions- Brochure

Attention:Carefully read throulation and operatingand safety informatinstalling and puttinservice.These must alwaysthe owner/user.Extended warrantyod if a service agreis concludedJewel WaterAmethyst crystalssion, stress, restlessnInstallation and Operating InstructionsJUDO JU-WEL AmethystJewel Water Device ¾" – 1¼"Valid for: EU countries and Switzerlandgh the instal- instructions ion before g the unit into be issued to peri-ement : strengthen the general condition and relieve pain caused by nervousness, ten-ess and insomnia.Language: EnglishFig.: JUW-A ¾" – 1¼"2Queries, orders, customer supportJUDO Wasseraufbereitung GmbHP.O. Box 380D-71351 WinnendenG E R M A N YPhone: +49 (0)7195/6 92-0Telefax: +49 (0)7195/6 92-188internet: http://www.judo-online.dee-mail: info@judo-oAddressJUDO WasseraufbeHohreuschstrasse 3D-71364 WinnendeG E R M A N YTrademarks:Trademarks used in thand registered trademer.© JUDO WasseraufbeD-71351 WinnendenAll rights reserved.Reprints – even of extwith special approval.Dear CustomerWe would like to thank you for your con-fidence in us, which you have shown bypurchasing this device. The product youhave purchased is a JU-WEL water de-vice developed using state of the arttechnology.This JU-WEL water device is designedfor use with cold drinking water with amaximum water and environmental tem-JU-WEL Amethystnline.dereitung GmbH9-41nis document are protected arks of the respective hold-reitung GmbHracts – is only permitted perature of 30°C (8the mains flows thrter device and thethe amethyst crystthe drinking water.All the manufacturvices have been squality control meaery. In the event of ado not hesitate to ble customer suppoverleaf.6°F). The water fromough the JU-WEL wa- positive qualities ofals are transferred toed JU-WEL water de-ubjected to precisesures prior to deliv-ny difficulties, pleaseconsult the responsi-ort department. SeeJU-WEL Amethyst 3EC Conformity DeclarationZur Unterschrift an H.Söcknick, 22/01/044About this Operating InstructionsTable of Contents1. About These Operating Instructions41.1 Used Symbols ............................. 51.2 Safety Instructions and Dangers Caused by Non-observance ........ 51.3 Used Units ................................... 52. Manufacturer’s Specifications for Use62.1 Water Pressure............................ 72.2 Instructions Concerning Specific Dangers ....3. Product Inform3.1 Operation P3.2 Used Mate4. Installation .....4.1 General Inf5. Operation .......5.1 Putting into5.2 Description5.3 Revitalazat5.4 ModificatioSpare Part5.5 Interruption6. Defects ...........7. Maintenance...7.1 Cleaning ...7.2 Checking thElectronics8. Warranty and M9. Data Sheet.......9.1 Typ...........9.2 Models .....9.3 Technical D9.4 Assembly D9.5 Extent of S9.6 Accessorie10. Spare Parts JU1¼".................11. Customer SuppAnnex: Consultati1. About this Operating InstructionsATTENTION(See chapter on “Safety information anddangers due to non-compliance”)The operating instructions should always bestored at the operating location of the JewelJU-WEL Amethyst................................... 7ation .......................... 8urpose ...................... 8rials............................. 8.................................... 8ormation..................... 8.................................. 11 Operation................ 11 of Functions ............ 11ion ............................ 13ns / Amendments / s................................ 13s in Operation .......... 14.................................. 14.................................. 15................................. 15e Revitalization ................................. 15aintenance............. 15................................. 16.................................. 16.................................. 16ata........................... 16imensions ............... 17upply ........................ 17s ............................... 17-WEL Amethyst ¾" –.................................. 18ort ........................... 20on VoucherWater Device.These operating insto make it easier to bthe JU-WEL water dedevice in accordancer’s specifications.The operating instrucinformation on howWater Device in a saoperating instructiontions which are to bestallation, operation adevice. The observahelps to prevent dancosts, as well as to and lifespan of the JeThe operating instruand observed by all pwith the JU-WEL wat– installation– operation– maintenance (putting into operaAny installation and the device may only bnel authorised to do and capable of obseric instructions and reqassembly and operatIn addition to the opethe obliging regulatioprevention that exist tion and the locationtechnical regulationsprofessional work, shtructions are designedecome acquainted withvice and the use of thee with the manufactur-tions contain important to operate the Jewelfe and proper way. Thes contain basic instruc- observed during the in-nd maintenance of thence of the instructionsgers, to reduce repairincrease the reliabilitywel Water Device.ctions should be readersons that have to doer device, for example:servicing, inspection,tion)maintenance work one performed by person-so by the manufacturer,ving the country specif-uirements stated in theing instructions.rating instructions andns concerning accidentin the country of opera- of use, the established concerning safe andould also be observed.About this Operating InstructionsIt is therefore essential that these operating instructions be read by the installer, as well as the responsible technical staff / operator, prior to any installation, commissioning or maintenance work being performed.In addition to the general safety instruc-tions stated in the chapter on “IntendedUse”, the specific safety instructionsstated in the other chapters should alsobe observed1.1 Symbols uThe safety instructiostructions are emphing symbols:, Information which iWEL water device it– Direction of Flow– Type Designatio– Cleaning Instrucshould be clearly visserved.1.2 Safety information and dan-gers due to non-complianceThe non-observance of the general dangersymbols may for example result in the fol-lowing dangers:– Danger to persons caused by electricalor mechanical effects.– Danger to persons or the environmentcaused by leaks.ATTENTIONWarningageManufacfor TightOperatinmationFig. 1: Fitted RotatiJU-WEL Amethystsedns in these operating in-asized using the follow-s displayed on the JU-self, e.g.: (see Fig. 1)n Platetionsible and legible and ob-Any working methodsafety are to be avoidThe non-observanceinstructions and the scontained herein mapersons, as well as fothe Jewel Water Dev1.3 Used UnitsThe following units winternational systemtional) are used:Note Danger Electric Tension Volt-turer’s Specifications ening Torque.g Tips and Other Infor-ng FlangeUnit Convers°F °F = 9/5bar 1 bar = ¾" DN 201" DN 251¼" DN 325s that might endanger ed. of these operating afety instructions y result in dangers for r the environment and ice itself.hich are not part of the (SI = System Interna-ion°C + 32105 Pa = 0,1 N/mm²6Intended Use2. Intended UseThe installation and operation of the JewelWater Device is subject to the following ex-isting national regulations.In addition to the operating instructions andthe obliging regulations concerning accidentprevention that exist in the country of opera-tion and the location of use, the establishedtechnical regulations concerning safe andprofessional work, sThe water which ifulfil the requiremropean drinking wIt is absolutely essturer / supplier will boperation of the devferent quality, respcontains additives.This Jewel Water Dewith cold drinking water and environmen(86°F).The Jewel Water Doped and manufacart technology andregulations in GermThe Jewel Water Dated in accordancespecifications. Any otion beyond the specordance with the mtions.Additional dangers mthe device not beingwith the manufactunon-observance of safety instructions. plier cannot be madcaused by these adderator is responsibleThe use of the deviccustomer’s specificservance of the opeThe manufacturer / supplier should be con-sulted prior to any operation of the JewelWater Device other than in the operationalareas stated in these operating instructions.The Jewel Water Devices may only be oper-ated in a technically faultless condition, inaccordance with the manufacturer’s specifi-cations and the stated safety and danger rel-evant instructions and under observance ofthe operating instructionsJU-WEL Amethysthould also be observed.s to be treated shouldents stipulated by Eu-ater directivesential that the manufac-e consulted prior to anyice using water of a dif-ectively with water thatvice is designed for useter with a maximum wa-tal temperature of 30°Cevice has been devel-tured using state of the the established safetyany.evice may only be oper- with the manufacturer’sther operation or opera-cified use, is not in ac-anufacturer’s specifica-ay result in the event of operated in accordancerer’s specifications andthe danger symbols orThe manufacturer / sup-e liable for any damagesitional dangers. The op- for these risks. e in accordance with theations includes the ob-rating instructions.Any functional defeimmediatelycts are to be removedIntended Use2.1 Water pressureThe water pressure should be between 1.5bar and 10 bar.ATTENTION(See chapter on “Safety information anddangers due to non-compliance”)In the event of water pressure above 10bar, the pressure refitted in front of th(see Fig. 2). If theabove 10 bar, this ming operation.2.2 Notes on special dangers2.2.1 Electrical equipment / installa-tionsElectrical wiring and devices may not be sit-1 = Pressure ReductFig. 2: Pressure Reries in Front of the JewThe installaduction valwater presand 10 barElectrical wiring and devices may not be situated under or in the di-rect vicinity of the Jewel Water De-viceJU-WEL Amethystduction valve should bee JU-WEL water device operating pressure isay result in defects dur-uated under or in theWEL water device.Electrical devices / esplash-water proof anrect vicinity of the Jebe damaged by wateWater Device causedvice not being operathe manufacturer’s spIn addition this may aif these electrical devconnected to the elethe event of such caand may sustain elefore any electrical deated in the direct vicwater proof, respecstatutory requiremenion Valveduction Valve Fitted in Se-el Water Devicetion of a pressure re-ve is recommended for sures between 5 bar .7 direct vicinity of the JU-quipment that are notd are situated in the di-wel Water Device mayr leaking from the Jewel as a result of the de-ted in accordance withecifications.lso result short circuitsices / equipment beingctrical power supply. Inses persons are at riskctrical shocks. There-vices / equipment situ-inity should be splash-tively comply with thets for wet areas (IP44).8Product Information3. Product Information3.1 Intended purposeThe Jewel Water Device is designed for usewith cold drinking water with a maximum wa-ter temperature of 30°C (86°F).ATTENTION(See chapter on “Safety information anddangers due to nonFor restrictions regrefer to the chapter GS-ZeichenIn addition the Jebeen checked by tbeen marked with tsafety (see Fig. 3).3.2 Materials uThe used materials ical, chemical and cing water and haveance with DIN 196pressure resistancein accordance with cal standards. All srecommendations) cordance with the rBgVV (Federal InHealth Protection an4. Installation4.1 GeneralATTENTION(See chapter on “Safety information anddangers due to non-compliance”)The installation of the device may only beperformed by suitably qualified specialistAbb. 3: RWTÜVJU-WEL Amethyst-compliance”)arding operation pleaseon “Intended Use”.wel Water Device hashe RWTÜV, and it hashe GS-sign for checkedsedare resistant to the phys-orrosive factors in drink- been tested in accord-32 (static and dynamic). All materials are safehygienic and physiologi-ynthetic materials (KTWand metals are in ac-equirements set by thestitute for Consumerd Vetinary Medicine).personnel.It is absolutely essen“Intended Use” will bThe installation shouter [DIN 19632 respethe pressure reducerwater station, but bement units.The installation has ting to DIN 1988 / parA non-return valve apart 02 has to be insin the flow direction.The piping system onter Device is mountedport the weight of thwithout endangeringnon-observance mepiping system may oces. This may resucaused by the watehealth of persons in Jewel Water Device a result of the largetherefore essential thclamping will be provtem where necessaconvenient operationessential that the staserved.tial that the chapter one observedld occur behind the fil-ctively EN 13443] and or behind the domesticfore further water treat-o be carried out accord-t 04 or EN 1717. ccording to DIN 1988 /talled there before, andto which the Jewel Wa- should be able to sup-e Jewel Water Device safety. In the event ofchanical defects to thecur, including breakag-lt in damages beingr. In such cases thethe direct vicinity of themay be endangered as water quantities. It isat additional support orided for the piping sys-ry. In order to ensure and maintenance it isted clearances are ob-Installation4.1.1 Requirements for the place of installationThe location where the device is installedshould be dry and frost-proof Unauthor-ised persons should not be able to ac-cess the Jewel Water DeviceATTENTION(See chapter on “dangers due to non– The environmenexceed 30°C (8cessive temperadamage to mateing the breaking– An outlet controlfront of the Jeweables the water ing installation, work and in theJewel Water Deventive measuredamages to furnequipment. – The device canmercially availabsystems. – The installation vice in front of thden4.1.2 Installed pATTENTION(See chapter on “dangers due to nonThe Jewel Water Dinstalled in a vertica4.1.3 Mounting the Fitted Rotating FlangeThe installation should occur using the sup-plied fitted rotating flange.The fitted rotating flange is suitable for bothhorizontal as well as vertical piping systems.The fitted rotating flange should be in-stalled in the direction of the water flow.This is marked by the arrow (pleaseJU-WEL AmethystSafety information and-compliance”)tal temperature may not6°F) In the event of ex-ture or solar radiation,rials may result, includ- of the bell. valve should be fitted inl Water Device This en-supply to be shut off dur-maintenance and repair event of a defect in thevice. In addition this pre- prevents flooding anditure or other household be installed in all com-le drinking water pipingof the Jewel Water De-e water meter is forbid-ositionSafety information and-compliance”)evice should always bel position (± 5°)refere Fig.5).ATTENTION(See chapter on “Sdangers due to non-cThe flange surfaceflange should be in installation of the fitteposition prevents thchanical tensions Inservance mechanicacluding breakages ofthe fitted rotating fladamages being causIn such cases the hearect vicinity of the Jebe endangered as a quantities.It is therefore essenpiping system, the fitthe Jewel Water Devexcessive loads.9afety information andompliance”) of the fitted rotatinga vertical position. Thed rotating flange in thise occurrence of me- the event of non-ob-l defects may result, in- the piping system or ofnge. This may result ined by the water.lth of persons in the di-wel Water Device mayresult of the large watertial to ensure that theted rotating flange andice are not subjected to10Installation4.1.4 Installing the Jewel Water De-viceJU-WEL Amethyst ¾" – 1¼"The fitted rotating flaDevice is supplied The necessary seaJewel Water Devicmounted.Do not unscrew th– insert the four fthe bayonet drilling flange (see F– turn the Jewel Wwise direction as4) II.– tighten the four fATTENTION(See chapter on “Safety information anddangers due to non-compliance”)I IIFig. 4: Fitted RotatintureSelect the prox. 4Nm)tight and thnot damagJU-WEL Amethystnge for the Jewel Waterwith bayonet drill holes.ls and screws for thise have already beene screwslange screws M6x25 in holes on the fitted rotat-ig. 4) I.ater Device in a clock- far as it will go (see Fig.lange screws.The profile of the propoint towards the fitteis not the case leaksmay escape. This madamages to the hohousehold equipmeng Flange with Bayonet Fix-tightening torque (ap- in a way that the seal is e Jewel Water Device is ed or over tightenedFig. 5: Fitted Rotatinfile flange seal shouldd rotating flange. If this may result and watery result in flooding anduse, furniture or othert (see Fig. 5).g FlangeOperation5. OperationATTENTION(See chapter on “Safety information anddangers due to non-compliance”)It is essential that the chapter on “IntendedUse” are observed5.1 CommissioPrior to putting the Joperation (initial cointo operation after device should be filaired– the Jewel Waterter by opening thtrol valve after it– open the next taDevice to the lim– by opening the tflow through it thautomatically airRevitalization ElecThe cover in the e(3) contains an impIt revitalizes the amlight.Activation:– Lift the covecompartment (2the Jewel Water– Place the two sbattery compartcompartment. U– Insert the harmthe light pipe (4– Replace the cocompartment (2By pressing the swiis manually activatetals are automaticweek.5.2 Functional descriptionThe treated water flows through the fitted ro-tating flange into the Jewel Water Device.The water in the device flows into a contain-er with the specially pre-treated amethystcrystals.The energy and information is then trans-ferred from the crystals to the water and itbecomes Jewel water. The water thenleaves the device through the fitted rotatingJU-WEL Amethystningewel Water Device intommissioning or puttingmaintenance work), theled with water and then Device is filled with wa-e connected outlet con- has been installed.p after the Jewel Waterit.ap and allowing water toe Jewel Water Device ised.tronics:lectronics compartmentortant revitalization unit.ethyst crystals usingr of the electronics) on the bottom side of Device.upplied batteries in thement of the electronicsse 1.5 V microbatteries.onising light source into).ver of the electronics).tch (1) the revitalizationd. The amethyst crys-ally revitalized once aflange.The amethyst crysgeneral condition anby nervousness, tenness and insomnia. ment of the crystals etheir characteristic feflows past in a verywater thus becomes 11tals strengthen one’sd relieve pain causedsion, stress, restless-The special pre-treat-nables them to transferatures to the water that effective way and thejewelized water.12Operation1 Switch2 Cover ElectronicRevitalization EleCompartment3 Cover Electronic4 Light PipeFig. 6: Description o8910JU-WEL Amethysts Compartment with ctronics and Battery s Compartment5 Crystals (Amethyst Crystals)6 Transparent Hoop7 Cover8 Fitted Rotating Flange9 Water Inlet10 jewelized waterf Functions1276453Operation5.3 RevitalazationIn order to be able to maintain the effectivityof the crystals over a longer period, theyhave to be regenerated (= revitalize) at reg-ular intervals. The revitalization of the crys-tals occurs using a light and energy sourcewhich harmonises especially well with theamethyst crystals. This light and energysource automatically revitalizes the crystalsonce a week. This procedure lasts approxi-mately 10 minutes.The Jewel Water Dduring the revitalizathe device is constabe operated withoutIn addition to the the revitalization of tcur manually. In orswitch (1). In geneis not required, howdemonstration purpparticularly high wa5.3.1 RevitalizatThe revitalization the amethyst crystthat harmonises wit– the amethyst crrevitalized once switch (1) this cur manually.– empty batteriestime in order torevitalization.5.4 Modifications / changes / spare partsATTENTION(See chapter on “Safety information anddangers due to non-compliance”)Only original spare parts may be usedFor reasons of safety, modifications andJU-WEL Amethystevice continues to worktion of the crystals, thusntly in operation and can any interruptions.automatic revitalization,he crystals may also oc-der to do so, press theral manual revitalizationever this may occur foroses or in the event ofter consumption.ion Electronicselectronics regeneratesals using a light sourceh the crystals.ystals are automaticallya week. By pressing theprocedure may also oc- should be replaced in ensure the continuousamendments are forpair the functionality vice or lead to leakseven lead to the Jewing. The imprinted insonly valid if the devicoriginal spare parts.5.4.1 Servicing / – Prior to any work,eration, being peWater Device, thshould be pressunon-observance leaks may occurdamages to the hhousehold equipmthe instructions“Installation” andserved.13bidden These may im-of the Jewel Water De- and in extreme casesel Water Device burst-pection certificates aree is operated using theRepair other than ordinary op-rformed on the Jewele Jewel Water Devicere free In the event ofuncontrolled water causing flooding andouse, furniture or otherent. It is essential that in the chapters “Maintenance” be ob-14Faults5.5 StoppagesATTENTION(See chapter on “Safety information anddangers due to non-compliance”)In the event of having to disconnect theflanges or unscrew the Jewel Water Device,it is essential that the chapter on “IntendedUse” be observed– The flange surfaagainst damagefaces are no lonleaks may resules to the house, hold equipment.– Ensure that thefree of dirt In thvice, the dirt mcome into contacwhen the Jewel operation. The cwater may endpeople who drin– The Jewel Water Device should bestored in a frost-free area Frost maycause water which is in the cavities Jew-el Water Device to freeze. This may re-sult in mechanical defects to the JewelWater Device or leaks, or even causethe device to burst when operating pres-sure is restored. Water leaks may resultin flooding and damages to the house,furniture or other household equipment.Help with faults:FaultsThe energy sourcewhen the switch ofelectronics is appliThe seals on the Jare no longer tightThe bell is cloudyCracks in the bellJU-WEL Amethyst no longer lights the revitalization ed.The battery is empty. Rewel Water Device The Jewel Water De-vice has been exposed to excessive tempera-tures or come into con-tact with solvents.Ntseplace the batteries.otify the plumber or he nearest customer upport department.ces should be protected Damaged flange sur-ger a tight seals. Watert in flooding and damag-furniture or other house- Jewel Water Device ise event of dirt on the de-ay enter the device ort with the drinking waterWater Device is put intoonsumption of pollutedanger the health of thek the water.In addition persons in the direct vicinityof the Jewel Water Device may be in-jured by parts of the device if it bursts.– When putting the Jewel Water Deviceback into operation the same instruc-tions apply as for when a new Jewel Wa-ter Device is being put into operation. 6. FaultsIn order to ensure the safety of the deviceand the functionality of the seals, theopening of the device or the replacementof parts subject to water pressure mayonly be performed by qualified person-nel. Cause SolutionMaintenance7. MaintenanceATTENTION(See chapter on “Safety information anddangers due to non-compliance”)It is essential that the chapter on “IntendedUse” be observed7.1 CleaningATTENTION(See chapter on “dangers due to nonOnly clear drinkingclean the housingbell.Conventional houseglass cleaners may vents and/or alcohoThese substances actions with the sydevice and lead to breakages.It is therefore not aagents of this type7.2 Checking the Revitalization ElectronicsThe revitalization electronics can bechecked by applying the switch.– If the energizing diode lights up, then therevitalization electronics are functioningcorrectly and the batteries are still pow-erful enough to operate the revitalizationelectronics. This battery test does not inany way have an influence on the weeklyJU-WEL AmethystSafety information and-compliance”) water may be used to and the transparenthold cleaning agents orcontain up to 25% in sol-l (spirit).may cause chemical re-nthetic materials in theembrittlements or evenllowed to use cleaning.revitalization proc– If the energizing dthen the batteriewith new batterieReplacing the batte– Open the cover partment.– Replace the battepartment with id(AAA).– Replace the cocompartment.– Used batteries adistributor or to ocilities, establishthe public recyclin8. Warranty aIn order to ensure yclaims, it is required in accordance with Dperformed every 3 toon the level of waterethyst crystals shouyears.15edure.iode does not light up,s have to be replaceds.ries:of the electronics com-ries in the battery com-entical type batteriesver of the electronicsre to be returned to ane of the returning fa-ed to this purpose byg entities.nd Servicesour statutory warrantythat a visual inspection,IN 1988, section 8, be 6 months, depending consumption. The am-ld be replaced every 516Data Sheet9. Data Sheet9.1 TypJU-WEL Amethyst Jewel Water DeviceAbbreviated name: JUW-A9.2 Models9.3 Technical The following applithe device:– Pressure loss: with the nomina– Maximum enviroperature: 30°C (– The water whicto correspond EG issued by quality of wateconsumption [as to the decrnewal of the nance in date o– Threaded conneDIN 2999The nominal pressure refers to the pressurestage according to which the JUW-A waterdevice has to fulfil the requirements of DIN19632.Model Bestell-Nr.JUW-A ¾"JUW-A 1"JUW-A 1¼"JUW-A with JQR¾"Model Operating pressureNominal pressureJUW-A¾" – 1¼"1,5 – 10 bar PN 10JU-WEL Amethystspecificationses for all the models of0.35 bar in accordancel flow ratenmental and water tem-86°F)h is to be treated hasto the directive 98/83/ the Council for ther destined to human03rd 11, 1998] as wellee concerning the re-drinking water ordi-f 21st May, 2001.ction in accordance with801 2501801 2502801 2503- 1¼" 801 2505ModelJUW-A ¾"JUW-A 1"JUW-A 1¼" JUW-A ¾" - 1¼"ModelNomFlowup toJUW-A ¾" 3,3 mJUW-A 1" 4,5 mJUW-A 1¼" 5,5 mWeight3,2 kg3,5 kg4,0 kg4,5 kginal Rate Pressure at Nominal Flow Rate³/h 0,35 bar³/h 0,35 bar³/h 0,35 barData Sheet9.4 Installed dimensionsA = Installation lengB = Height under thC = Height above thD = DepthE = Width9.5 Scope of supply– Pre-installed Jewel Water Device– Installation and Operating Instructions– Fitted rotating flangeJQE ¾", 1" or 1¼" with bayonet fixture and screw connection– 2 x microbatteries with electronic memory system (AAA)Fig. 7: All DimensioModel AJUW-A ¾" 180JUW-A 1" 195JUW-A 1¼" 230All dimensions in [mJU-WEL Amethystthe centre of the pipee centre of the pipe9.6 Accessorie– JUDO JQR expaOrder no. 825 00nection of two deter treatment sysnsB C D E 105 280 170 130105 280 170 130105 280 180 130m] (see Fig. 7)17snsion quickset41 for the series con-vices, e.g. filter and wa-tem.18Spare Parts JU-WEL Amethyst ¾" – 1¼"10. Spare Parts JU-WEL Amethyst ¾" – 1¼"JU-WEL AmethystSpare Parts JU-WEL Amethyst ¾" – 1¼"List of Spare Parts JU-WEL Amethyst ¾" – 1¼"Pos.Designation(Recommended average replacement interval for wearable parts [*])Piece(s) Order No. VE1)/Piece1 Cover 1 2010312 182 Complete Plug 1 2010331 103 O-ring 18 x 2.2 ***** 1 1200195 14 Lens metal screw 3.5 x 13 2 1607114 15 Cover 1 2010325 456 Bottom7 O-ring 90 x 48 Inserted floor9 Spacing pipe11 Gem housing12 Flange ring13 Cylinder screw14 Casing top pa15 Adjusting ring16 O-ring 10 x 317 Complete ligh18 Light charger,19 Lens metal sc20 Microbattery 121 Light charger,22 Locking ring23 Lampe de rev24 Crystals (ame25 Profile flange 26 Cylinder screw27 Protection dev1) VE = Unit of BReplacement interval* = 1 year***** = 5 yearsExtended warranty JU-WEL Amethyst 191 2010308 210***** 1 1120333 91 1120595 351 1440163 151 2010324 1981 2010313 103 M6x40 6 1650123 3rt 1 2010314 451 1120585 8***** 2 1120332 2t pipe 1 2010319 39 complete 1 2010316 29rew 2.9 x 32 2 1650350 2.5 V * 2 1500202 4 blue 1 1500289 58***** 1 1650351 1italisation 1 2010317 12thyst crystals) ***** 2010330 106seal 1 1200218 5 M6x25 4 2010199 2ice 1 2270004 40illingperiod if a maintenance agreement is concluded20 JU-WEL AmethystCustomer Support11. Customer SupportAll the illustrations, dimensions and information for the different models are those valid on the date ofprinting. All rights are reserved for modifications as a result of technical progress or further develop-ments. Claims with regard to models or products are excluded.1701263 • 2005/04JUDO Wasseraufbereitung GmbHPostfach 380 • D-71351 WinnendenTel. +49 (0)7195/6 92-0 • Fax: +49 (0)7195/6 92-188e-mail: info@judo-online.de • www.judo-online.deJUDO France S.à.r.L76 Rue de la Plaine des Bouchers • Technosud • F-67100 StrasbourgTel. +33 (0)3 88 65 93 94 • Fax +33 (0)3 88 65 98 49e-mail: info@judo.fr • www.judo.frJUDO BeNeLuxKerkstraat 1 / 1 Rue de l'Eglise • B-1780 WemmelTel. +32 (0)24 60 12 88 • Fax +32 (0)24 61 18 85e-mail: info@judo-online.be • www.judo-online.beJUDO AustriaUnter den Linden 32 • A-2000 StockerauTel. +43 (0)2266 / 6 40 78 • Fax +43 (0)2266 / 6 40 79e-mail: info@judo-online.at • www.judo-online.atInstalled by:JUDO HEIFI-TOPHeating and rinse filter for the removal of sludge and gas deposits. Ideal in combination with JUDO HEIFI-Fül.JUDO HEIFi-FÜLAutomatic heating after supply station for compli-ance with DIN EN 1717, ideal in combination with JUDO HEIFI-TOPJUDO Domestic Water PROmiRinse protective filter with JUDO ROFI-PLUS technology, pressu-re reduce and backflow preven-ter.JUDO ZEWA Water StopCentral water safety fitting. Stops water flow in the event of water pipe bursts and de-tects leaks.JUDO BIOSTAT 2000Alternative water treatment against limescale deposits without any subsequent costs, without the need to replace the cartridges. Installation and Operating Instructions JUDO JU-WEL Amethyst Jewel Water: 1. About this Operating Instructions 1.1 Symbols used 1.2 Safety information and dangers due to non-compliance 1.3 Used Units 2. Intended Use 2.1 Water pressure 2.2 Notes on special dangers 2.2.1 Electrical equipment / installations 3. Product Information 3.1 Intended purpose 3.2 Materials used 4. Installation 4.1 General 4.1.1 Requirements for the place of installation 4.1.2 Installed position 4.1.3 Mounting the Fitted Rotating Flange 4.1.4 Installing the Jewel Water Device 5. Operation 5.1 Commissioning 5.2 Functional description 5.3 Revitalazation 5.3.1 Revitalization Electronics 5.4 Modifications / changes / spare parts 5.4.1 Servicing / Repair 5.5 Stoppages 6. Faults 7. Maintenance 7.1 Cleaning 7.2 Checking the Revitalization Electronics 8. Warranty and Services 9. Data Sheet 9.1 Typ 9.2 Models 9.3 Technical specifications 9.4 Installed dimensions 9.5 Scope of supply 9.6 Accessories 10. Spare Parts JU-WEL Amethyst ½"–1¹" 11. Customer Support