ALTRU-V - V-Strike Series - UVC Lamp and Fixture System - Brochure

vb:uv_>• Waterproof NEMA 3 design for outdoor locations• Heavy gauge steel, tamper-resistant enclosure• Installs easily and safely into “through the wall” and “rooftop” units up to 10 tons• Maintains AHU capacity to optimal operating condition with near original equipment capacities • Lowers energy costs for most systems• Reduces costly maintenance and cleaning programs• With short paybacks, the V-Strike has one of the lowest ownership costs in the industry • Improves indoor air quality by destroying surface microbes that grow in and on coils and drain pans, including mold and bacteria• Helps to reduce infectious disease microbes including colds, flu, and other viruses• UV has proven effectiveness on Mycobacterium tuberculosis (TB), Legionella pneumophila (Legionnaire’s disease), and other infectious bacteria• Produces no ozone, gases, or other noxious fumes – will not harm building occupants, equipment or furnishings• ALTRU-V™ Lamps have the lowest output loss in the industry (over their operating life)• Fixtures are UL/C-UL Listed under Category Code ABQK (Accessories, Air Duct Mounted), UL Standards: 153, 1598 & 1995 respectively• One-year warranty on both the fixture and the lamp• Replace lamps just once a year. Lamp change-out can take less than 5 minutesUNLEASH THE POWER OF THE VALTRU-V products from UVDI are transforming HVAC maintenance. By applyingreal science and the relentless cleaning power of ultraviolet light, ALTRU-V products are the optimal HVAC maintenance solution, replacing outdatedmechanical and chemical cleanings that can be both costly and dangerous. The results are lower operating costs, safer lamp change-outs for maintenancepersonnel, and cleaner air. The V-Strike™ delivers UVC energy through a supported lamp design, allowing for maximum application flexibility in systems ofup to 10 tons, either side mount or top mount. Its NEMA rated housing providesreliable outdoor installs for all applications. The V-Strike installs easily into“through the wall” or “rooftop” designs from outside the unit, so there is no needto open or compromise the equipment. EXTERNAL SYSTEM-MOUNTULTRAVIOLET FIXTUREV-Strike Series Provides Cleaner Air and Greater Safety WhileAlso Delivering Significant Increased Operating EfficienciesModel No. VS-XSVS-XT VS-32-T5VS-28-T5 VS-15-PLLDescription V-Strike™ XS, 120/240V-Single Ended Fixture (Side Mount)V-Strike™ XT, 120/240V-Single Ended Fixture (Top Mount)V-Strike™ XS/XT, 32" New/Replacement LampV-Strike™ XS/XT, 28" New/Replacement LampV-Strike™ XS/XT, 15" New/Replacement LampPart Number18-205018-205118-500018-500118-5002Nom.Dim.32.5"28.5"15"Electrical 120Vac/240Vac, 60 Hz, .7A/.4A120Vac/240Vac, 60 Hz, .7A/.4A---Weight7 Lbs.6 Lbs.5 Lbs.4 Lbs.2 Lbs.REPRESENTED BY:SPECIFICATIONSUVC Lamp and fixture are factoryassembled and tested. They consist of ahousing, power source, one piece steelsupported lamp and connector. All com-ponents are constructed to withstandtypical HVAC environments. They areUL/C-UL Listed under Category CodeABQK (Accessories, Air Duct Mounted),UL Standards: 153, 1598 & 1995respectively.Housing is constructed of 16-gauge,powder-coated steel and is equippedwith 3/4" electrical knockouts on allaccessible sides to facilitate wiring toA/C power. Fixtures may be used asside (XS) or top (XT) mount as requiredor as shown on the plans. Each fixtureincorporates all components into oneintegral assembly that maximizes service-ability. Fixtures shall be designed to bemounted outdoors or where necessary.Power Source is an electronic, highfrequency, rapid-start type with overloadprotection. Its standard power switchingcapability allows for 120/240Vac wiringand is designed to maximize photon production, radiance and reliability andshall be UL/C-UL Listed for temperaturesof 55-135° F. It includes RF and EMIsuppression.Lamp Assembly and MountingThe UV lamps are mounted in a sturdyand easy to handle assembly whichmounts quickly (1/2 turn) into a speciallydesigned socket within the enclosure.An integral plug provides power. Thisprovides a very sturdy mount that allowsfor quick lamp changes. Lamp and Connector are integratedinto one unit that includes a steelsupport to protect the lamp before, during and after its installation andoperation. The bayonet style lampincludes a rotational mounting and locking connector knob (with light pipe)that accepts lamp power via a safetyplug from the power source. The lamps0 medium bi-pin types for the VS-32-T5and VS-28-T5. The VS-15-PLL type is abi-axial, T5 diameter twin-tube type. Bothlamps have their pins isolated from theair stream. Each achieves the specifiedoutput at 500 fpm in air temperatures of55-135º F. They produce no ozone orother secondary contamination.Independent Testing: ALTRU-V systems have been independently testedto verify conformance to UL/C-UL perCategory Code ABQK (Accessories, AirDuct Mounted) and UL Standards: 153, 1598 & 1995 respectively. The health aspects associated with theuse of this product and its ability to aidin the disinfection of environmental airhave not been investigated by UL.XS: SIDE MOUNTXT: TOP MOUNT1. Strike Bulb Lengths: 32.5”, 28.5” and 15”. 2. Glow Light “ON” Indicator without lamp removal. 12ALTRU-V (A Division of UVDI)26145 Technology DriveValencia, CA 91355Tel 877-PUREUVC (877-787-3882)Tel 661-295-8140Fax 661-257-4698www.altruv.comSpecifications subject to change without notice.V-Strike XS (Side Mount). Not pictured: XT (Top Mount) also available.V-Strike XT (Top Mount)V-Strike XS (Side Mount)TM 2003 UVDI. ALTRU-V and V-Strike are trademarks owned by UVDI. 21-1001 rev 2 6/03