CMC Solutions, LLC articles

Capacity: 400,000 Barrels per day
A major oil and gas operator in KSA contracted CMC to deliver and certify 4 PEMS for compliance on their refinery stacks. A SmartCEMS PEMS was started-up to record the operating and emission data in June of 2013 for all of the units. The data acquisition system consisted of a data historian integrated with the DCS. The system utilizes the signal from the gas flow monitor and other boiler parameters and the results of test data to calcula

Capacity: 100 kpph
An Automotive Power Plant owns and operates three boilers in the powerhouse at their 902 E. Leith Street facility in Flint, Michigan. All three boilers combust exclusively pipeline quality natural gas to generate steam that is used at the site for process and space heating purposes. All three boilers have a rated capacity of 100,000 lbs per hour steam output. The exhaust gas stream is discharged to the atmosphere from each boiler through a separate sta

CMC Solutions, LLC. was retained by a chemical plant in the Michigan to install and evaluate a Predictive Emission Monitoring System (PEMS) under 40 CFR Part 75, Subpart E as an alternate monitoring system under Title IV of the Clean Air Act. The PEMS software (SmartCEMS with Data eLements) was installed onsite for predictive models for continuous monitoring on two units. One of these boiler units is monitored under Part 75.

The required 720 hours of data was collected during the f

CMC Solutions, LLC. was retained by a chemical plant in the Michigan to install and evaluate a Predictive Emission Monitoring System (PEMS) under 40 CFR Part 75, Subpart E as an alternate monitoring system under Title IV of the Clean Air Act. The PEMS software (SmartCEMS with Data eLements) was installed onsite for predictive models for continuous monitoring on two units. One of these boiler units is monitored under Part 75.

The required 720 hours of data was collected during the firs

Capacity: 500,000 Barrels per day
A major oil and gas operator in UAE contracted CMC to deliver and certify 28 PEMS and 3 CEMS along with a mobile CEMS for compliance on their refinery stacks. A SmartCEMS PEMS was started-up to record the operating and emission data in September of 2008 for all of the units. A data acquisition system was provided by Honeywell Xceed and was started-up to record the operating and emission data in the October of 2012. The DAS collects the p

Capacity: 56.2 MW
A major oil and gas operator in Norway owns and operates five turbines located off the coast of Norway in the North Sea. Turbines JA-001 and JA-002 operate at 23 MW and dire on fuel gas, and turbines RI101, RI-102, and RI-103 operate at 5300 kW and also fire on fuel gas.

The turbines are operated in accordance with the framework permit regulations specified for the individual sites by the Norwegian Environmental agencies. The units are requir

Capacity: 500MW
A major power generator in Malaysia owns and operates two turbines operating in Malaysia. The turbines, GT1A and GT2A, are gas fired and both have an operating capacity of 250MW. Two SmartCEM 60 Analyzers were installed to determine the effectiveness of PEMS as an alternative to CEMS for gas turbines.

A study was conducted to determine which parameters would be suitable for inputs and outputs. After two rounds of testing a short list of 100 parame

Capacity: 45 MW
A Saudi Arabian Methanol Plant owns and operates seven gas-fired boilers in three plants onsite at their facility in Al Jubail, Saudi Arabia. The units are designated 620A, 620B, and 620C for the utility boilers. The site has two boilers designated 3620A and 3620B and two boilers designated 4620A and 4620B. The utility boilers fire fuel gas exclusively and the other boilers fire fuel gas and waste alcohol. The exhaust gas stream is discharged to the atmos

Capacity: 100 mmBTU
An energy company owns and operates a combustion process at an ethanol processing facility in Denison, Iowa. The ethanol process combusts exclusively pipeline natural gas to drive a 100 mmBTU heat recovery steam generator (HRSG) for production of steam used in the distilling process. The exhaust gas stream is discharged to the atmosphere and emissions are monitored using a PEMS and a data acquisition system under the requirements of 40 CFR Part 60.